EOC 12-inch L/23.5

Last updated
EOC 12-inch L/23.5
Thirty nine ton breech loading gun 1877.jpg
As depicted in March 1877
Type Naval artillery
Place of origin United Kingdom
Service history
Used byNone (prototype)
Production history
Designer Elswick Ordnance Company
ManufacturerElswick Ordnance Company
Produced1877
No. built1
Specifications
Mass39 long tons (40 t)
Length282 inches (7.16 m) L/23.5

Caliber 12 inches (30.5 cm)
Muzzle velocity 1,650 feet per second (500 m/s)

The EOC 12-inch L/23.5 or '39-ton breechloading gun' or '40-ton breechloading gun', was an experimental breechloading gun designed and manufactured by the Elswick Ordnance Company also known as Armstrong. The gun was made to profit from recent discoveries about how gunpowder behaved. These required longer guns and made muzzleloading troublesome. The gun seems to have been a failure.

Contents

Context

The 12.5-inch 38-ton RML

The development of the EOC 12-inch L/23.5 gun, took place at about the same time as experiments with a muzzle-loading gun of almost the same weight, the RML 12.5-inch 38-ton gun. This was basically a RML 12-inch 35-ton gun that had been given a slightly higher caliber and was significantly lengthened to make better use of new kinds of gunpowder. Initial results were very good. [1] In October 1876, the 12.5-inch 38-ton RML was then tested against armor at Shoeburyness. With a charge of 130 pounds (59 kg), a 800 pounds (360 kg) Palliser shell was fired. It went through the target, which consisted of 19.5 inches (500 mm) of iron and 10 inches (250 mm) of teak. Velocity was estimated at 1,420 feet per second (430 m/s). This was again a very good result and plans were made to widen the chamber of the gun. [2]

At the time, 'chambering' a gun meant that its chamber got a diameter that was significantly wider than its caliber. For the 12.5-inch gun this resulted in a chamber diameter of 14 inches (35.6 cm). A test in March 1877 (i.e. after the below test of our L/25.5 gun) proved that this allowed an increased charge of 200 pounds (91 kg) of pebble powder. The projectile weighed 812 pounds (368 kg), of which 12 pounds (5.4 kg) was the gas check. With regard to loading the gun through the muzzle, there were challenges. The first charge could not be rammed down and had to be blown out. The second charge could not be fit in the chamber and stuck out a bit, which negatively impacting the velocity. This was still 1,540 feet per second (470 m/s). [3] The gun later reached 1,560 feet per second (480 m/s) with an 812 pounds (368 kg) projectile. [4]

The new Armstrong breechloading system

Meanwhile, the Elswick Ordnance Company (EOC) had been working on creating a new breechloading mechanism. This was based on the interrupted screw system used by the French navy. The obturation method differed. For this the EOC used a steel cup or saucer attached to the end of the breech screw. When the charge exploded, it expanded this cup, which then came to fit on a copper ring in the chamber, forming a seal against escaping gas. [5]

Development of the EOC 12-inch L/23.5

Development

Development of the EOC 12-inch L/23.5 started in 1875. [6] It weighed about the same as the RML 12.5-inch 38-ton gun. However, its length of bore of 264 inches (6.7 m) or L/22 showed that it was based on very different ideas than those behind the RML 12.5-inch 38-ton gun with its length of bore of only 198 inches (5.0 m) or L/16. The similarity between the charges of the guns was as deceiving as their weight. In February 1877 (below), the EOC gun fired with a charge of 180 pounds (82 kg), one month later the chambered Woolwich gun fired with a charge of 200 pounds (91 kg) (above).

The deceivingly similar charges can be explained by the fact that it was possible to chamber the RML 12.5-inch 38-ton gun without changing the rest of the gun. [7] On the other hand, the EOC gun could get a longer chamber, because its longer barrel was able to 'consume' the energy of slower burning gunpowder. Both circumstances led to the EOC gun using a high charge without chambering the gun. I.e. the EOC 12-inch L/23.5 was not chambered. [8]

Tested near Elswick

In February 1877, the EOC 12-inch L/23.5 and a smaller 4.75 inches (121 mm) EOC gun were tested at the Elswick proof ground, some forty miles north of Newcastle. [9] Among those present were: General Campbell, director-general of Artillery and Stores; Colonel Younghusband, Superintendant of the Royal Gun Factory; the naval attachés of: France, Austria-Hungary, Russia, Italy, Brazil; Captain Jessen Director of Danish Naval Ordnance; Captain Müllertz sent by Denmark; Captain Garcia of the Spanish Naval Commission; as well several others. [10]

The tests involved three shots with the 12-inch L/23.5 with measurements of velocity and peak gas pressures. The projectile that was fired weighed 700 pounds (320 kg). With a charge of 160 pounds (73 kg) velocity measurement failed, peak pressures were 15.0 tons per square inch (2,286 atm) at the top of the chamber and 15.1 tons at the bottom. With a charge of 170 pounds (77 kg), velocity was 1,563 feet per second (476 m/s) and pressures were 17.1 at the top and 18.3 ton at the bottom. With a 180 pounds (82 kg) charge, velocity was 1,615 feet per second (492 m/s) and pressures were 18.6 at the top and 18.7 ton per square inch (2,850 atm) at the bottom. [5] One can compare these results with the test of the Krupp 30.5 cm MRK L/25 in 1878.

As the news showed, the tests were not only about the power of the gun, but also about using the Armstrong breech on heavy guns. After the test, it was said that this 'worked perfectly, the breech being easily opened without assistance of any sort, by one man, and with great rapidity. The escape of gas was entirely prevented'. [5]

The results were very promising. However, they said nothing about the endurance of the gun or the breech. For that a durability test (prolonged firing) was required. [9]

Quickly becomes obsolete

Shortly after 1878, the British War Office received an official comparison of guns with a caliber of about 12-inch. The comparison had been brought about by Krupp successfully testing three heavy artillery pieces in Meppen in July 1878. The Krupp 30.5 cm MRK L/25 was important for the report. The EOC 12-inch L/23.5 was also mentioned, as were a French 12.6 inch 38-ton breechloader, an Italian breechloader, and a 12-inch Russian one of 40-tons. The overview concluded that the short, but chambered RML 12.5-inch 38-ton gun mark II made by the Royal Arsenal, was the most powerful of these guns. [4] I.e. considered only in terms of the energy given to the projectile, the chambered muzzle-loading gun triumphed over 'long guns' like the EOC 12-inch L/23.5.

Meanwhile, smaller guns that were both chambered and long had been made. An August 1878 overview of powerful modern British guns mentioned an Elswick breechloading gun of 6-inch which fired a 70 pounds (32 kg) projectile with the enormous speed of 2,000 feet per second (610 m/s). It also mentioned an Elswick 8-inch 11.5 tons gun firing a 180 pounds (82 kg) projectile with the same velocity. [11]

It was a matter of time before heavier guns would become both chambered and long. During the August 1879 Meppen tests, Krupp demonstrated its prototype 24 cm MRK L/25.5 of 18 ton. It created a sensation, because it was just as powerful as the above 12-inch guns. Only the most recent British guns, like: The BL 9.2-inch Mk I – VII naval gun then under development; the EOC 8-inch 11.5-ton gun; and the EOC 9-inch 18-ton gun, were of comparable efficiency. [12]

When both developments, i.e. the need for longer guns and the advantages of 'chambering' a gun, became clear, the British artillery establishment had to change its stance on breechloading. An obvious reason to do this was that muzzleloaders longer than the 38-ton gun could not be handled in existing works, because they had to be brought in to reload. [13]

Within a few years of first getting tested, the EOC 12-inch L/23.5 had become obsolete because it was not chambered and was not very long. However, this was not the end of the story. A somewhat later lecture about the Meppen tests primarily focused on a comparison between the 40 cm MRK L/25 and the Elswick 100-ton gun. In the audience Stuart Rendel then referrred to the EOC 12-inch L/23.5 breechloader made almost five years earlier. [14]

Characteristics

Labels

On the 1877 engraving, the gun is called a 39-ton gun. Later on, it was called a 40-ton gun, because this was more convenient. [15] [10]

Technical

The 12-inch L/23.5 had a caliber of 12 inches (30.5 cm). The barrel had a length of 282 inches (7.16 m) or L/23.5 with a length of bore of 264 inches (670.6 cm) or L/22. The gun weighed 39 long tons (40 t). There were 45 grooves of the polygroove type. The twist rate was progressive, increasing from L/100 to L/45, meaning that at the muzzle, the projectile made a turn on its axis every 45 feet (14 m). [5] (Really every 45 calibers, with the caliber happening to be one foot)

The gun fired a 700 pounds (320 kg) projectile. This used copper driving bands and a copper centration bourrelet. The driving band was an attached gas-check, which was pushed into the grooves by the force of the explosion. With charges of 170 pounds (77 kg) and 180 pounds (82 kg) of pebble powder, this reached a mean velocity of 1,606 feet per second (490 m/s) and 1,650 feet per second (500 m/s). [5]

Notes

  1. The Engineer XL 1875, p. 212.
  2. The Engineer XLII 1876, p. 260, 269.
  3. The Engineer XLIII 1877, p. 193.
  4. 1 2 Brassey 1882, p. 94.
  5. 1 2 3 4 5 The Engineer XLIII 1877, p. 203.
  6. Rendel 1875, p. 51.
  7. Inglis 1878, p. 200.
  8. King 1881, p. 463.
  9. 1 2 The Engineer XLIII 1877, p. 134.
  10. 1 2 Army and Navy Gazette 1877, p. 118.
  11. Inglis 1878, p. 199.
  12. Simpson 1880, p. 730.
  13. Inglis 1880, p. 182-184.
  14. Orde Brown 1881, p. 72, 79.
  15. Nostrand's 1877, p. 478.

Related Research Articles

<span class="mw-page-title-main">RBL 7-inch Armstrong gun</span> 1861 British coast defence gun

The Armstrong RBL 7-inch gun, also known as the 110-pounder, was a heavy caliber Armstrong gun, an early type of rifled breechloader.

<span class="mw-page-title-main">100-ton gun</span> Naval gun

The 100-ton gun was the heaviest gun of the world for quite some time and got a lot of media attention. It was a 17.72-inch (450 mm) rifled muzzle-loading (RML) gun made by Elswick Ordnance Company, the armaments division of the British manufacturing company Armstrong Whitworth, owned by William Armstrong. The 15 guns Armstrong made were used to arm two Italian battleships and, to counter these, British fortifications at Malta and Gibraltar.

<span class="mw-page-title-main">BL 12-inch Mk I – II naval gun</span> Naval gun

The BL 12 inch naval gun Mk I was a British rifled breech-loading naval gun of the early 1880s intended for the largest warships such as battleships and also coastal defence. It was Britain's first attempt to match the large guns being installed in rival European navies, particularly France, after Britain transitioned from rifled muzzle-loading guns to the modern rifled breech-loaders somewhat later than the European powers.

<span class="mw-page-title-main">RML 16-inch 80-ton gun</span> Naval gun

RML 16-inch 80-ton guns were large rifled muzzle-loading guns intended to give the largest British battleships parity with the large guns being mounted by Italian and French ships in the Mediterranean Sea in the 1870s.

<span class="mw-page-title-main">RML 9-inch Armstrong Gun</span> Naval gun

The RML 9-inch Armstrong Gun was a rifled muzzle loading gun, used in substantial numbers by the Dutch navy, the Spanish Navy, and other navies. It should not be confused with the RML 9-inch 12-ton gun, used in the British Royal Navy.

<span class="mw-page-title-main">RML 7-inch Armstrong Gun</span> Naval gun

The RML 7-inch Armstrong Gun was a rifled muzzle loading gun. It was an export version of the British Royal Navy's RML 7-inch gun. The RML 7-inch Armstrong Gun was produced by William Armstrong's Elswick Ordnance Company.

<span class="mw-page-title-main">24 cm K L/20</span> 1867 German Navy rifled breech loader

The 24 cm K L/20 was a 24 cm caliber Krupp gun which was the first heavy Ring Kanone or built-up gun used by Germany. It was a rifled breech loader with a Krupp cylindroprismatic sliding breech and a Broadwell ring.

<span class="mw-page-title-main">30.5 cm MRK L/22</span> 1876 Krupp rifled breach loader gun

The 30.5 cm Mantel Ring Kanone L/22 was a 30.5 cm 22 caliber long Krupp Mantel Ring Kanone (MRK). It was a rifled breech loader built-up gun with a Krupp cylindroprismatic sliding breech. It was a further development of the earlier 30.5 cm RK L/22 that Krupp had developed and exhibited at the 1873 Vienna World's Fair.

<span class="mw-page-title-main">30.5 cm MRK L/25</span> 1880 coastal artillery by Krupp

The 30.5 cm Mantel Ring Kanone L/25 was a 30.5 cm 25 caliber long Krupp Mantel Ring Kanone. It was a further development of the earlier 30.5 cm MRK L/22. It came in different models. The Chinese Navy used the gun on board the Dingyuan-class ironclads. The Dutch Army used one of these models as coastal artillery. Due to changes in the interior configuration of the gun, this was basically a shorter version of the 30.5 cm MRK L/35.

<span class="mw-page-title-main">30.5 cm MRK L/35</span> 30.5 cm 35 calibre long Krupp gun

The 30.5 cm Mantel Ring Kanone L/35 was a 30.5 cm 35 caliber long Krupp gun. It was a further development of the earlier 30.5 cm MRK L/22. There were multiple models: The early model was basically a lengthened 30.5 cm MRK L/22. The later model had a heavier barrel and used a heavier charge for a higher muzzle velocity.

<span class="mw-page-title-main">35.5 cm MRK L/22.5</span> 1875 rifled breech loader gun by Krupp

The 35.5 cm Mantel Ring Kanone L/22.5 was a 35.5 cm 22.5 caliber long Krupp Mantel Ring Kanone (MRK). It was a rifled breech loader built-up gun with a Krupp cylindroprismatic sliding breech. It was exhibited at the 1876 Centennial Exposition and then bought by Russia. Meanwhile, another gun was sent to Turkey, which made it part of the Fortifications of the Dardanelles.

<span class="mw-page-title-main">35.5 cm MRK L/25</span> 1878 Krupp breech loader naval artillery

The 35.5 cm Mantel Ring Kanone L/25 was a 35.5 cm 25 caliber long Krupp Mantel Ring Kanone (MRK). It was a rifled breech loader built-up gun with a Krupp cylindroprismatic sliding breech. It was one of the few Krupp breechloaders that was designed to profit from slower burning gunpowders, but not for using very long projectiles. The gun was used by Denmark.

<span class="mw-page-title-main">15 cm MRK L/30</span> Weapon

The 15 cm Mantel Ring Kanone L/30, known as 15 cm Kanone L/30 was a 15 cm 30 caliber long Krupp Mantel Ring Kanone (MRK). It was a rifled breech loader built-up gun with a Krupp cylindroprismatic sliding breech. It was based on the later models of the 15 cm RK L/26, a 15 cm MRK L/28, and a 15.24 cm predecessor. This predecessor was the first of a new series of 30 and 35 caliber long guns that Krupp made to profit from a slower burning gunpowder invented in the early 1870s.

<span class="mw-page-title-main">15 cm MRK L/35</span> Weapon

The 15 cm Mantel Ring Kanone L/35, known as 15 cm Kanone L/35 was a 15 cm 35 caliber long Krupp Mantel Ring Kanone (MRK). It was very similar to the related 15 cm MRK L/25 and 15 cm MRK L/30, and the somewhat later 15 cm MRK L/40. Like these, it was a rifled breech loader built-up gun with a Krupp cylindroprismatic sliding breech.

<span class="mw-page-title-main">15 cm MRK L/40</span> Weapon

The 15 cm Mantel Ring Kanone L/40 or 15 cm Kanone L/40 was basically a rare, slightly longer version of the 15 cm MRK L/35. It was a long rifled breech loader built-up gun with a Krupp cylindroprismatic sliding breech. Shortly after its introduction, Krupp introduced quick-firing guns of 15 cm caliber, making the 15 cm MRK L/40 practically obsolete.

<span class="mw-page-title-main">40 cm MRK L/25</span> Weapon

The 40 cm Mantel Ring Kanone L/25, was a 40 cm 25 caliber long Krupp Mantel Ring Kanone (MRK). It was a high caliber, but in restrospect comparatively short, rifled breech loader built-up gun with a Krupp cylindroprismatic sliding breech.

<span class="mw-page-title-main">40 cm MRK L/35</span> Weapon

The 40 cm Mantel Ring Kanone L/35, was a 40 cm 35 caliber long Krupp Mantel Ring Kanone (MRK). It was a super heavy gun built for the defense of the Italian naval base of La Spezia, where four guns were placed in armored cupolas. It was transported by a special railway carriage. For some time it was the heaviest gun of the world.

<span class="mw-page-title-main">24 cm MRK L/25</span> Weapon

The 24 cm MRK L/25 known in the Netherlands as 24 cm lang 25 was a 24 cm 25 caliber long Dutch coastal gun built by Krupp. It was a rifled breech loader built-up gun with a Krupp cylindroprismatic sliding breech. It included some significant innovations and its prototype appeared at the 1876 Centennial Exposition in Philadelphia.

<span class="mw-page-title-main">24 cm MRK L/30</span> German naval gun

The 24 cm MRK L/30 was a Krupp naval gun developed in the early 1880s. Together with the 24 cm K L/35, it implemented the ideas of using higher charges and longer projectiles for the Krupp 24 cm caliber.

<span class="mw-page-title-main">24 cm MRK L/25.5</span> German naval gun

The 24 cm MRK L/25.5 was a Krupp prototype naval gun developed in the late 1870s. It was one of two guns that Krupp made to test the application of scientific discoveries with regard to gunpowder. These discoveries made it possible to use higher charges by enlarging the chamber of the gun. During an August 1879 test in Meppen, the gun pierced 51 cm of armor. This test prompted the last competitors to switch to steel guns and breech loading.

References