Double-hulled tanker

Last updated February 11, 2024

Plan of a double-hulled tanker

A double-hulled tanker refers to an oil tanker which has a double hull. They reduce the likelihood of leaks occurring compared to single-hulled tankers, and their ability to prevent or reduce oil spills led to double hulls being standardized for oil tankers and other types of ships including by the International Convention for the Prevention of Pollution from Ships or MARPOL Convention.^[1] After the Exxon Valdez oil spill disaster in Alaska in 1989, the US government required all new oil tankers built for use between US ports to be equipped with a full double hull.

Reasons for use

A number of manufacturers have embraced oil tankers with a double hull because it strengthens the hull of ships, reducing the likelihood of oil disasters in low-impact collisions and groundings over single-hull ships.^[2] They reduce the likelihood of leaks occurring at low speed impacts in port areas when the ship is under pilotage. Research of impact damage of ships has revealed that double-hulled tankers are unlikely to perforate both hulls in a collision, preventing oil from seeping out. However, for smaller tankers, U-shaped tanks might be susceptible to "free flooding" across the double bottom and up to the outside water level each side of the cargo tank. Salvors prefer to salvage doubled-hulled tankers because they permit the use of air pressure to vacuum out the flood water.^[2] In the 1960s, collision proof double hulls for nuclear ships were extensively investigated, due to escalating concerns over nuclear accidents.^[3]

The ability of double-hulled tankers to prevent or reduce oil spills led to double hulls being standardized for other types of ships including oil tankers by the International Convention for the Prevention of Pollution from Ships or MARPOL Convention.^[1] In 1992, MARPOL was amended, making it "mandatory for tankers of 5,000 dwt and more ordered after 6 July 1993 to be fitted with double hulls, or an alternative design approved by IMO". However, in the aftermath of the Erika incident of the coast off France in December 1999, members of IMO adopted a revised schedule for the phase-out of single-hull tankers, which came into effect on 1 September 2003, with further amendments validated on 5 April 2005.^[4]

After the Exxon Valdez oil spill disaster, when that ship grounded on Bligh Reef outside the port of Valdez, Alaska in 1989, the US government required all new oil tankers built for use between US ports to be equipped with a full double hull.^[5] However, the damage to the Exxon Valdez penetrated sections of the hull (the slops oil tanks, or slop tanks) that were protected by a double bottom, or partial double hull.^[6]

Maintenance issues

Although double-hulled tankers reduce the likelihood of ships grazing rocks and creating holes in the hull, a double hull does not protect against major, high-energy collisions or groundings which cause the majority of oil pollution, despite this being the reason that the double hull was mandated by United States legislation.^[7] Double-hulled tankers, if poorly designed, constructed, maintained and operated can be as problematic, if not more problematic than their single-hulled counterparts.^[2] Double-hulled tankers have a more complex design and structure than their single-hulled counterparts, which means that they require more maintenance and care in operating, which if not subject to responsible monitoring and policing, may cause problems.^[2] Double hulls often result in the weight of the hull increasing by at least 20%,^[3] and because the steel weight of doubled-hulled tanks should not be greater than that of single-hulled ships, the individual hull walls are typically thinner and theoretically less resistant to wear. Double hulls by no means eliminate the possibility of the hulls breaking apart. Due to the air space between the hulls, there is also a potential problem with volatile gases seeping out through worn areas of the internal hull, increasing the risk of an explosion.^[8]

Although several international conventions against pollution are in place, as of 2003 there was still no formal body setting international mandatory standards, although the International Safety Guide for Oil Tankers and Terminals (ISGOTT) does provide guidelines giving advice on optimum use and safety, such as recommending that ballast tanks are not entered while loaded with cargo, and that weekly samples are made of the atmosphere inside for hydrocarbon gas.^[2] Due to the difficulties of maintenance, ship builders have been competitive in producing double-hulled ships which are easier to inspect, such as ballast and cargo tanks which are easily accessible and easier to spot corrosion in the hull.^[2] The Tanker Structure Cooperative Forum (TSCF) published the Guide to Inspection and Maintenance of Double-Hull Tanker Structures in 1995 giving advice based on experience of operating double-hulled tankers.^[9]

Related Research Articles

The Exxon Valdez oil spill was a major environmental disaster that made worldwide headlines in the spring of 1989 and occurred in Alaska's Prince William Sound on March 24, 1989. The spill occurred when Exxon Valdez, an oil supertanker owned by Exxon Shipping Company, bound for Long Beach, California, struck Prince William Sound's Bligh Reef, 6 mi (9.7 km) west of Tatitlek, Alaska at 12:04 a.m. The tanker spilled approximately 10.8 million US gallons (260,000 bbl) of crude oil over the next few days.

The International Maritime Organization is a specialised agency of the United Nations responsible for regulating shipping. The IMO was established following agreement at a UN conference held in Geneva in 1948 and the IMO came into existence ten years later, meeting for the first time on 17 March 1958. Headquartered in London, United Kingdom, IMO currently has 175 Member States and three Associate Members.

<span class="mw-page-title-main">Oil spill</span> Release of petroleum into the environment

An oil spill is the release of a liquid petroleum hydrocarbon into the environment, especially the marine ecosystem, due to human activity, and is a form of pollution. The term is usually given to marine oil spills, where oil is released into the ocean or coastal waters, but spills may also occur on land. Oil spills may be due to releases of crude oil from tankers, offshore platforms, drilling rigs and wells, as well as spills of refined petroleum products and their by-products, heavier fuels used by large ships such as bunker fuel, or the spill of any oily refuse or waste oil.

The Exxon Valdez was an oil tanker that gained notoriety after running aground in Prince William Sound, spilling its cargo of crude oil into the sea. On 24 March 1989, while owned by the former Exxon Shipping Company, captained by Joseph Hazelwood and First Mate James Kunkel, and bound for Long Beach, California, the vessel ran aground on the Bligh Reef, resulting in the second largest oil spill in United States history. The size of the spill is estimated to have been 40,900 to 120,000 m³. In 1989, the Exxon Valdez oil spill was listed as the 54th-largest spill in history.

The International Convention for the Prevention of Pollution from Ships, 1973 as modified by the Protocol of 1978, or "MARPOL 73/78" is one of the most important international marine environmental conventions. It was developed by the International Maritime Organization with an objective to minimize pollution of the oceans and seas, including dumping, oil and air pollution.

The Oil Pollution Act of 1990 (OPA) was passed by the 101st United States Congress and signed by President George H. W. Bush. It works to avoid oil spills from vessels and facilities by enforcing removal of spilled oil and assigning liability for the cost of cleanup and damage; requires specific operating procedures; defines responsible parties and financial liability; implements processes for measuring damages; specifies damages for which violators are liable; and establishes a fund for damages, cleanup, and removal costs. This statute has resulted in instrumental changes in the oil production, transportation, and distribution industries.

A double hull is a ship hull design and construction method where the bottom and sides of the ship have two complete layers of watertight hull surface: one outer layer forming the normal hull of the ship, and a second inner hull which is some distance inboard, typically by a few feet, which forms a redundant barrier to seawater in case the outer hull is damaged and leaks.

<i>Prestige</i> oil spill 2002 environmental disaster off the coast of Galicia, Spain

The Prestige oil spill occurred off the coast of Galicia, Spain in November 2002, caused by the sinking of the 26-year-old, structurally deficient oil tanker MV Prestige, carrying 77,000 tonnes of heavy fuel oil. During a storm, it burst a tank on 13 November, and French, Spanish, and Portuguese governments refused to allow the ship to dock. The vessel subsequently sank on 19 November, about 210 kilometres (130 mi) from the coast of Galicia. It is estimated that it spilled 60,000 tonnes or a volume of 67,000 m³ (17.8 million US gal) of heavy fuel oil.

Ship grounding or ship stranding is the impact of a ship on seabed or waterway side. It may be intentional, as in beaching to land crew or cargo, and careening, for maintenance or repair, or unintentional, as in a marine accident. In accidental cases, it is commonly referred to as "running aground".

An oil tanker, also known as a petroleum tanker, is a ship designed for the bulk transport of oil or its products. There are two basic types of oil tankers: crude tankers and product tankers. Crude tankers move large quantities of unrefined crude oil from its point of extraction to refineries. Product tankers, generally much smaller, are designed to move refined products from refineries to points near consuming markets.

The Coulombi egg tanker is a design that is aimed at reducing oil spills. It was approved by the International Maritime Organization (IMO) as an alternative to the double hull concept. The United States Coast Guard does not allow this design to enter US waters, effectively preventing it from being built.

Oil tankers generally have from 8 to 12 tanks. Each tank is split into two or three independent compartments by fore-and-aft bulkheads. The tanks are numbered with tank one being the forwardmost. Individual compartments are referred to by the tank number and the athwartships position, such as "one port", "three starboard", or "six center."

The environmental effects of shipping include air pollution, water pollution, acoustic, and oil pollution. Ships are responsible for more than 18% of nitrogen oxides pollution, and 3% of greenhouse gas emissions.

All cargo vessels where MARPOL Convention is applicable must have an oil record book in which the officer responsible will record all oil or sludge transfers and discharges within the vessel. This is necessary for authorities to be able to monitor if a vessel's crew has properly disposed of their oil discharges at sea.

Oil spill governance in the United States is governed by federal law.

The Prince William Sound Regional Citizens' Advisory Council is an independent non-profit organization based in Anchorage and Valdez, Alaska, whose mission is to promote the environmentally-safe operation of the Alyeska Pipeline's Valdez Marine Terminal and associated oil tankers, and to inform the public of those activities.

Marpol Annex I is the first implementation made by Marpol 73/78, one of the most important international marine environmental conventions. The convention was designed to minimize pollution of the seas from ships. The objective of the convention is to preserve the marine environment through the complete elimination of pollution by oil and other harmful substances and the minimization of accidental discharge of such substances. The Marpol Annex I began to be enforced on October 2, 1983, and it details the prevention of pollution by oil and oily water.

A variety of factors affect the water and marine life along the coastline of Lebanon. These factors include marine pollution, environmental impact of shipping, oil spills, noxious liquid substances spills, sewage spills, and the dumping of radioactive and medical waste. Despite being a hotspot for marine life within the Mediterranean, the Lebanese watershed and coastline is home to very high levels of pollution that threaten the human, animal, and plant life that rely upon it.

The International Convention for the Prevention of Pollution of the Sea by Oil (OILPOL) was an International Treaty signed in London on 12 May 1954. It was updated in 1962, 1969, and 1971. OILPOL was subsumed by the International Convention for the Prevention of Pollution from Ships (MARPOL) in 1973.

Southeast Asia is home to a diverse marine environment. The region is host to extensive coral reefs, mangroves and seagrass beds, and has even been described as the Amazon rainforest of the ocean. The region is estimated to contain approximately 35% of the world’s mangrove species and over 45% of the world’s seagrass species.. The shipping industry has multiple damaging impacts on marine habitats and wildlife, such as pollution from port actives, oil spills ballast and bilge discharge, waste dumping from ships and direct physical impact from grounding and anchor damage.

References

1 2 Chircop, Aldo E.; Lindén, Olof (2006). Places of Refuge for Ships: Emerging Environmental Concerns of a Maritime Custom. Martinus Nijhoff Publishers. p. 194. ISBN 90-04-14952-X.
1 2 3 4 5 6 "Double Hull Tankers – Are They the Answer?" (PDF). CEIDA. Archived (PDF) from the original on 2012-04-17. Retrieved 18 September 2014.
1 2 Okumoto, Yasuhisa; Takeda, Yu; Mano, Masaki; Okada, Tetsuo (25 March 2009). Design of Ship Hull Structures: A Practical Guide for Engineers. Springer Science & Business Media. p. 108. ISBN 978-3-540-88445-3.
↑ "Construction Requirements for Oil Tankers". International Marine Organization (IMO). Archived from the original on 25 June 2012. Retrieved 18 September 2014.
↑ Faure, Michael G.; Hu, James (1 January 2006). Prevention and Compensation of Marine Pollution Damage: Recent Developments in Europe, China and the US. Kluwer Law International. p. 14. ISBN 978-90-411-2338-1.
↑ Skinner, Samuel K.; Reilly, William K. "The Exxon Valdez Oil Spill" (PDF). US Federal report. Archived from the original (PDF) on 15 April 2012. Retrieved 18 September 2014.
↑ Devanney, Jack (2006). The Tankship Tromedy, The Impending Disasters in Tankers (PDF). CTX Press, Tavernier, Florida. ISBN 0-9776479-0-0. Archived (PDF) from the original on 2008-07-08. Retrieved 18 September 2014.
↑ World in Transition: New structures for global environmental policy. Earthscan. 2001. p. 34. ISBN 978-1-85383-852-1.
↑ Marine Board; Transportation Research Board (2 October 2001). Environmental Performance of Tanker Designs in Collision and Grounding: Method for Comparison – Special Report 259. National Academies Press. p. 128. ISBN 978-0-309-55033-8.

External links

Media related to Double-hulled tanker at Wikimedia Commons

This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.

[ChircopLindén2006-1] 1 2 Chircop, Aldo E.; Lindén, Olof (2006). Places of Refuge for Ships: Emerging Environmental Concerns of a Maritime Custom. Martinus Nijhoff Publishers. p. 194. ISBN 90-04-14952-X.

[CEIDA-2] 1 2 3 4 5 6 "Double Hull Tankers – Are They the Answer?" (PDF). CEIDA. Archived (PDF) from the original on 2012-04-17. Retrieved 18 September 2014.

[OkumotoTakeda2009-3] 1 2 Okumoto, Yasuhisa; Takeda, Yu; Mano, Masaki; Okada, Tetsuo (25 March 2009). Design of Ship Hull Structures: A Practical Guide for Engineers. Springer Science & Business Media. p. 108. ISBN 978-3-540-88445-3.

[4] "Construction Requirements for Oil Tankers". International Marine Organization (IMO). Archived from the original on 25 June 2012. Retrieved 18 September 2014.

[FaureHu2006-5] Faure, Michael G.; Hu, James (1 January 2006). Prevention and Compensation of Marine Pollution Damage: Recent Developments in Europe, China and the US. Kluwer Law International. p. 14. ISBN 978-90-411-2338-1.

[6] Skinner, Samuel K.; Reilly, William K. "The Exxon Valdez Oil Spill" (PDF). US Federal report. Archived from the original (PDF) on 15 April 2012. Retrieved 18 September 2014.

[7] Devanney, Jack (2006). The Tankship Tromedy, The Impending Disasters in Tankers (PDF). CTX Press, Tavernier, Florida. ISBN 0-9776479-0-0. Archived (PDF) from the original on 2008-07-08. Retrieved 18 September 2014.

[8] World in Transition: New structures for global environmental policy. Earthscan. 2001. p. 34. ISBN 978-1-85383-852-1.

[BoardBoard2001-9] Marine Board; Transportation Research Board (2 October 2001). Environmental Performance of Tanker Designs in Collision and Grounding: Method for Comparison – Special Report 259. National Academies Press. p. 128. ISBN 978-0-309-55033-8.

[1]

[2]

[3]

[4]

[5]

[6]

[7]

[8]

[9]