A rollover or overturn is a type of vehicle crash in which a vehicle tips over onto its side or roof. Rollovers have a higher fatality rate than other types of vehicle collisions. [1]
A rollover or overturn is a type of vehicle crash in which a vehicle tips over onto its side or roof. Rollovers have a higher fatality rate than other types of vehicle collisions. [1]
Vehicle rollovers are divided into two categories: tripped and untripped. Tripped rollovers are caused by forces from an external object, such as a curb or a collision with another vehicle. Untripped rollovers are the result of steering input, speed, and friction with the ground. [2] Trailers that are not roll-coupled (i.e. those that use a trailer coupling rather than a fifth wheel) are more prone to rolling as they do not have the tractor unit or prime mover for additional stability.
Untripped rollovers occur when cornering forces destabilize the vehicle. As a vehicle rounds a corner, three forces act on it: tire forces (the centripetal force), inertial effects (the centrifugal force), and gravity. The cornering forces from the tire push the vehicle towards the center of the curve. This force acts at ground level, below the center of mass. The force of inertia acts horizontally through the vehicle's center of mass away from the center of the turn. These two forces make the vehicle roll towards the outside of the curve. The force of the vehicle's weight acts downward through the center of mass in the opposite direction. When the tire and inertial forces are enough to overcome the force of gravity, the vehicle starts to turn over.
The most common type of tripped rollover in light passenger vehicles occurs when a vehicle is sliding sideways, and the tires strike a curb, dig into soft ground, or a similar event occurs that results in a sudden increase in lateral force. The physics are similar to cornering rollovers. In a 2003 report, this was the most common mechanism, accounting for 71% of single-vehicle rollovers. [3]
Another type of tripped rollover occurs due to a collision with another vehicle or object. These occur when the collision causes the vehicle to become unstable, such as when a narrow object causes one side of the vehicle to accelerate upwards, but not the other. Turned down guard rail end sections have been shown to do this. A side impact can accelerate a vehicle sideways. The tires resist the change, and the coupled forces rotate the vehicle. In 1983, crash tests showed that light trucks were prone to rolling over after colliding with certain early designs of guide rail. [4]
A rollover can also occur as a vehicle crosses a ditch or slope. Slopes steeper than 33% (one vertical unit rise or fall per three horizontal units) are called "critical slopes" because they can cause most vehicles to overturn. [5] A vehicle may roll over when hitting a large obstacle with one of its wheels or when maneuvering over uneven terrain. A trailer jackknife can push the towing vehicle into a rollover scenario if the vehicle is subject to a tripped scenario (soft ground or a curb).
Strong winds may cause high-sided vehicles such as trucks, buses and vans to be blown over. [6] Risk areas are coastal roads, plains and exposed bridges. [7] Vehicles exiting a wind shadow can be subjected to instant gusts that can affect high-sided vehicles.
All vehicles are susceptible to rollovers to various extents. Generally, rollover tendency increases with the height of the center of mass, narrowness of the axle track, steering sensitivity, and increased speed.
The rollover threshold for passenger cars is over 1 g of lateral acceleration. The Tesla Model S has an unusually low rollover risk of 5.7% due to its low center of mass. [8] [9] Light trucks will roll over at lateral accelerations of 0.8 to 1.2 g. Large commercial trucks will roll at lateral accelerations as low as 0.2 g [10] Trucks are more likely to roll over than passenger cars because they usually have taller bodies and higher ground clearance. This raises the center of mass.
SUVs are prone to rollover, especially those outfitted with long travel off-road suspensions. The increased suspension height for increased clearance off-road raises the center of mass.
Full-size vans don't usually have off-road suspensions, but their increased body height makes them more prone to tip. Fifteen passenger vans such as the Ford E-Series (at 27.9% [11] ), are particularly notorious for rolling over because their height is increased by the heavy-duty suspensions necessary to carry large numbers of people. The rollover tendency is increased when the vehicles are heavily loaded. It is recommended to not load anything on the roof of such vans, and to use drivers experienced or trained in safe operation of the vehicle. In such cases, familiarity with the vehicle's behavior loaded and unloaded, avoiding sudden swerving maneuvers, and reducing speed through tight turns can greatly decrease the rollover risk associated with these vehicles.
Manufacturers of SUVs often post warnings on the driver's sun-visor. Among the vehicles which have received publicity for tendencies to roll over are the Ford Bronco II, Suzuki Samurai, Jeep CJ, Mitsubishi Pajero/Montero, and Isuzu Trooper.
Military vehicles have a much wider wheel track than civilian SUVs, making them more difficult to roll over. However, IEDs in Iraq and Afghanistan cause roll overs not seen by civilian vehicles. The top turret gunner is particularly vulnerable. [12]
A tall passenger coach made US headlines when 15 passengers were killed in New York in 2011. The bus swerved, flipped on its side and hit a pole which split off the top of the vehicle. [13]
Vehicles sold in the United States, sorted by risk as evaluated by the U.S. National Highway Traffic Safety Administration. Click <> to sort by other parameters.
| Year [N 1] | Manufacturer | Model | Roll-over risk [N 2] | Grip g [N 3] | CoG height [N 4] | Produced [N 5] | Type | Seats | Comment |
|---|---|---|---|---|---|---|---|---|---|
| 2011 | Chevrolet | Tahoe | 24.6% [14] | 0.79 [15] | SUV | 8 | |||
| 2011 | Ford | F-150 | 19.8% [16] | 0.71 [17] | Truck | 4 | |||
| 2013 | Toyota | Hilux | 19.1% [18] | 5 million until 2009 [19] [20] | Truck | 4 | Also named Tacoma | ||
| 2011 | Audi | Q7 | 18.5% [21] | 0.85 [22] | SUV | 4 | |||
| 2013 | Mercedes-Benz | M-Class | 17.9% [23] | SUV | 5 | ||||
| 2013 | Volvo | XC90 | 17.9% [24] | 0.77 [25] | SUV | 5 or 7 | |||
| 2013 | BMW | X5 | 17.4% [26] | 1 million until 2010 [27] | SUV | 5 | |||
| 2013 | Lexus | RX | 16.4% [28] | SUV | 5 | ||||
| 2012 | Chrysler | Town & Country | 16.4% [29] | Minivan | ? | ||||
| 2013 | Toyota | Sienna | 14% [30] | Minivan | 7 or 8 | ||||
| 2011 | Toyota | Prius | 12.1% [31] | 0.79 [32] | 3-4 million until 2014 [33] | 4 | Hybrid | ||
| 2011 | Chevrolet | Impala | 11.3% [34] | Sedan | 4 | ||||
| 2014 | Mercedes-Benz | E-Class | 9.9% [35] | 0.87 [36] | Sedan | 4 | |||
| 2011 | Chevrolet | Volt | 9.4% [37] | 93,000 until 2015 [38] | 4 | Hybrid | |||
| 2011 | BMW | 535 | 9.3% [39] | 5 million until 2009 [40] | Sedan | 4 | |||
| 2013 | Chevrolet | Camaro | 8.7% [41] | 0.98 [42] | Coupe | 4 | |||
| 2013 | Tesla Motors | Model S | 5.7% [8] | 0.92 [43] | 18 in (46 cm) | 100,000 until 2016 [44] | Sedan | 5 or 7 | Electric |
After a rollover, the vehicle may end up lying on its side or roof, often blocking the doors and complicating the escape for the passengers. Large passenger vehicles such as buses, trams, and trolley buses that have doors on one side only usually have one or more methods of using windows for escape in case of a rollover. Some have special windows with handles to pull so that windows can be used as an emergency exit. Some have tools for breaking the windows and making an improvised exit. Some have emergency exit door or hatches in their roofs or on the opposite side of the bus to the usual entry door. Some combine two or more of these escape methods.[ citation needed ]
Rollover crashes are particularly deadly for the occupants of a vehicle when compared to frontal, side, or rear crashes, because in normal passenger vehicles, the roof is likely to collapse in towards the occupants and cause severe head injuries. [45] The use of roll cages in vehicles would make them much safer, but in most passenger vehicles their use would cut cargo and passenger space so much that their use is not practical. The Jeep Wrangler, a vehicle which is short, narrow, and designed to be used on uneven terrain, is unusual in that it comes with a roll bar as standard equipment.[ citation needed ]
The decline in popularity of convertibles in the US was partly caused by concern about lack of protection in rollover accidents, because most convertibles have no protection beyond the windshield frame. Some convertibles provide rollover protection using two protruding curved bars behind the headrests. Some Mercedes-Benz convertibles have a retractable roll bar which deploys in case of an accident. Race cars almost always have roll cages, since racing is very likely to result in a rollover. In addition, the roll cage's chassis-stiffening effect is usually seen as a benefit to the car.[ citation needed ]
Some countries have a unique sign warning of curves and other areas with an increased danger of rollover for trucks and other vehicles with high centers of gravity. These signs may include an advisory safe speed to avoid rolling over. This speed is typically set by measuring a maximum g-force permitted around the corner to remain well under the maximum static roll threshold. [46]
In the UK, the "adverse camber" plate comes with a warning sign such as "roundabout ahead", "bend ahead", "junction on (...) a bend ahead", or "series of bends ahead". [47]
In most European countries the official accident statistics contain no information on rolling cars, only Great Britain can deliver official statistical data. Regarding other sources, only a few accident databases on rollover accidents exist.
— European union Rollover Final Public Report - Annexes (May 2006) [48]
Although only less than 10% of all vehicle accidents with severe injuries involve rollovers, approximately 25% of all seriously injured occupants were involved in accidents where their car rolled. These numbers are currently increasing, as rollover frequency of several new vehicle types like mini vans, SUV or MPV is a lot higher than for most conventional cars.
— European union Rollover Final Public Report - Annexes (May 2006) [48]
Inside the European union, most rollovers occur off the carriageway. When the occupant is not ejected from the vehicle and the car does not strike any rigid objects, rollovers are the least injurious of the different impact types, because deceleration is longer and slower. [49]
Nonetheless, rollover risk depends upon the centre of gravity, suspension characteristics and loads carried. The severity of injury depends on the presence of crash-protective roadsides and the speed of impact. [50] In most of western Europe over 3,5 tonnes HGV have a speed limited from 80 km/h or 90 km/h, except in Great-Britain and Northern Ireland [51] and Italy, Romania and Bulgaria which have HGV speed limit up to 110 km/h. In France, HGV can reach 90 km/h on the motorway network and some other roads but are limited to the 80 km/h general speed limit of the local/secondary road network.
It is considered that Electronic Stability Programmes can contribute to reduce some accidents including rollovers. [50]
The vehicle fleets in Europe and in the US differ from each other. For instance, the US has significantly more SUVs, MPVs, Pick-ups and other vehicles with a high center of gravity. Further differences can be found when considering the road environment, e.g. availability and type of barriers, road side objects, congestion levels, road surfaces, proximity of buildings. Moreover, the belt wearing rate in the US, particularly in those vehicles prone to rollover, is lower than in European countries. Finally, there are differences in legislation which affect vehicle design and/or driver behavior.
— European union Rollover Final Public Report - Annexes (May 2006) [48]
- Occupant ejection is an important factor, especially when serious injuries are considered
- The risk of injury increases substantially when occupants are unrestrained
- Most rollovers occur about the longitudinal axis of the vehicle
- Most vehicle rollovers involve one complete roll or less
- Ejection takes place most frequently through the side windows.
— European union Rollover Final Public Report - Annexes (May 2006) [48]
Within European union, it is considered that HGV rollovers do not usually result in serious injury. [52]
Some European trucks have no ESC. [53]
In Sweden one to two rollover accidents occur every day. [54]
In France, several double-decker bus performed rollover making BEATT to recommend regulation improvement to make ESC mandatory, while seat belt has become mandatory in the meantime:
This led to European regulation (CE) 661/2009 and to UNECE regulation 66 revision to take into account such an issue.
In the US, rollover fatalities represents respectively 29.1%, 32.4% and 33.3% of fatalities in 1994, 2003 and 2004. [57]
Single-vehicle rollover fatalities represents respectively 82%, 82% and 81% of all rollover fatalities in 1994, 2003 and 2004. [57]
Rollover fatalities represents respectively 29%, 32% and 33% of fatalities in 1994, 2003 and 2004. [57]
US States & Territories where rollover includes a bigger part of fatalities includes:
US States & Territories where rollover includes a lower part of fatalities includes:
A skilled driver may stop a rollover by stopping a turn. Stunt drivers deliberately use ramps to launch a rollover. Vehicles with a high center of gravity are easily upset or "rolled." Short of a rollover, stunt drivers may also drive the car on two wheels for some time, but this requires precise planning and expert driver control. Specialized safety equipment is often utilized.[ citation needed ]
The driver deliberately drives one side of their vehicle onto a ramp which causes their vehicle to roll over. [58] The winner is the driver who guides their vehicle to the most rolls. [58]
A seat belt, also known as a safety belt or spelled seatbelt, is a vehicle safety device designed to secure the driver or a passenger of a vehicle against harmful movement that may result during a collision or a sudden stop. A seat belt reduces the likelihood of death or serious injury in a traffic collision by reducing the force of secondary impacts with interior strike hazards, by keeping occupants positioned correctly for maximum effectiveness of the airbag, and by preventing occupants being ejected from the vehicle in a crash or if the vehicle rolls over.
An airbag is a vehicle occupant-restraint system using a bag designed to inflate exceptionally quickly and then deflate during a collision. It consists of an airbag cushion, a flexible fabric bag, an inflation module, and an impact sensor. The purpose of the airbag is to provide a vehicle occupant with soft cushioning and restraint during a collision. It can reduce injuries between the flailing occupant and the vehicle's interior.
Crumple zones, crush zones, or crash zones are a structural safety feature used in vehicles, mainly in automobiles, to increase the time over which a change in velocity occurs from the impact during a collision by a controlled deformation; in recent years, it is also incorporated into trains and railcars.
A crash test is a form of destructive testing usually performed in order to ensure safe design standards in crashworthiness and crash compatibility for various modes of transportation or related systems and components.
Automotive safety is the study and practice of automotive design, construction, equipment and regulation to minimize the occurrence and consequences of traffic collisions involving motor vehicles. Road traffic safety more broadly includes roadway design.
Road traffic safety refers to the methods and measures used to prevent road users from being killed or seriously injured. Typical road users include pedestrians, cyclists, motorists, vehicle passengers, and passengers of on-road public transport.
Electronic stability control (ESC), also referred to as electronic stability program (ESP) or dynamic stability control (DSC), is a computerized technology that improves a vehicle's stability by detecting and reducing loss of traction (skidding). When ESC detects loss of steering control, it automatically applies the brakes to help steer the vehicle where the driver intends to go. Braking is automatically applied to wheels individually, such as the outer front wheel to counter oversteer, or the inner rear wheel to counter understeer. Some ESC systems also reduce engine power until control is regained. ESC does not improve a vehicle's cornering performance; instead, it helps reduce the chance of the driver losing control of the vehicle.
Corporate average fuel economy (CAFE) standards are regulations in the United States, first enacted by the United States Congress in 1975, after the 1973–74 Arab Oil Embargo, to improve the average fuel economy of cars and light trucks produced for sale in the United States. More recently, efficiency standards were developed and implemented for heavy-duty pickup trucks and commercial medium-duty and heavy-duty vehicles.
An off-road vehicle (ORV), sometimes referred to as an off-highway vehicle (OHV), overland vehicle, or adventure vehicle, is considered to be any type of vehicle that is capable of driving off paved or gravel surfaces, such as trails and forest roads that have rough and low traction surfaces.
Seat belt legislation requires the fitting of seat belts to motor vehicles and the wearing of seat belts by motor vehicle occupants to be mandatory. Laws requiring the fitting of seat belts to cars have in some cases been followed by laws mandating their use, with the effect that thousands of deaths on the road have been prevented. Different laws apply in different countries to the wearing of seat belts.
The Insurance Institute for Highway Safety and Highway Loss Data Institute (IIHS-HLDI) is an American nonprofit organization. It was established in 1959, and it is noted for its safety reviews of vehicles in various simulated traffic situations, including the effectiveness of a vehicle's structural integrity and safety systems during a collision, in addition to examining improvement on such elements.
The National Traffic and Motor Vehicle Safety Act was enacted in the United States in 1966 to empower the federal government to set and administer new safety standards for motor vehicles and road traffic safety. The Act was the first mandatory federal safety standards for motor vehicles. The Act created the National Highway Safety Bureau. The Act was one of a number of initiatives by the government in response to increasing number of cars and associated fatalities and injuries on the road following a period when the number of people killed on the road had increased 6-fold and the number of vehicles was up 11-fold since 1925. The reduction of the rate of death attributable to motor-vehicle crashes in the United States represents the successful public health response to a great technologic advance of the 20th century—the motorization of the United States.
A side collision is a vehicle crash where the side of one or more vehicles is impacted. These crashes typically occur at intersections, in parking lots, and when two vehicles pass on a multi-lane roadway.
Transportation safety in the United States encompasses safety of transportation in the United States, including automobile crashes, airplane crashes, rail crashes, and other mass transit incidents, although the most fatalities are generated by road incidents annually killing 32,479 people in 2011 to over 42,000 people in 2022. The number of deaths per passenger-mile on commercial airlines in the United States between 2000 and 2010 was about 0.2 deaths per 10 billion passenger-miles. For driving, the rate was 150 per 10 billion vehicle-miles: 750 times higher per mile than for flying in a commercial airplane.
Sport utility vehicles (SUVs) have been criticized for a variety of environmental and automotive safety reasons. The rise in prodution and marketing of SUVs in the 2010s and 2020s by auto manufacturers has resulted in over 80% of all new car sales in the United States being SUVs or light trucks by October 2021. This rise in SUV sales has also spilled over into the United Kingdom and the European Union. It has generated calls from car safety advocates to downsize in favor of models such as sedans, wagons, and compacts.
Most seat belt laws in the United States are left to the state or country’s law. However, the recommended age for a child to sit in the front passenger seat is 13. The first seat belt law was a federal law, Title 49 of the United States Code, Chapter 301, Motor Safety Standard, which took effect on January 1, 1968, that required all vehicles to be fitted with seat belts in all designated seating positions. This law has since been modified to require three-point seat belts in outboard-seating positions, and finally three-point seat belts in all seating positions. Seat belt use was voluntary until New York became the first state to require vehicle occupants to wear seat belts, as of December 1, 1984. New Hampshire is the only state with no law requiring adults to wear seat belts in a vehicle.
A traffic collision, also known as a motor vehicle collision, occurs when a vehicle collides with another vehicle, pedestrian, animal, road debris, or other moving or stationary obstruction, such as a tree, pole or building. Traffic collisions often result in injury, disability, death, and property damage as well as financial costs to both society and the individuals involved. Road transport is statistically the most dangerous situation people deal with on a daily basis, but casualty figures from such incidents attract less media attention than other, less frequent types of tragedy. The commonly used term car accident is increasingly falling out of favor with many government departments and organizations, with the Associated Press style guide recommending caution before using the term. Some collisions are intentional vehicle-ramming attacks, staged crashes, vehicular homicide or vehicular suicide.
A roadway departure is a type of incident that occurs when a vehicle leaves the roadway. Such incidents can lead to a single-vehicle collision.
When a person makes a claim for personal injury damages that have resulted from the presence of a defective automobile or component of an automobile, that person asserts a product liability claim. That claim may be against the automobile's manufacturer, the manufacturer of a component part or system, or both, as well as potentially being raised against companies that distributed, sold or installed the part or system that is alleged to be defective.
Electric vehicle warning sounds are sounds designed to alert pedestrians to the presence of electric drive vehicles such as hybrid electric vehicles (HEVs), plug-in hybrid electric vehicles (PHEVs), and battery electric vehicles (BEVs) travelling at low speeds. Warning sound devices were deemed necessary by some government regulators because vehicles operating in all-electric mode produce less noise than traditional combustion engine vehicles and can make it more difficult for pedestrians and cyclists to be aware of their presence. Warning sounds may be driver triggered or automatic at low speeds; in type, they vary from clearly artificial to those that mimic engine sounds and those of tires moving over gravel.
NHTSA's normal tests couldn't induce the car to flip, so the agency had to resort to "special means". Tesla credits the sedan's battery pack for that, which gives the Model S a very low center of gravity
| Main topics |  | |
|---|---|---|
| Road collisions | ||
| Causes | ||
| Lists of traffic collisions | ||
| Related lists | ||