Presflo

Last updated

Presflo and Prestwin were the designation for two types of goods wagon designed by British Railways in the 1950s for the carriage of powdered goods. The Presflo design was specifically for carriage of powdered cement but wagons to this design were subsequently used to transport other powdered commodities. The later Prestwin wagons were designed to overcome problems encountered with using the Presflo design for certain powdered commodities. Both types of wagon were loaded by gravity but unloaded using compressed air.

Contents

Presflo

While the Ideal Stock Committee reviewed the existing wagon designs inherited by British Railways and recommended which pre-nationalisation designs should either be continued or developed, there were also occasions where a need was identified that could not be met by an existing wagon designs such as the need for the bulk transport of cement powder, a commodity that had previously been carried bagged in vans. [1] [2]

Presflo is short for Pressure flow, and the designation came about as the design of wagon features air fluidisation, a system that pumps air into the powder under pressure to loosen it and prevent clumping, thus allowing the powder to be drained from the wagon efficiently. The distinctive external ribs were designed to strengthen the wagon to prevent it collapsing when unloading. The wagon itself was 16 feet 6 inches (5.03 m) over headstocks on a 10 feet 6 inches (3.20 m) wheelbase chassis. The wagon was not symmetrical, with both the access ladder and the discharge pipe only at one end. The total capacity of powder was 611 cubic feet (17,300 L). [3]

The prototype Presflo wagon was built to BR Diagram 1/273 but all production wagons were built to diagram 1/272. A total of 1840 Presflo wagons were constructed to diagram 1/272 with the following numbers: [4] [lower-alpha 1]

In the mid 1960s a Presflo wagon was modified to carry fly ash. The maximum load of the wagon was reduced to 17 tons and the diagram of the modified wagon was 1/281. As a result, in 1964 a further batch of 17 Ton wagons with vacuum brakes were constructed to Diagram 1/278, and these were followed by a 21 Ton variant designated ASH21, with these being built to diagram 1/279 (vacuum brakes) and diagrams 1/ 280 and 1/ 282 (air brakes). [4] [5] These wagons were longer than the previous Presflos and thus had a longer wheelbase and chassis. The brake arrangement was Morton brakes on one side but on the side with the discharge equipment they were fitted with clasp brakes. [6]

BR operation of Presflo wagons ceased in 1987.

Traffic flows

Wagons operated by Tunnel Cement between Aberthaw and either Oakengates, Birmingham Curzon Street or Southampton. [4]

Cement was conveyed from Westbury to both Exeter Central and Barnstaple for Blue Circle Industries. [7]

A trial was carried out using Presflo wagons built to diagram 1/272 for use with powdered slate from Delabole slate quarry in north Cornwall, and as a result five wagons were lettered SLATE POWDER for this traffic. [8] Further wagons that had previously been used for salt traffic were also used, some being branded BULK SLATE. [8] Traffic was originally over the North Cornwall Railway from Delabole to Tonbridge, but when that line closed in 1967, the powder was taken by lorry to Wadebridge and the wagons loaded there. [9]

During the 1970s cement was conveyed to Kishorn Yard with a Presflo wagon being attached to the rear of the Inverness to Kyle of Lochalsh passenger trains, this being used in the construction of oil rigs.

Accidents

These wagons were prone to lateral oscillation, which led to a derailment at Thirsk in July 1967, with a passenger train subsequently running into the wreckage, causing 7 fatalities and the destruction of prototype locomotive DP2.

Preservation

A Presflo wagon, originally used for cement powder traffic, has been preserved as part of the national collection. Wagon No B873368 was built in 1951 has been part of the collection of the National Railway Museum since 1986. In 2020 this wagon was on display at their Shildon location. [10]

In addition five other Presflo wagons have been privately preserved. Examples located at the Mid-Hants Railway, [11] Quainton Railway Society, [12] and Llangollen Railway [13] have been restored. A further example owned by the Darlington Railway Preservation Society was recorded as awaiting restoration in 2013, [14] while a further example is located at the Rushden, Higham and Wellingborough Railway. [15] All five privately preserved Presflos were built by Butterley Iron, and the single wagon in the care of the National Railway Museum was built by Gloucester Railway Carriage and Wagon. No examples built by BR Shildon works, Metro-Cammell or Central Wagon have survived.

Models

Ellis Clarke Trains have announced that they will produce several O gauge ready-to-run models of the Presflo in both bauxite and grey liveries. [16] Also in O Gauge First Class Kits have produced a kit of one of the Presflo wagons used for fly ash, [17] and Just Like The Real Thing have produced an O gauge kit of a diagram 1/272 Presflo.

A 00 gauge plastic kit was produced by Airfix between 1960 and 1964, and was re-released between 1975 and 1979. This kit was subsequently re-issued again by Dapol. [18]

The first 00 gauge ready-to-run Presflo wagon was produced by Hornby Dublo. [19] This model was subsequently sold to Wrenn and was produced by them is a variety of liveries including grey. [20] Bachmann also produce a 00 scale model. [21]

Prestwin

Prestwin wagons were designed by British Railways and built by Gloucester Railway Carriage and Wagon Company to carry some types of powder traffic that were unsuited to the Presflo design. There were two designs; diagram 1/274 had a 10 feet 6 inches (3.20 m) wheelbase while the final 100 wagons were built to diagram 1/277 and had a longer 12 feet (3.7 m) wheelbase [22] with larger silos although they were slightly lower as the silos were mounted between the frames rather than on top of them. [22] The wagons were completely distinctive, with two circular powder silos. A walkway is provided to permit access to the top of the silos with a ladder on each side located between the silos.

Construction of the type started in 1960 [22] and went on for 2 years. The wagons were numbered in four series: [4] [23]

The whole fleet of wagons were originally painted in bauxite although some were later repainted in a dark grey/black. [24]

Prestwin wagons ceased to be used in the 1980s [24]

Traffic flows

From 1972 Prestwins were used to convey Dried Hydrate of Alumina from Burtisland to Welwyn Garden City. [25]

Sodium tripolyphosphate from Albright and Wilson at Corkickle to Unilever facilities at both Port Sunlightt and Warrington, and to Procter & Gamble at West Thurrock. [24]

Lime from Hindlow [24]

Sand from Oakamoor to Port Sunlight [26]

Soda ash from Northwich [24]

Alumina hydrate from Rogerstone to Newport [25]

Trials were carried out to use the Prestwin design for carrying slag, China clay, Fuller's earth, ground limestone, Ground silica, Salt, Soda ash, Starch, and Slate powder. [24]

Models

Between 1978 and 1982 Hornby produced a ready-to-run model of the Prestwin in bauxite. A total of 67000 were made. [27]

Airfix produced a 00 gauge kit of the diagram 1/277 version of the Prestwin, [25] which later passed to Dapol. [28]

Lima produced an HO model in the 1970s which was marketed as a Prestwin. The colours were fictional and the design of the wagon itself, while bearing a general resemblance to the BR Prestwin, had several major differences, most notably the silhouette. [29]

Bachmann were due to release a ready-to-run OO gauge model in 2019. [30]

Notes

  1. ↑ Different sources quote a variety of numbers for the total number of Presflo wagons built across all diagrams

Related Research Articles

<span class="mw-page-title-main">Great Western Railway</span> British railway company (1833-1947)

The Great Western Railway (GWR) was a British railway company that linked London with the southwest, west and West Midlands of England and most of Wales. It was founded in 1833, received its enabling Act of Parliament on 31 August 1835 and ran its first trains in 1838 with the initial route completed between London and Bristol in 1841. It was engineered by Isambard Kingdom Brunel, who chose a broad gauge of 7 ft —later slightly widened to 7 ft 1⁄4 in —but, from 1854, a series of amalgamations saw it also operate 4 ft 8+1⁄2 in standard-gauge trains; the last broad-gauge services were operated in 1892.

<span class="mw-page-title-main">British Rail Classes 101 and 102</span>

The British Rail Classes 101 and 102 diesel mechanical multiple units were built by Metro-Cammell at Washwood Heath in Birmingham, England from 1956 to 1959, following construction of a series of prototype units. These classes proved to be some of the most successful and longest-lived of BR's First Generation DMUs, second in longevity only to the Class 121, with the final five units being withdrawn on 24 December 2003. The oldest set was, by then, just over 47 years old.

<span class="mw-page-title-main">Rutland Railway Museum</span> Railway museum in Oakham, Rutland

Rutland Railway Museum, now trading as Rocks by Rail: The Living Ironstone Museum, is a heritage railway on part of a former Midland Railway mineral branch line. It is situated north east of Oakham, in Rutland, England.

<span class="mw-page-title-main">Rail transport in Victoria</span> Overview of rail transport in Victoria, Australia

Rail transport in the Australian state of Victoria is provided by a number of railway operators who operate over the government-owned railway lines. The network consists of 2,357 km of Victorian broad gauge lines, and 1,912 km of standard gauge freight and interstate lines; the latter increasing with gauge conversion of the former. Historically, a few experimental 762 mm gauge lines were built, along with various private logging, mining and industrial railways. The rail network radiates from the state capital, Melbourne, with main interstate links to Sydney and to Adelaide, as well as major lines running to regional centres, upgraded as part of the Regional Fast Rail project.

<span class="mw-page-title-main">Transporter wagon</span>

A transporter wagon, in railway terminology, is a wagon (UIC) or railroad car (US) designed to carry other railway equipment. Normally, it is used to transport equipment of a different rail gauge. In most cases, a transporter wagon is a narrower gauge wagon for transporting a wider gauge equipment, allowing freight in a wider gauge wagons to reach destinations on the narrower gauge network without the expense and time of transshipment into a narrower gauge wagons.

<span class="mw-page-title-main">LMS Ivatt Class 2 2-6-2T</span>

The London, Midland and Scottish Railway (LMS) Ivatt Class 2 2-6-2T is a class of light 'mixed-traffic' steam locomotive introduced in 1946.

<span class="mw-page-title-main">Festiniog and Blaenau Railway</span> Disused railway in Wales

The Festiniog & Blaenau Railway (F&BR) was a narrow gauge railway built in 1868 to connect the town of Blaenau Ffestiniog in Wales with the slate quarries around Tanymanod and the village of Llan Ffestiniog, 3+1⁄2 miles (5.6 km) to the south. At Blaenau Ffestiniog it made a direct connection with the Festiniog Railway (FR) with which it was closely associated during its fifteen-year life. The railway was purchased by the Bala and Festiniog Railway in 1883 and converted to 4 ft 8+1⁄2 instandard gauge to extend the Bala Ffestiniog line, a branch of the GWR's line from Ruabon to Barmouth.

<span class="mw-page-title-main">Mineral wagon</span> Small open-topped railway goods wagon

A mineral wagon or coal truck is a small open-topped railway goods wagon used in the United Kingdom and elsewhere to carry coal, ores and other mine products.

<span class="mw-page-title-main">Merry-go-round train</span> Train that loads and unloads its cargo while moving

A merry-go-round train, often abbreviated to MGR, is a block train of hopper wagons which both loads and unloads its cargo while moving. In the United Kingdom, they are most commonly coal trains delivering to power stations. These trains were introduced in the 1960s, and were one of the few innovations of the Beeching cuts, along with investment from the Central Electricity Generating Board (CEGB) and the NCB into new power stations and loading facilities.

<span class="mw-page-title-main">1967 Thirsk rail crash</span> Train crash in Yorkshire, England on 31 July 1967

The Thirsk rail crash occurred on 31 July 1967 at Thirsk, Yorkshire, England on the British Rail East Coast Main Line.

<span class="mw-page-title-main">British Rail Class 128</span>

The British Rail Class 128 was a class of diesel multiple unit, built for British Rail. Introduced in 1959, ten of the class were built by Gloucester Railway Carriage and Wagon Company, each with two 230 hp British United Traction - Albion engines. The class was built specifically for parcels, fitted out with parcel racks and bike storage at each end, and did not feature any passenger accommodation. The last members of the class were withdrawn in 1990 and broken up the following year, and none were preserved.

<span class="mw-page-title-main">London Underground engineering stock</span>

Over the years, London Underground has acquired various types of engineering stock to help with the construction of new lines and maintenance of existing lines. Some of these wagons were inherited from its predecessors, many were built new and some were acquired second-hand from the main-line railways. Several types of specialist wagons have been used, which are described below.

<span class="mw-page-title-main">South African Class NG G13 2-6-2+2-6-2</span> Class of 12 South African 2–6-2+2-6-2 Garratt locomotives

The South African Railways Class NG G13 2-6-2+2-6-2 of 1927 was a narrow gauge articulated steam locomotive.

<span class="mw-page-title-main">Rosebud Kitmaster</span>

Rosebud Kitmaster is the brand name of a short-lived but critically acclaimed range of plastic assembly kits, manufactured in the United Kingdom by Rosebud Dolls Ltd of Raunds, Northamptonshire. Introduced from May 1959, the range rapidly expanded to include 34 models of railway locomotives and coaches in OO, HO and TT scales, and eventually, one motorcycle in 1:16 scale.

<span class="mw-page-title-main">Goods wagon</span> Unpowered railway vehicle used for freight transport

Goods wagons or freight wagons, also known as goods carriages, goods trucks, freight carriages or freight trucks, are unpowered railway vehicles that are used for the transportation of cargo. A variety of wagon types are in use to handle different types of goods, but all goods wagons in a regional network typically have standardized couplers and other fittings, such as hoses for air brakes, allowing different wagon types to be assembled into trains. For tracking and identification purposes, goods wagons are generally assigned a unique identifier, typically a UIC wagon number, or in North America, a company reporting mark plus a company specific serial number.

<span class="mw-page-title-main">Great Western Railway wagons</span> Fleet of railway rolling stock

The fleet of Great Western Railway wagons was both large and varied as it carried the wide variety of goods traffic on the Great Western Railway (GWR) in the United Kingdom. This was the railway company that operated for the longest period of time in the country and covered a large geographical area that included big cities such as London, industrialised areas including the West Midlands, areas of coal and mineral mining such as South Wales, and Somerset and other important agricultural districts. In 1902 the company owned 59,036 wagons, and by 1926 this had risen to 88,580.

The Nottingham Heritage Railway (formerly known as Great Central Railway (Nottingham) and Nottingham Transport Heritage Centre) is a heritage railway and transport museum on the south side of the village of Ruddington in Nottinghamshire. The route consists of almost 10 miles (16 km) of the former Great Central Railway Main Line from Loughborough South Junction (with the Midland Main Line) to Fifty Steps Bridge and the site of Ruddington's former GCR station, plus a branch line from Fifty Steps Bridge to Ruddington Fields station which is located on a former Ministry of Defence site next to Rushcliffe Country Park.

The Victorian Railways in Australia have had a vast range of hopper-type wagons over the last century, for transporting anything from grains through fuel to various powders.

References

Citations

  1. ↑ Hendry 1999, p. 12.
  2. ↑ "Kitmaster Presflo Cement Wagon Kit". Gaugemaster Controls Ltd. 2021. Retrieved 22 August 2021.
  3. ↑ Hendry 1999, p. 87.
  4. 1 2 3 4 5 "FROM THE ABSTRACT TO THE CONCRETE : GLOUCESTER'S CEMENT WAGONS". visit-gloucestershire.co.uk/. Retrieved 21 August 2021.
  5. ↑ Hendry 1999, p. 59.
  6. ↑ "Brief History". First Class Kits mail order site. Retrieved 21 August 2021.
  7. ↑ "Presflo Wagon liveries". RMweb.co.uk. 2020. Retrieved 22 August 2021.
  8. 1 2 "Kernow Model Rail Centre - Cornish Exclusive Wagons OO Gauge". RMweb.co.uk. 2020. Retrieved 21 August 2021.
  9. ↑ Wroe & Reeve 2008, p. 135.
  10. ↑ "British Railways Presflo cement wagon". The Science Museum Group. Retrieved 21 August 2021.
  11. ↑ "PO PF 29 Cement Hopper built 1960". Railway Heritage Register. Retrieved 22 August 2021.
  12. ↑ "PO TC 8956 Cement Hopper built 1960". Railway Heritage Register. Retrieved 22 August 2021.
  13. ↑ "PO TC 8953 Cement Hopper built 1960". Railway Heritage Register. Retrieved 22 August 2021.
  14. ↑ "PO APCM 8717 Cement Wagon built 1963". Railway Heritage Register. Retrieved 22 August 2021.
  15. ↑ "PO 5 Cement Hopper built 1960". Railway Heritage Register. Retrieved 22 August 2021.
  16. ↑ "Ellis Clark Trains E73-1-7U Finescale O Gauge Presflo Wagon 'Un-numbered', Bauxite (Pre-order)". Ellis Clark Trains. 2021. Retrieved 21 August 2021.
  17. ↑ "FCK22 Flyash Presflo Hopper Wagon". First Class Kits mail order site. Retrieved 21 August 2021.
  18. ↑ "1960 Presflo Cement Wagon 1.76". The airfix tribute forum. Tapatalk Inc. 2021. Retrieved 22 August 2021.
  19. ↑ "Hornby Dublo 4646 Presflo Cement wagon". Dublo For Sale. Retrieved 22 August 2021.
  20. ↑ "Wrenn Presflo "BRITISH RAIL" 20T Cement Wagon Rolling Stock W5005X". Connoisseur Wrenn. Retrieved 22 August 2021.
  21. ↑ "BR 22T 'Presflo' Cement Wagon 'Blue Circle Cement' Yellow". Bachmann Europe Plc. 2021. Retrieved 22 August 2021.
  22. 1 2 3 "Post Nationalisation Wagon Development". International Good Guys. Mike Smith. 2003. Retrieved 21 August 2021.
  23. ↑ "BR Wagon Numbers - Railway-owned B/DB Series - Part 1". LTSV wagons. 2014. Retrieved 21 August 2021.
  24. 1 2 3 4 5 6 "prestwin wagons". RMweb.co.uk. 2020. Retrieved 21 August 2021.
  25. 1 2 3 "prestwin wagons (page 2)". RMweb.co.uk. 2020. Retrieved 21 August 2021.
  26. ↑ "Prestwin wagon, used to carry sand between Oakamoor and Port Sunlight". Science & Society Picture Library. National Railway Museum. Retrieved 21 August 2021.
  27. ↑ "Prestwin Twin Silo Wagon". Hornby Collector Guide. 2021. Retrieved 21 August 2021.
  28. ↑ "Twin Silo Cement Wagon (Prestwin)". North Western Models. Retrieved 21 August 2021.
  29. ↑ "Lima British HO Wagons - Part 2". Lima HO scale. 8 April 2015. Retrieved 21 August 2021.
  30. ↑ "Bachmann 38-292 CQV Prestwin Twin Silo Wagon BR Bauxite Weathered". Model Junction. 2021. Retrieved 21 August 2021.

References

This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.