Waffle slab foundation

Last updated
Wafflemat Install Step 2.jpg

The Wafflemat foundation system, also called a waffle slab foundation, is an above-ground mat foundation used to provide load-bearing capacity on expansive, rocky, compressible, or hydro collapsible soils. The slab is created by placing a series of plastic forms ("Waffleboxes") that are either 8.5 or 12 inches (220 or 300 mm) in height, and 19 by 19 inches (480 mm × 480 mm) in plan, directly on grade to create a waffle-like grid of ribs, and then monolithically pour a post-tensioned reinforced concrete slab over the Waffleboxes. The completed slab then sits on the ground as a 'raft', with the void areas underneath the slab allowing for soil movement. [1]

Contents

The waffle slab is very stiff, with the cross section providing the needed strength to resist differential swelling resulting from landscaping practices, surface drainage, or flooding from any source. It does not require presoaking underlying soil pads, and there is no need for footings, meaning no earth spoils. [2] And, since the slab section is typically 12.5 to 16 inches (320–410 mm) above grade, it typically does not require a capillary break or moisture barrier.

Current design practice provides post-tensioned on-grade slabs with stiffness equal to or better than other post-tensioned slab types, but with less susceptibility to swell pressures exerted by expansive soils. An on-grade Wafflemat foundation provides all of the elements of the in-ground rib and uniform thickness slabs, but with greater performance provided by its geometry and smaller contact area with the soils.

Building code considerations

[3] The Wafflemat foundation system adheres to International Building Code and PTI requirements. By 2008, most states put into effect the changes adopted in the 2006 IBC and, in regards to foundations, the on-grade mat foundation has become a more attractive design because, as an engineered system, it already accommodates the 2008 design recommendations. Also, in 2008, the Post-Tensioning Institute (PTI) approved two key specifications for waffle-slab foundations and incorporated them into the PTI Manual, which is frequently referenced by building codes for post-tensioned slab design.

Performance of an on-grade mat foundation

Structural considerations

An engineer designing an on-grade slab makes the same calculations and follows the same requirements used in the design of traditional post-tensioned slabs on grade, and then applies them to the on-grade mat foundation ensuring the system possesses equal or greater stiffness.[ citation needed ]

Geotechnical considerations

The higher contact pressures along the base of the ribs and the voids, or low pressure areas in the system, limit deformations of soil due to moisture variation to the void spaces, reducing the impact of the soil's volume change on the on-grade mat slabs.

Environmental considerations

Environmental engineers note reduced carbon and/or other air quality emissions are usually of the same magnitude as the reduction in concrete needed for any foundation project. Since use of the on-grade Wafflemat foundation system typically results in a 20%–30% reduction in concrete, [4] a similar or even greater reduction in these other emissions will also occur. Because a Wafflemat foundation system uses less raw materials (cement, steel, fuel, aggregate, and sand) than alternative slab-on-grade and/or deep foundations, it is also more environmentally sustainable.

In addition to the lowering of CO2, the Wafflebox forms are made of recycled polypropylene plastic, and are a very 'green' material. This contributes, and adds to, the environmental benefits delivered by the system.

Finally, as the Wafflemat foundation system does not require presoaking of the underlying building pad (often averaging over 8,500 US gallons (32,000 L; 7,100 imp gal) for a 1,500-square-foot (140 m2) footprint with other foundations types), significantly less water is used than with alternative slab-on-grade and/or deep foundations. The Wafflemat system has been recognized by several organizations for its environmental advantages, including the Breath California Award for Environmental Excellence.

Commercial Acceptance

After nearly 20 years of Research and Development, the initial and current design of the Wafflemat foundation system was installed in 1,100 homes in Northern California from 1993 to 1995. Since that time, over 25,000,000 square feet (2.3 km2) has been installed in projects from the west coast of the US to east coast, and from Texas in the south to the Dakotas in the north. Production facilities for the Waffleboxes are located in California, Texas, and Monterrey, Mexico. [5]

See also

Related Research Articles

<span class="mw-page-title-main">Civil engineering</span> Engineering discipline focused on physical infrastructure

Civil engineering is a professional engineering discipline that deals with the design, construction, and maintenance of the physical and naturally built environment, including public works such as roads, bridges, canals, dams, airports, sewage systems, pipelines, structural components of buildings, and railways.

<span class="mw-page-title-main">Geotechnical engineering</span> Scientific study of earth materials in engineering problems

Geotechnical engineering, also known as geotechnics, is the branch of civil engineering concerned with the engineering behavior of earth materials. It uses the principles of soil mechanics and rock mechanics to solve its engineering problems. It also relies on knowledge of geology, hydrology, geophysics, and other related sciences.

<span class="mw-page-title-main">Rebar</span> Steel reinforcement

Rebar, known when massed as reinforcing steel or reinforcement steel, is a steel bar used as a tension device in reinforced concrete and reinforced masonry structures to strengthen and aid the concrete under tension. Concrete is strong under compression, but has low tensile strength. Rebar significantly increases the tensile strength of the structure. Rebar's surface features a continuous series of ribs, lugs or indentations to promote a better bond with the concrete and reduce the risk of slippage.

<span class="mw-page-title-main">Foundation (engineering)</span> Lowest and supporting layer of a structure

In engineering, a foundation is the element of a structure which connects it to the ground or more rarely, water, transferring loads from the structure to the ground. Foundations are generally considered either shallow or deep. Foundation engineering is the application of soil mechanics and rock mechanics in the design of foundation elements of structures.

<span class="mw-page-title-main">Gravity dam</span> Type of dam that uses mass to counteract water pressure

A gravity dam is a dam constructed from concrete or stone masonry and designed to hold back water by using only the weight of the material and its resistance against the foundation to oppose the horizontal pressure of water pushing against it. Gravity dams are designed so that each section of the dam is stable and independent of any other dam section.

<span class="mw-page-title-main">Soil mechanics</span> Branch of soil physics and applied mechanics that describes the behavior of soils

Soil mechanics is a branch of soil physics and applied mechanics that describes the behavior of soils. It differs from fluid mechanics and solid mechanics in the sense that soils consist of a heterogeneous mixture of fluids and particles but soil may also contain organic solids and other matter. Along with rock mechanics, soil mechanics provides the theoretical basis for analysis in geotechnical engineering, a subdiscipline of civil engineering, and engineering geology, a subdiscipline of geology. Soil mechanics is used to analyze the deformations of and flow of fluids within natural and man-made structures that are supported on or made of soil, or structures that are buried in soils. Example applications are building and bridge foundations, retaining walls, dams, and buried pipeline systems. Principles of soil mechanics are also used in related disciplines such as geophysical engineering, coastal engineering, agricultural engineering, hydrology and soil physics.

In construction or renovation, underpinning is the process of strengthening the foundation of an existing building or other structure. Underpinning may be necessary for a variety of reasons:

<span class="mw-page-title-main">Geosynthetics</span> Synthetic material used to stabilize terrain

Geosynthetics are synthetic products used to stabilize terrain. They are generally polymeric products used to solve civil engineering problems. This includes eight main product categories: geotextiles, geogrids, geonets, geomembranes, geosynthetic clay liners, geofoam, geocells and geocomposites. The polymeric nature of the products makes them suitable for use in the ground where high levels of durability are required. They can also be used in exposed applications. Geosynthetics are available in a wide range of forms and materials. These products have a wide range of applications and are currently used in many civil, geotechnical, transportation, geoenvironmental, hydraulic, and private development applications including roads, airfields, railroads, embankments, retaining structures, reservoirs, canals, dams, erosion control, sediment control, landfill liners, landfill covers, mining, aquaculture and agriculture.

<span class="mw-page-title-main">Concrete slab</span> Flat, horizontal concrete element of modern buildings

A concrete slab is a common structural element of modern buildings, consisting of a flat, horizontal surface made of cast concrete. Steel-reinforced slabs, typically between 100 and 500 mm thick, are most often used to construct floors and ceilings, while thinner mud slabs may be used for exterior paving (see below).

<span class="mw-page-title-main">Geotechnical investigation</span> Work done to obtain information on the physical properties of soil earthworks and foundations

Geotechnical investigations are performed by geotechnical engineers or engineering geologists to obtain information on the physical properties of soil earthworks and foundations for proposed structures and for repair of distress to earthworks and structures caused by subsurface conditions; this type of investigation is called a site investigation. Geotechnical investigations are also used to measure the thermal resistance of soils or backfill materials required for underground transmission lines, oil and gas pipelines, radioactive waste disposal, and solar thermal storage facilities. A geotechnical investigation will include surface exploration and subsurface exploration of a site. Sometimes, geophysical methods are used to obtain data about sites. Subsurface exploration usually involves soil sampling and laboratory tests of the soil samples retrieved.

<span class="mw-page-title-main">Soil nailing</span>

Soil nailing is a remedial construction measure to treat unstable natural soil slopes or unstable man-made (fill) slopes as a construction technique that allows the safe over-steepening of new or existing soil slopes. The technique involves the insertion of relatively slender reinforcing elements into the slope – often general purpose reinforcing bars (rebar) although proprietary solid or hollow-system bars are also available. Solid bars are usually installed into pre-drilled holes and then grouted into place using a separate grout line, whereas hollow bars may be drilled and grouted simultaneously by the use of a sacrificial drill bit and by pumping grout down the hollow bar as drilling progresses. Kinetic methods of firing relatively short bars into soil slopes have also been developed.

<span class="mw-page-title-main">Shallow foundation</span> Type of building foundation

A shallow foundation is a type of building foundation that transfers structural load to the earth very near to the surface, rather than to a subsurface layer or a range of depths, as does a deep foundation. Customarily, a shallow foundation is considered as such when the width of the entire foundation is greater than its depth. In comparison to deep foundations, shallow foundations are less technical, thus making them more economical and the most widely used for relatively light structures.

<span class="mw-page-title-main">Voided biaxial slab</span>

Voided biaxial slabs, sometimes called biaxial slabs or voided slabs, are a type of reinforced concrete slab which incorporates air-filled voids to reduce the volume of concrete required. These voids enable cheaper construction and less environmental impact. Another major benefit of the system is its reduction in slab weight compared with regular solid decks. Up to 50% of the slab volume may be removed in voids, resulting in less load on structural members. This also allows increased weight and/or span, since the self-weight of the slab contributes less to the overall load.

<span class="mw-page-title-main">Cellular confinement</span> Confinement system used in construction and geotechnical engineering

Cellular confinement systems (CCS)—also known as geocells—are widely used in construction for erosion control, soil stabilization on flat ground and steep slopes, channel protection, and structural reinforcement for load support and earth retention. Typical cellular confinement systems are geosynthetics made with ultrasonically welded high-density polyethylene (HDPE) strips or novel polymeric alloy (NPA)—and expanded on-site to form a honeycomb-like structure—and filled with sand, soil, rock, gravel or concrete.

<span class="mw-page-title-main">Screw piles</span> Construction component used for foundations

Screw piles, sometimes referred to as screw-piles, screw piers, screw anchors, screw foundations, ground screws, helical piles, helical piers, or helical anchors are a steel screw-in piling and ground anchoring system used for building deep foundations. Screw piles are typically manufactured from high-strength steel using varying sizes of tubular hollow sections for the pile or anchors shaft.

<span class="mw-page-title-main">Pressure grouting</span>

Pressure grouting or jet grouting involves injecting a grout material into otherwise inaccessible but interconnected pore or void space of which neither the configuration or volume are known, and is often referred to simply as grouting.

Geoprofessions is a term coined by the Geoprofessional Business Association to connote various technical disciplines that involve engineering, earth and environmental services applied to below-ground ("subsurface"), ground-surface, and ground-surface-connected conditions, structures, or formations. The principal disciplines include, as major categories:

<span class="mw-page-title-main">Waffle slab</span> Concrete flooring structural system

A waffle slab or two-way joist slab is a concrete slab made of reinforced concrete with concrete ribs running in two directions on its underside. The name waffle comes from the grid pattern created by the reinforcing ribs. Waffle slabs are preferred for spans greater than 40 feet (12 m), as they are much stronger than flat slabs, flat slabs with drop panels, two-way slabs, one-way slabs, and one-way joist slabs.

The Neoloy Geocell is a Cellular Confinement System (geocell) developed and manufactured by PRS Geo-Technologies Ltd. Geocells are extruded in ultrasonically welded strips. The folded strips are opened on-site to form a 3D honeycomb matrix, which is then filled with granular material. The 3D confinement system is used to stabilize soft subgrade soil and reinforce the subbase and base layers in flexible pavements. Cellular confinement is also used for soil protection and erosion control for slopes, including channels, retention walls, reservoirs and landfills.

<span class="mw-page-title-main">Geological engineering</span>

Geological engineering is a discipline of engineering concerned with the application of geological science and engineering principles to fields, such as civil engineering, mining, environmental engineering, and forestry, among others. The work of geological engineers often directs or supports the work of other engineering disciplines such as assessing the suitability of locations for civil engineering, environmental engineering, mining operations, and oil and gas projects by conducting geological, geoenvironmental, geophysical, and geotechnical studies. They are involved with impact studies for facilities and operations that affect surface and subsurface environments. The engineering design input and other recommendations made by geological engineers on these projects will often have a large impact on construction and operations. Geological engineers plan, design, and implement geotechnical, geological, geophysical, hydrogeological, and environmental data acquisition. This ranges from manual ground-based methods to deep drilling, to geochemical sampling, to advanced geophysical techniques and satellite surveying. Geological engineers are also concerned with the analysis of past and future ground behaviour, mapping at all scales, and ground characterization programs for specific engineering requirements. These analyses lead geological engineers to make recommendations and prepare reports which could have major effects on the foundations of construction, mining, and civil engineering projects. Some examples of projects include rock excavation, building foundation consolidation, pressure grouting, hydraulic channel erosion control, slope and fill stabilization, landslide risk assessment, groundwater monitoring, and assessment and remediation of contamination. In addition, geological engineers are included on design teams that develop solutions to surface hazards, groundwater remediation, underground and surface excavation projects, and resource management. Like mining engineers, geological engineers also conduct resource exploration campaigns, mine evaluation and feasibility assessments, and contribute to the ongoing efficiency, sustainability, and safety of active mining projects

References

  1. "Six Steps to Build a Wafflemat Foundation - YouTube". www.youtube.com. Archived from the original on 2021-12-21. Retrieved 2020-11-18.
  2. "Saving Thousands of Gallons of Water Per Home During Construction by Using the Wafflemat Foundation - YouTube". www.youtube.com. Archived from the original on 2021-12-21. Retrieved 2020-11-18.
  3. "Wafflemat Developer - YouTube". www.youtube.com. Retrieved 2020-11-18.
  4. "Carbon Footprint Analysis for Foundation at Laie Marriott". SmartSense Structural Systems. Retrieved 2020-11-18.
  5. "Wafflemat Developer - YouTube". www.youtube.com. Retrieved 2020-11-18.