Corporal E

Last updated • 5 min readFrom Wikipedia, The Free Encyclopedia

Corporal E
JPL---Corporate-and-Private-rockets.jpg
Major General Gladeon M. Barnes (right) and JPL Acting Director Frank Malina (left) stand below the 39-foot Corporal E, which was launched in May 1947.
Type Experimental guided missile
Place of originUnited States
Service history
In service1947–1951
Used by United States Army
Production history
Designer Jet Propulsion Laboratory
Designed1946
ManufacturerDouglas Aircraft
No. built11
Specifications
Mass11,700 lb (5,300 kg)
Length39 feet 2+3⁄8 inches (11.948 m)
Diameter30 in (760 mm)
EngineLiquid fuelled rocket
20,000 lbf (89 kN) thrust
PropellantLiquid fuel
Operational
range
62.5 mi (100.6 km)
Flight ceiling24.5 mi (39.4 km)
Boost time60 sec
Maximum speed 2,695 ft/s (821 m/s)

The ORDCIT (US Army's Ordnance and California Institute of Technology) program to develop a ballistic missile called Corporal was a progressive one. The original design was called XF30L20,000 which envisioned a 30 in (760 mm) diameter liquid fueled missile with a 20,000 lbf (89 kN) thrust engine and was ventured in the summer of 1944. The WAC Corporal sounding rocket was developed in 1945, providing experience with liquid fueled ballistic rocketry. The second phase gave experience with a redesigned and refined rocket and engine the following year. What was learned was applied to the Corporal program. [1]

Contents

Creating the Corporal E

The major development problems that were to be encountered with the XF30L20,000 were guidance and the increased size of the rockets engine. [2] The original time schedule was excessively optimistic especially as it envisioned the development of a turbo pump for propellants. [2]

The biggest problem was guidance as it was essentially unbroken ground. To provide as much data as possible a telemetry system was required. [2] It was determined that an autopilot guidance system was required and that a means of radio guidance to control roll, pitch and yaw, would also be needed. [3] Graphic mapping of the missile's flight would be performed by two radar plotting boards. [3] The guidance system of the first few rounds of Corporal E were to be supplied by Sperry Gyroscope Company largely from existing units because of the time required to develop special units. [3] Primary control was to be via vanes extending into the rocket exhaust. Ten channels of telemetry were envisioned to be displayed on graphic recorders to provide data to the missile operators. It was the intent of the people conducting the program to have the capability to control the rocket's flight with a control stick to observe flight characteristics. The intent was following the first few flights to have the operator hit a predetermined target. [4]

At the end of WWII the Corporal E programs adjusted to a less ambitious schedule and the WAC Corporal program was adjusted to provide more experience and design information. [5]

Work on the Corporal F with turbo pump instead of compressed air pressure propellant feed was halted with few parts produced.and the Corporal G study of a chemical gas generator to pressurize the fuel tanks was terminated as well. [6] The Corporal E was designed by JPL, with the first 4 airframes built by Douglas Aircraft Company, rocket motors and telemetry equipment were produced by JPL, Sperry Gyroscope provided the autopilot, Army Ordnance the Doppler and Position transponder, and the Signal Corps the radar tracking beacon. [5]

Testing the Corporal E

The first of the three pre-production missiles was fired at White Sands Proving Ground on 22 May 1947 with satisfactory results with a range of 62.5 miles (100.6 km) and an altitude of 24.5 miles (39,400 m). [7] The second Corporal E was a failure on 17 July 1947. [8] The third Corporal E was a partial success on 4 November 1947. Thrust ceased after 43 seconds and an altitude of 66,000 ft (20,000 m) and range of 14 miles (23 km) were achieved. Telemetry reveals fluctuations in amplitude and frequency of pressure in the motor chamber. [9]

As a results of the first three flights the Army Ordnance Department decided to use the Corporal E as a means of developing the means of enlarging its experience in manufacturing guided missiles. There was also interest in developing the basic design to improve performance and reliability. To achieve these goals a further seven rockets were contracted for. [9] Improving the Corporal E involved drastic changes in the rocket motor, airframe, guide vanes and control system. The design was changed to a more easily produced, assembled, and accessible structure. The means of launching was changed from the rocket sitting upon its fins to being held by four arms holding it above the fins which would retract to release it. [10] The first of the redesigned Corporal E missiles was available in May 1949. [11]

Corporal E number 4 was launched on 7 June 1949 and was a failure due to guidance failure. [11] It was determined that the guidance system was unreliable. It was determined that the guidance system being developed for the Sergeant missile was sufficiently developed to be used so it replaced the Corporal E's system. [11] It was also determined that the revised airframe had allowed damage to the control system. [12] Considerable changes in the program were being promoted in Washington with Ordnance Department pushing for the development of a guided missile as a weapon. [13] There was pressure to develop a missile for service by 1954. Corporal was further along than he competing GE Hermes program and was thus selected to develop a weapon, not just an experimental vehicle. [14]

The Corporal E launch program restarted with Corporal E number 5 on 11 July 1950, which was partially successful, as was Corporal E number 6. [15] Changes were made in the control system, and it achieved reliable service. Changes in the fuel system also improved reliability. [16]

Corporal E number 7 introduced the quick shutoff valve to increase accuracy and the 19 cell air tank. [17] Rockets 8 and 9 both showed failures in range both under and over. Electronics failure due to vibration was suspected and addressed. Corporal E 10 was not fired and number 11 which flew on 11 October 1951 was essentially the basic configuration of the Corporal ballistic missile the Army wanted including the new fin configuration. [17] The Corporal E number 11 went off course towards Las Cruces. [16] Corporal E number 5 had marked the effective end of Corporal E test vehicle development as the Corporal E had been selected for development into a guided missile weapon. [18] [19] The Corporal had been a most flexible program developing from WAC Corporal A and B to the early Corporal E to the limited production Corporal E. [20] There was even a study done as to using the Corporal E in an anti-aircraft role. [20] The Corporal Project proceeded with the development of the MGM-5 Corporal. [21] }

Notes

    Related Research Articles

    <span class="mw-page-title-main">UGM-27 Polaris</span> Submarine-launched ballistic missile

    The UGM-27 Polaris missile was a two-stage solid-fueled nuclear-armed submarine-launched ballistic missile (SLBM). As the United States Navy's first SLBM, it served from 1961 to 1980.

    <span class="mw-page-title-main">PGM-11 Redstone</span> American short-range ballistic missile

    The PGM-11 Redstone was the first large American ballistic missile. A short-range ballistic missile (SRBM), it was in active service with the United States Army in West Germany from June 1958 to June 1964 as part of NATO's Cold War defense of Western Europe. It was the first US missile to carry a live nuclear warhead, in the 1958 Pacific Ocean weapons test, Hardtack Teak.

    <span class="mw-page-title-main">Project HARP</span> US-Canada ballistics research project famous for its extremely large gun

    Project HARP, for high altitude research project, was a joint venture of the United States Department of Defense and Canada's Department of National Defence created with the goal of studying ballistics of re-entry vehicles and collecting upper atmospheric data for research. Unlike conventional space launching methods that rely on rockets, HARP instead used very large guns to fire projectiles into the atmosphere at extremely high speeds.

    A guidance system is a virtual or physical device, or a group of devices implementing a controlling the movement of a ship, aircraft, missile, rocket, satellite, or any other moving object. Guidance is the process of calculating the changes in position, velocity, altitude, and/or rotation rates of a moving object required to follow a certain trajectory and/or altitude profile based on information about the object's state of motion.

    <span class="mw-page-title-main">PGM-17 Thor</span> Intermediate-range ballistic missile

    The PGM-17A Thor was the first operative ballistic missile of the United States Air Force (USAF). It was named after the Norse god of thunder. It was deployed in the United Kingdom between 1959 and September 1963 as an intermediate-range ballistic missile (IRBM) with thermonuclear warheads. Thor was 65 feet (20 m) in height and 8 feet (2.4 m) in diameter.

    <span class="mw-page-title-main">PGM-19 Jupiter</span> Medium-range ballistic missile (MRBM)

    The PGM-19 Jupiter was the first nuclear armed, medium-range ballistic missile (MRBM) of the United States Air Force (USAF). It was a liquid-propellant rocket using RP-1 fuel and LOX oxidizer, with a single Rocketdyne LR79-NA rocket engine producing 667 kilonewtons (150,000 lbf) of thrust. It was armed with the 1.44 megatons of TNT (6.0 PJ) W49 nuclear warhead. The prime contractor was the Chrysler Corporation.

    <span class="mw-page-title-main">MGM-29 Sergeant</span> Tactical ballistic missile

    The MGM-29 Sergeant was an American short-range, solid fuel, surface-to-surface missile developed by the Jet Propulsion Laboratory. The missiles were built by Sperry Utah Company. The Sergeant was the third and last in a series of JPL rockets for the US Army whose names correspond to the progression in Army enlisted ranks, starting with Private and Corporal.

    <span class="mw-page-title-main">WAC Corporal</span> Sounding rocket

    The WAC Corporal was the first sounding rocket developed in the United States and the first vehicle to achieve hypersonic speeds. It was an offshoot of the Corporal program, that was started by a partnership between the United States Army Ordnance Corps and the California Institute of Technology in June 1944 with the ultimate goal of developing a military ballistic missile.

    <span class="mw-page-title-main">MGM-5 Corporal</span> Tactical ballistic missile

    The MGM-5 Corporal missile was a nuclear-armed tactical surface-to-surface missile. It was the first guided weapon authorized by the United States to carry a nuclear warhead. A guided tactical ballistic missile, the Corporal could deliver either a nuclear fission, high-explosive, fragmentation or chemical warhead up to a range of 75 nautical miles (139 km).

    <span class="mw-page-title-main">RTV-G-4 Bumper</span> Type of rocket

    The RTV-G-4 Bumper was a sounding rocket built by the United States. A combination of the German V-2 rocket and the WAC Corporal sounding rocket, it was used to study problems pertaining to two-stage high-speed rockets. The Bumper program launched eight rockets between May 13, 1948 and July 29, 1950. The first six flights were conducted at the White Sands Missile Range; the seventh launch, Bumper 8 on July 24, 1950, was the first rocket launched from Cape Canaveral.

    <span class="mw-page-title-main">RTV-A-2 Hiroc</span> 20th-century US research project

    The RTV-A-2 Hiroc was a product of the United States' first effort to develop an intercontinental ballistic missile (ICBM). The project was named MX-774. The project was canceled in 1947, but leftover funds were used to build and launch three of the planned 10 research vehicles designated RTV-A-2. The design included several innovations; the gimbaled thrust chambers provided guidance control, the internal gas pressure was used to support the airframe and the nose cap was separable. All of these concepts were later used on the Atlas missile and the first two on the Viking rocket. Also developed as part of MX-774 was the Azusa guidance system which was not used on the Hiroc missile but did contribute to the Atlas missile as well as many other early guided missiles launched from Cape Canveral.

    <span class="mw-page-title-main">Spaceflight before 1951</span>

    Spaceflight as a practical endeavor began during World War II with the development of operational liquid-fueled rockets. Beginning life as a weapon, the V-2 was pressed into peaceful service after the war at the United States' White Sands Missile Range as well as the Soviet Union's Kapustin Yar. This led to a flourishing of missile designs setting the stage for the exploration of space. The small American WAC Corporal rocket was evolved into the Aerobee, a much more powerful sounding rocket. Exploration of space began in earnest in 1947 with the flight of the first Aerobee, 46 of which had flown by the end of 1950. These and other rockets, both Soviet and American, returned the first direct data on air density, temperature, charged particles and magnetic fields in the Earth's upper atmosphere.

    <span class="mw-page-title-main">Hermes program</span> United States Army missile research program

    Project Hermes was a missile research program run by the Ordnance Corps of the United States Army from November 15, 1944, to December 31, 1954, in response to Germany's rocket attacks in Europe during World War II. The program was to determine the missile needs of army field forces. A research and development partnership between the Ordnance Corps and General Electric started November 20, 1944 and resulted in the "development of long-range missiles that could be used against both ground targets and high-altitude aircraft."

    Private was an experimental rocket developed by the California Institute of Technology on behalf of the United States Army. Tested in two different configurations, it provided the proof of concept that a fin-stabilised ballistic missile was technologically feasible, and led to the development of the Corporal ballistic missile. The Private was the first in a series of JPL rocket designs for the US Army, whose names correspond to the progression in Army enlisted ranks, leading to WAC Corporal, Corporal E, MGM-5 Corporal and finally Sergeant.

    <span class="mw-page-title-main">Missile Defense Alarm System</span> Satellite early warning system

    The Missile Defense Alarm System, or MIDAS, was a United States Air Force Air Defense Command system of 12 early-warning satellites that provided limited notice of Soviet intercontinental ballistic missile launches between 1960 and 1966. Originally intended to serve as a complete early-warning system working in conjunction with the Ballistic Missile Early Warning System, cost and reliability concerns limited the project to a research and development role. Three of the system's 12 launches ended in failure, and the remaining nine satellites provided crude infrared early-warning coverage of the Soviet Union until the project was replaced by the Defense Support Program. MiDAS represented one element of the United States's first generation of reconnaissance satellites that also included the Corona and SAMOS series. Though MIDAS failed in its primary role as a system of infrared early-warning satellites, it pioneered the technologies needed in successor systems.

    <span class="mw-page-title-main">NOTS-EV-1 Pilot</span> U.S. expendable launch system

    The NOTS-EV-1 Pilot, better known as NOTSNIK was an expendable launch system and anti-satellite weapon developed by the United States Navy's United States Naval Ordnance Test Station (NOTS). NOTSNIK began as an in-house project using available NOTS funds. The Advanced Research Projects Agency later supplied some funds for the program. The program involved creating transistorized sensors to detect nuclear explosions from the Operation Argus tests. Ten were launched during July and August 1958, all of which failed. It was the first air-launched rocket to be used for an orbital launch attempt; however, none was recorded as having reached orbit. Following the third orbital launch attempt a NOTS engineer at the tracking station in Christchurch, New Zealand reported receiving a weak signal from the spacecraft; This was never confirmed, and the launches were not catalogued as having reached orbit. The Pilot rocket was part of Project Pilot.

    The Mercury-Redstone Launch Vehicle, designed for NASA's Project Mercury, was the first American crewed space booster. It was used for six sub-orbital Mercury flights from 1960–1961; culminating with the launch of the first, and 11 weeks later, the second American in space. The four subsequent Mercury human spaceflights used the more powerful Atlas booster to enter low Earth orbit.

    <span class="mw-page-title-main">High Virgo</span> Air-launched ballistic missile

    The High Virgo, also known as Weapons System 199C (WS-199C), was a prototype air-launched ballistic missile (ALBM) jointly developed by Lockheed and the Convair division of General Dynamics during the late 1950s. The missile proved moderately successful and aided in the development of the later GAM-87 Skybolt ALBM. It was also used in early tests of anti-satellite weapons.

    <span class="mw-page-title-main">Crow (missile)</span> Experimental missile

    The Creative Research On Weapons or Crow program was an experimental missile project developed by the United States Navy's Naval Air Missile Test Center during the late 1950s. Intended to evaluate the solid-fueled integral rocket/ramjet (SFIRR) method of propulsion as well as solid-fueled ramjet engines, flight tests were conducted during the early 1960s with mixed success.

    <span class="mw-page-title-main">RTV-A-3 NATIV</span> Missile

    The RTV-A-3 NATIV was an experimental missile developed by North American Aviation for the United States Air Force in the late 1940s to test and evaluate guided missile technologies. The North American Test Instrumentation Vehicle (NATIV) was developed as part of the MX-770 program which was created towards the end of WWII with the intent of developing a long range missile.

    References

    1. ↑ Bragg, James W. (1961). Development of the Corporal: The Embryo of the Army Missile Program (PDF). Redstone Arsenal, Alabama: Reports and Historical Office, Army Ballistic Missile Agency, Army Ordnance Missile Command. p. 113. Archived (PDF) from the original on 28 June 2019.
    2. 1 2 3 Bragg 1961, p. 109.
    3. 1 2 3 Bragg 1961, p. 110.
    4. ↑ Bragg 1961, p. 11.
    5. 1 2 Bragg 1961, p. 113.
    6. ↑ The Rockets and Missiles of WHITE SANDS PROVING GROUNDS 1945-1958, by Gregory P. Kennedy, p 118, Schiffer Military History, Atglen, PA, 2009 ISBN   978-0-7643-3251-7
    7. ↑ Bragg 1961, p. 115.
    8. ↑ Bragg 1961, p. 114.
    9. 1 2 Bragg 1961, p. 116.
    10. ↑ Bragg 1961, p. 118.
    11. 1 2 3 Bragg 1961, p. 119.
    12. ↑ Bragg 1961, p. 120.
    13. ↑ Bragg 1961, p. 121.
    14. ↑ Bragg 1961, p. 122.
    15. ↑ Bragg 1961, p. 123.
    16. 1 2 Bragg 1961, p. 124.
    17. 1 2 Kennedy 2009, p. 120.
    18. ↑ Bragg 1961, p. 226.
    19. ↑ Kennedy 2009, p. 119.
    20. 1 2 Bragg 1961, p. 225.
    21. ↑ Kennedy 2009, p. 121.

    Further reading

    This page is based on this Wikipedia article
    Text is available under the CC BY-SA 4.0 license; additional terms may apply.
    Images, videos and audio are available under their respective licenses.