Viper Aircraft ViperJet

Last updated
ViperJet
RoleHigh performance sport and aerobatic
National originUnited States
Manufacturer Viper Aircraft
DesignerScott Hanchette
First flightOctober 1999
Developed from Viper Aircraft Viperfan

The Viper Aircraft ViperJet is a small homebuilt jet aircraft by Viper Aircraft Corporation. It is a conventional, low-wing monoplane with swept wings and tail and two seats in tandem under a bubble canopy. The jet intakes are located at the sides of the fuselage and the tricycle undercarriage is retractable. Construction throughout is of composite materials. [1] [2]

Contents

Development

Originally conceived to use a piston engine driving a five- or six-blade pusher propeller, brothers Scott and Dan Hanchette commenced work on the prototype, then known as the ViperFan, [3] in February 1996. [4] However, concerns about the difficulty and cost associated with eliminating vibration from the drivetrain led the Hanchettes to choose turbojet propulsion instead, and they installed a Turbomeca Marboré engine in place of the Continental flat-6 they had originally envisaged as a powerplant. [3]

The Viperjet prototype flew late in October 1999. [1] and made its public debut at EAA AirVenture Oshkosh in 2000. [5] The Hanchette brothers, however, were unhappy with both the low power [6] and the high fuel consumption [7] of the Turbomeca engine, and soon swapped it for a General Electric T58 turboshaft engine with the power turbine removed, [7] turning it into a turbojet. While this worked, it still did not produce as much thrust as the Hanchettes hoped for, and eventually, they selected the General Electric J85. [7] With this engine producing around four times the thrust of the previous powerplants tested in the Viper, the Hanchettes substantially redesigned the aircraft, dubbing the J85-powered version the MKII. [7] The prototype was dismantled and rebuilt, with parts of the canopy and fuselage center section all that remained of the original design. [7] The slightly larger MKII also features a pressurized cabin, [8] nearly three times the fuel tankage, [9] stronger undercarriage, [9] and optional tip tanks. [9] The MKII prototype flew on 12 June 2005 and Viper Aircraft offered replacement MKII parts to all customers who had purchased kits of the original version, [7] now dubbed the MKI.

In 2006, the base MKII kit cost US$182,000, but since builders can purchase additional components already pre-made by Viper Aircraft, customers spent an average of $350,000 on their kits. [6] They would then have to spend approximately another $300,000 [6] and around 3,000 to 3,500 hours to complete the aircraft. [4] The company also offers customers a builder assistance program to help them assemble the major airframe components and a training program to help them learn to fly their ViperJet once it is complete. Zero Gravity Builders provides builder assistance for the ViperJet MKII, ViperJet LXR and Viper FanJet. [10] Viper Aircraft had sold 21 kits by September 2006. [4]

In 2008, Viper Aircraft announced an enlarged, turbofan-powered follow-on design as the Viper Aircraft FanJet. The company has also proposed a military trainer version of the ViperJet, as well as a UAV version. [11]

Operational history

By April 2020 seven examples had been registered in the United States with the Federal Aviation Administration. [12]

Specifications (MKII, preliminary specifications)

Data from White 2006, p.13

General characteristics

Performance

See also

Related lists

Related Research Articles

<span class="mw-page-title-main">Heinkel He 280</span> Experimental jet aircraft

The Heinkel He 280 was an early turbojet-powered fighter aircraft designed and produced by the German aircraft manufacturer Heinkel. It was the first jet fighter to fly in the world.

<span class="mw-page-title-main">North American T-2 Buckeye</span> Jet powered Training aircraft

The North American T-2 Buckeye was the United States Navy's intermediate training aircraft, intended to introduce U.S. Navy and U.S. Marine Corps student naval aviators and student naval flight officers to jets. It entered service in 1959, beginning the replacement process of the Lockheed T2V SeaStar, and was itself replaced by the McDonnell Douglas T-45 Goshawk in 2008.

<span class="mw-page-title-main">Saab 105</span> Military training aircraft

The Saab 105 is a Swedish high-wing, twinjet trainer aircraft developed in the early 1960s as a private venture by Saab AB. The Swedish Air Force, which had opted to procure the type for various roles, issued the aircraft with the designation Sk 60. The Sk 60 entered service in 1967, replacing the ageing De Havilland Vampire fleet.

<span class="mw-page-title-main">PZL TS-11 Iskra</span> Type of aircraft

The PZL TS-11 Iskra is a Polish jet trainer, developed and manufactured by aircraft company PZL-Mielec. It was used by the air forces of Poland and India. It is notable as being the first domestically developed jet aircraft to be produced by Poland, its service for over 50 years as the principal training aircraft of the Polish Air Force, and at the time of its retirement was the oldest jet-propelled aircraft still in service in Poland.

<span class="mw-page-title-main">Bell X-14</span> Experimental vertical take-off and landing (VTOL) jet aircraft

The Bell X-14 is an experimental VTOL aircraft flown in the United States in the 1950s. The main objective of the project was to demonstrate vectored thrust horizontal and vertical takeoff, hover, transition to forward flight, and vertical landing.

<span class="mw-page-title-main">Piaggio PD.808</span> Type of aircraft

The Piaggio PD.808 was an Italian business jet built by Piaggio. It was designed as a joint venture between Piaggio and Douglas Aircraft Company of Long Beach, California, United States.

<span class="mw-page-title-main">General Electric J85</span> Turbojet aircraft engine

The General Electric J85 is a small single-shaft turbojet engine. Military versions produce up to 2,950 lbf (13.1 kN) of thrust dry; afterburning variants can reach up to 5,000 lbf (22 kN). The engine, depending upon additional equipment and specific model, weighs from 300 to 500 pounds. It is one of GE's most successful and longest in service military jet engines, with the civilian versions having logged over 16.5 million hours of operation. The United States Air Force plans to continue using the J85 in aircraft through 2040. Civilian models, known as the CJ610, are similar but supplied without an afterburner and are identical to non-afterburning J85 variants, while the CF700 adds a rear-mounted fan for improved fuel economy.

<span class="mw-page-title-main">Temco TT Pinto</span> Type of aircraft

The Temco TT Pinto is a tandem two-seat primary jet trainer built for the United States Navy by Temco Aircraft of Dallas, Texas.

<span class="mw-page-title-main">Lockheed XV-4 Hummingbird</span> American experimental VTOL aircraft

The Lockheed XV-4 Hummingbird was a U.S. Army project to demonstrate the feasibility of using VTOL for a surveillance aircraft carrying target-acquisition and sensory equipment. It was designed and built by the Lockheed Corporation in the 1960s, one of many attempts to produce a V/STOL vertical take off/landing jet. Both prototype aircraft were destroyed in accidents.

<span class="mw-page-title-main">Ryan Firebee</span> Series of target drones

The Ryan Firebee is a series of target drones developed by the Ryan Aeronautical Company beginning in 1951. It was one of the first jet-propelled drones, and remains one of the most widely used target drones ever built.

<span class="mw-page-title-main">Ambrosini Sagittario</span> 1953 Italian research aircraft

The Ambrosini Sagittario was an Italian aerodynamic research aircraft based on the manufacturer's S.7.

<span class="mw-page-title-main">Miles Student</span> Type of aircraft

The Miles M.100 Student was built as a lightweight trainer as a private venture by F.G. and George Miles with development started in 1953. Although not specifically a Miles product, it was promoted as a British Royal Air Force trainer but failed to enter production.

The Fouga CM.88 Gemeaux was a 1950s French engine test-bed aircraft produced by Fouga. An unusual aircraft, it was two aircraft joined by a common wing.

<span class="mw-page-title-main">Leduc 022</span> French prototype aircraft

The Leduc 022 was the prototype of a mixed-power French interceptor built in the mid-1950s. Designer René Leduc had been developing ramjet-powered aircraft since before World War II and had flown a series of experimental aircraft, the Leduc 0.10 and Leduc 0.21, throughout the Fifties before he was awarded a contract for two examples of a short-range supersonic interceptor armed with two air-to-air missiles (AAMs).

<span class="mw-page-title-main">SIPA S.200 Minijet</span> Type of aircraft

The SIPA S.200 Minijet was a light sporting jet aircraft designed and produced by the French aircraft manufacturer Société Industrielle Pour l’Aéronautique (SIPA). It is designed to perform liaison, training, and aerobatic flights. The Minijet was claimed to be the first jet-powered light touring aircraft

<span class="mw-page-title-main">Caproni Trento F-5</span> 1952 Italian jet trainer aircraft

The Caproni Trento F.5 was a small Italian two-seat trainer designed by Stelio Frati and built by Aeroplani Caproni Trento. The F.5 was not ordered into production and only a prototype was built.

The Procaer Cobra was a two-seat turbojet powered light aircraft designed and built in Italy and flown in the early 1960s. Only one was completed.

<span class="mw-page-title-main">Sonex Aircraft SubSonex</span> American jet-powered homebuilt airplane

The SubSonex is an experimental, single-seat, amateur-built jet aircraft from Sonex Aircraft's "Hornet's Nest" development division.

The Stargate YT-33 is an American homebuilt aircraft that was designed and intended to be produced by Stargate, Inc of McMinnville, Oregon, introduced in 1994. The aircraft is a 2/3 scale replica of the Lockheed T-33 jet trainer.

The Viper Aircraft Viperfan was an American homebuilt aircraft that was designed and produced by Viper Aircraft of Kennewick, Washington, introduced in the late 1990s. The aircraft was intended to be supplied as a kit for amateur construction, but only one was ever built.

References

Notes

  1. 1 2 "ViperJet kit aircraft makes maiden flight", Flight international, Flight global, 10 November 1999, The composite ViperJet….
  2. ↑ Bayerl, Robby; Berkemeier, Martin; et al. (2011–2012), World Directory of Leisure Aviation, Lancaster, UK: WDLA, p. 126, ISSN   1368-485X
  3. 1 2 Freeze 2005, p. 10C
  4. 1 2 3 Saywers 2006, p. 14
  5. ↑ Hitchman 2000, p. 44.
  6. 1 2 3 Saywers 2006, p. 1
  7. 1 2 3 4 5 6 Freeze 2005, p.11C
  8. ↑ Joshi 2007, p. B6
  9. 1 2 3 White 2006, p. 11.
  10. ↑ White 2006, p. 12
  11. ↑ White 2006, p. 13
  12. ↑ Federal Aviation Administration (27 October 2012). "Make / Model Inquiry Results" . Retrieved 8 April 2020.

Bibliography

  • Freeze, Di (November 2005). "The Path to the Viperjet MkII – The Trickest Jet on the Block". Pacific Northwest Aviation & Business Journal. Airport Journals. 4 (10): 8C–14C.
  • Hitchman, Nigel (5–11 September 2000). "Travelling Light". Flight International : 44–46. Retrieved 2009-02-21.
  • Joshi, Pratik (21 October 2007). "The right brothers". Tri-City Herald . pp. B5–B6.
  • Saywers, Karisa (September 2006). "Local kit plane company provides opportunity for aircraft ownership". Tri-Cities Area Journal of Business. 5 (9): 1, 14.
  • "ViperJet kit aircraft makes maiden flight" (PDF). Flight International : 32. 10–16 November 1999. Retrieved 2009-02-21.
  • White, Diane (February 2006). "The ViperJet MKII". Twin & Turbine: 8–13.

Commons-logo.svg Media related to Viperjet at Wikimedia Commons

This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.