Aquatic Species Program

Last updated

The Aquatic Species Program was a research program in the United States launched in 1978 by President Jimmy Carter and was funded by the United States Department of Energy, [1] which over the course of nearly two decades looked into the production of energy using algae. Initially, the funding of the Aquatic Species Program was to develop renewable fuel for transportation. Later, the program focused on producing bio-diesel from algae. The research program was discontinued in 1996. The research staff compiled their work and conclusions into a 1998 report.

Contents

History

Around 1978, the Carter Administration consolidated all federal energy activities under the support of the newly established U.S. Department of Energy (DOE). The DOE initiated research on the use of plant life as a source of transportation fuels. [2] The Aquatic Species Program (ASP) was a small research effort intended to look at the use of aquatic plants as sources of energy. While its history dates back to 1978, much of the research from 1978 to 1982 was focused on using algae to produce hydrogen. The program switched emphasis to other transportation fuels, in particular biodiesel, beginning in the early 1980s. [2] In 1995, DOE made the decision to eliminate funding for algae research within the Biofuels Program. The Department chose to focus its on one or two key areas, the largest of these being the development of bioethanol. The Aquatic Species Program ended in 1996.

Algal groups

Microalgae are microscopic organisms that can grow via photosynthesis. Many groups grow quickly and are more productive than land plants and macroalgae (seaweed). Microalgae reproduction occurs primarily by vegetative (asexual) cell division, although sexual reproduction can occur in many species under appropriate growth conditions. Microalgae are efficient for fuel production and they are capable of taking a waste (zero-energy) form of carbon (CO
2) and converting it into a high density liquid form of energy (natural oil). [2]

There are several main groups of microalgae, that differ by pigment composition, biochemical constituents, ultrastructure, and life cycle. Five groups were of primary importance to the ASP: diatoms (Class Bacillariophyceae), green algae (Class Chlorophyceae), golden- brown algae (Class Chrysophyceae), prymnesiophytes (Class Prymnesiophyceae), and the eustigmatophytes (Class Eustigmatophyceae). The blue-green algae, or cyanobacteria (Class Cyanophyceae), were also represented in some of the collections. [2]

Research

One side benefit was the sequestration of waste CO
2 from coal-fired power plants. The researchers were concerned with finding algae species which had a large lipid content, collecting over 3,000 North American species in their search. Work then focused on increasing their lipid content by reducing the supply of key nutrients, such as nitrogen and silicon.

Another key research aim was to validate the open pond system for mass production, resulting in the creation of 1,000 square metres (11,000 sq ft) pond systems in Roswell, New Mexico. While achieving the desired yields of 50 grams (1.8 oz) of algae per square meter per day, low temperatures were found to hamper yields.

Findings

Research on oil production in the cells

The main focus of the program was the production of biodiesel from high lipid-content algae grown in ponds, utilizing waste CO
2 from coal-fired power plants. The lipids that they are referring to are another name for Triglycerides or TAGs, which are the primary storage form of natural oils. The program looked at nutrient deficiency in algae, because they wanted to study the lipid trigger. The hypothesis was that when the algae is nutrient starved, oil production in the cells increases, so this might affect overall productivity. However, the study found that during nutrient deficiency, rates of oil production are lower. Higher levels of oil in the cells are more than offset by lower rates of cell growth. [2]

Acetyl-CoA carboxylase

Acetyl-CoA carboxylase (ACCase) is an enzyme which catalyzes a key metabolic step in the synthesis of oils in algae. The program was the first to isolate this enzyme from a diatom. The researchers discovered the transformation system for diatoms. They wanted to know if increasing the level of ACCase activity in the cells would lead to higher oil production. However, no increased oil production occurred. [2]

Open ponds

The program looked into the possibility of large-scale algae production in open ponds. They conducted studies in California, Hawaii, New Mexico, and found that the long term, reliable production of algae was possible. The Roswell, New Mexico tests proved that outdoor ponds could be run with extremely high efficiency of CO
2 utilization. Careful control of pH and other physical conditions for introducing CO
2 into the ponds allowed greater than 90% utilization. Single day production reported over the course of one year was as high as 50 grams (1.8 oz) of algae per square meter per day, the long-term target. Low temperatures negatively affected production. [2]

Cost

The costs were significantly lower than the costs of conventional fuel production to the environment and society.

Resource availability

ASP evaluated appropriate climate, land, and resource availability. They found that algae could supply several quads of biodiesel (one quad is 290 terawatt-hours), much more than existing oilseed crops could provide. Microalgae systems use less water than traditional oilseed crops. Land is not a limitation. 200,000 hectares (490,000 acres) could produce one quad of fuel. Thus, resource limitations are not an argument against the technology. [2]

Funding

In its prime, the program had up to $2–2.75 million in annual funding. [3] After the boom years of 1984 and 1985, funding fell rapidly to its low of $250,000 in 1991. The total cost of the Aquatic Species Program was $25.05 million over its twenty-year life. [3]

Crude oil price history from 1861-2006, dollars per barrel Oil Prices 1861 2006.jpg
Crude oil price history from 1861-2006, dollars per barrel

The July 1998 close out report from the program concluded that even with the most optimistic lipid yields the production of bio-diesel from algae would only become cost effective if petro-diesel prices rose to twice the 1998 levels. While highly volatile, oil prices are typically three or more times higher than the average 1998 price in constant dollars.

Future

The American Recovery and Reinvestment Act (ARRA) is the largest increase in scientific research funding in US history. Billions of dollars are going into energy research, development and deployment in the present and will continue. [3] U.S. Energy Secretary Steven Chu announced in January 2010 $80 million in government funding for biofuel research and development. The bulk of the funding, went to algae research and development, while the rest went toward ethanol infrastructure. [4]

However, projections for future costs of petroleum are a moving target. DOE expects petroleum costs to remain relatively flat over the next 20 years. Algal biodiesel is expensive in comparison and might not be able to compete with such cheap petroleum prices. [5]

Aftermath

National Renewable Energy Laboratory scientists isolated around 3,000 algae species. Fifty-one varieties were characterized as potential high-value strains, but fewer than half of those remain.

A few hundred strains were in storage at the University of Hawaii, which for years, every two months, transferred, “passaged”, them to new nutrient-rich test tubes. When a National Science Foundation grant ran out in 2004, maintaining the collection became impractical.

A review released earlier this year found that more than half the genetic legacy had been lost. 23 of the 51 strains that were extensively studied during the program survive. The losses to the rest of the algal cultures have been even worse.

“The really bloody shame is that of those 3,000, there are maybe 100 to 150 strains that remain at the University of Hawaii,” said Al Darzins, who heads up the resurgent algal biofuels research program at the National Renewable Energy Laboratory. [3]

Department of Energy

During the Carter Administration in the mid-1970s, all energy-related offices were brought together under the newly formed Department of Energy.

The hierarchy between the DOE and the Aquatic Species Program was as follows:

See also

Related Research Articles

<span class="mw-page-title-main">Biofuel</span> Type of biological fuel produced from biomass from which energy is derived

Biofuel is a fuel that is produced over a short time span from biomass, rather than by the very slow natural processes involved in the formation of fossil fuels, such as oil. Biofuel can be produced from plants or from agricultural, domestic or industrial biowaste.

<span class="mw-page-title-main">Biodiesel</span> Fuel made from vegetable oils or animal fats

Biodiesel is a form of diesel fuel derived from plants or animals and consisting of long-chain fatty acid esters. It is typically made by chemically reacting lipids such as animal fat (tallow), soybean oil, or some other vegetable oil with an alcohol, producing a methyl, ethyl or propyl ester by the process of transesterification.

<span class="mw-page-title-main">Microalgae</span> Microscopic algae

Microalgae or microphytes are microscopic algae invisible to the naked eye. They are phytoplankton typically found in freshwater and marine systems, living in both the water column and sediment. They are unicellular species which exist individually, or in chains or groups. Depending on the species, their sizes can range from a few micrometers (μm) to a few hundred micrometers. Unlike higher plants, microalgae do not have roots, stems, or leaves. They are specially adapted to an environment dominated by viscous forces.

<span class="mw-page-title-main">Algaculture</span> Aquaculture involving the farming of algae

Algaculture is a form of aquaculture involving the farming of species of algae.

<span class="mw-page-title-main">SERI microalgae culture collection</span>

The SERI microalgae culture collection was a collection from the Department of Energy's Aquatic Species Program cataloged at the Solar Energy Research Institute located in Golden, Colorado. The Aquatic Species Program ended in 1996 after its funding was cut, at which point its microalgae collection was moved to the University of Hawaii. In 1998 the University of Hawaii, partnered with the University of California at Berkeley, received a grant from the National Science Foundation (NSF), for their proposal to develop commercial, medical, and industrial uses of microalgae, as well as new and more efficient techniques for cultivation. This grant was used to form Marine Bioproduct Engineering Center (MarBEC), a facility operating within the University system of Hawaii at Manoa, but connected to corporate interests.

Pyrolysis oil, sometimes also known as bio-crude or bio-oil, is a synthetic fuel under investigation as substitute for petroleum. It is obtained by heating dried biomass without oxygen in a reactor at a temperature of about 500 °C (900 °F) with subsequent cooling. Pyrolysis oil is a kind of tar and normally contains levels of oxygen too high to be considered a pure hydrocarbon. This high oxygen content results in non-volatility, corrosiveness, immiscibility with fossil fuels, thermal instability, and a tendency to polymerize when exposed to air. As such, it is distinctly different from petroleum products. Removing oxygen from bio-oil or nitrogen from algal bio-oil is known as upgrading.

<i>Botryococcus braunii</i> Species of alga

Botryococcus braunii is a green, pyramid-shaped planktonic microalga that is of potentially great importance in the field of biotechnology. Colonies held together by a lipid biofilm matrix can be found in temperate or tropical oligotrophic lakes and estuaries, and will bloom when in the presence of elevated levels of dissolved inorganic phosphorus. The species is notable for its ability to produce high amounts of hydrocarbons, especially oils in the form of Triterpenes, that are typically around 30–40% of their dry weight. Compared to other green alge species it has a relatively thick cell wall that is accumulated from previous cellular divisions; making extraction of cytoplasmic components rather difficult. Much of the useful hydrocarbon oil is outside of the cell.

<i>Scenedesmus</i> Genus of green algae

Scenedesmus is a genus of green algae, in the class Chlorophyceae. They are colonial and non-motile. They are one of the most common components of phytoplankton in freshwater habitats worldwide.

Auxenochlorella protothecoides, formerly known as Chlorella protothecoides, is a facultative heterotrophic green alga in the family Chlorellaceae. It is known for its potential application in biofuel production. It was first characterized as a distinct algal species in 1965, and has since been regarded as a separate genus from Chlorella due its need for thiamine for growth. Auxenochlorella species have been found in a wide variety of environments from acidic volcanic soil in Italy to the sap of poplar trees in the forests of Germany. Its use in industrial processes has been studied, as the high lipid content of the alga during heterotrophic growth is promising for biodiesel; its use in wastewater treatment has been investigated, as well.

<i>Choricystis</i> Genus of algae

Choricystis is a genus of green algae in the class Trebouxiophyceae, considered a characteristic picophytoplankton in freshwater ecosystems. Choricystis, especially the type species Choricystis minor, has been proposed as an effective source of fatty acids for biofuels. Choricystis algacultures have been shown to survive on wastewater. In particular, Choricystis has been proposed as a biological water treatment system for industrial waste produced by the processing of dairy goods.

<span class="mw-page-title-main">Algae fuel</span> Use of algae as a source of energy-rich oils

Algae fuel, algal biofuel, or algal oil is an alternative to liquid fossil fuels that uses algae as its source of energy-rich oils. Also, algae fuels are an alternative to commonly known biofuel sources, such as corn and sugarcane. When made from seaweed (macroalgae) it can be known as seaweed fuel or seaweed oil.

<span class="mw-page-title-main">Cellana (company)</span>

Cellana, Inc. is an American company which develops of algae-based bioproducts for high-value nutrition, ink, and bioenergy applications, including Omega-3 nutraceutical applications, sustainable ink, aquaculture and animal feeds, human food ingredients, pigments, specialty chemicals, and biofuels. The company, with offices in Hawaii and San Diego, has received multiple multimillion-dollar grants from the United States Department of Energy and United States Department of Agriculture.

<i>Nannochloropsis</i> Genus of algae

Nannochloropsis is a genus of algae comprising six known species. The genus in the current taxonomic classification was first termed by Hibberd (1981). The species have mostly been known from the marine environment but also occur in fresh and brackish water. All of the species are small, nonmotile spheres which do not express any distinct morphological features that can be distinguished by either light or electron microscopy. The characterisation is mostly done by rbcL gene and 18S rRNA sequence analysis.

<span class="mw-page-title-main">Algae bioreactor</span> Device used for cultivating micro or macro algae

An algae bioreactor is used for cultivating micro or macroalgae. Algae may be cultivated for the purposes of biomass production (as in a seaweed cultivator), wastewater treatment, CO2 fixation, or aquarium/pond filtration in the form of an algae scrubber. Algae bioreactors vary widely in design, falling broadly into two categories: open reactors and enclosed reactors. Open reactors are exposed to the atmosphere while enclosed reactors, also commonly called photobioreactors, are isolated to varying extents from the atmosphere. Specifically, algae bioreactors can be used to produce fuels such as biodiesel and bioethanol, to generate animal feed, or to reduce pollutants such as NOx and CO2 in flue gases of power plants. Fundamentally, this kind of bioreactor is based on the photosynthetic reaction, which is performed by the chlorophyll-containing algae itself using dissolved carbon dioxide and sunlight. The carbon dioxide is dispersed into the reactor fluid to make it accessible to the algae. The bioreactor has to be made out of transparent material.

Algae fuel in the United States, as with other countries, is under study as a source of biofuel.

<i>Nannochloropsis</i> and biofuels

Nannochloropsis is a genus of alga within the heterokont line of eukaryotes, that is being investigated for biofuel production. One marine Nannochloropsis species has been shown to be suitable for algal biofuel production due to its ease of growth and high oil content, mainly unsaturated fatty acids and a significant percentage of palmitic acid. It also contains enough unsaturated fatty acid linolenic acid and polyunsaturated acid for a quality biodiesel.

<span class="mw-page-title-main">Culture of microalgae in hatcheries</span>

Microalgae or microscopic algae grow in either marine or freshwater systems. They are primary producers in the oceans that convert water and carbon dioxide to biomass and oxygen in the presence of sunlight.

<span class="mw-page-title-main">Carbon-neutral fuel</span> Type of fuel which have no net greenhouse gas emissions

Carbon-neutral fuel is fuel which produces no net-greenhouse gas emissions or carbon footprint. In practice, this usually means fuels that are made using carbon dioxide (CO2) as a feedstock. Proposed carbon-neutral fuels can broadly be grouped into synthetic fuels, which are made by chemically hydrogenating carbon dioxide, and biofuels, which are produced using natural CO2-consuming processes like photosynthesis.

Algal viruses are the viruses infecting photosynthetic single-celled eukaryotes, algae. As of 2020, there were 61 viruses known to infect algae. Algae are integral components of aquatic food webs and drive nutrient cycling, so the viruses infecting algal populations also impacts the organisms and nutrient cycling systems that depend on them. Thus, these viruses can have significant, worldwide economic and ecological effects. Their genomes varied between 4.4 to 560 kilobase pairs (kbp) long and used double-stranded Deoxyribonucleic Acid (dsDNA), double-stranded Ribonucleic Acid (dsRNA), single-stranded Deoxyribonucleic Acid (ssDNA), and single-stranded Ribonucleic Acid (ssRNA). The viruses ranged between 20 and 210 nm in diameter. Since the discovery of the first algae-infecting virus in 1979, several different techniques have been used to find new viruses infecting algae and it seems that there are many algae-infecting viruses left to be discovered

References

  1. ↑ "Archived copy" (PDF). Archived from the original (PDF) on 2006-09-26. Retrieved 2006-08-29.{{cite web}}: CS1 maint: archived copy as title (link)
  2. 1 2 3 4 5 6 7 8 "Archived copy" (PDF). Archived from the original (PDF) on 2020-04-23. Retrieved 2010-04-21.{{cite web}}: CS1 maint: archived copy as title (link)
  3. 1 2 3 4 Madrigal, Alexis (December 29, 2009). "How Algal Biofuels Lost a Decade in the Race to Replace Oil". Wired. Retrieved December 31, 2009.
  4. ↑ "DOE shows interest in algae fuels | Green Tech - CNET News". Archived from the original on 2010-08-23. Retrieved 2010-04-21.
  5. ↑ Jarvis, Eric E. (February 2008). "Aquatic Species Program (ASP): Lessons Learned" (PDF). National Renewable Energy Laboratory. Archived from the original (PDF) on 2009-08-26. Retrieved 2010-04-21.
This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.