Sasin Spraymaster

Last updated
SA-29 Spraymaster
Role Agricultural aircraft
ManufacturerSasin Aircraft Service
First flight1965
Introduction1965
Number built3
Developed from de Havilland Canada DHC-1 Chipmunk

The Sasin SA-29 Spraymaster was an agricultural aircraft designed and manufactured in Australia in the 1960s by Sasin Aircraft Service of Goulburn, New South Wales in conjunction with Aerostructures at Sydney's Bankstown Airport.

Contents

Design and development

By the 1960s the converted World War II-vintage types that comprised a large part of the Australian agricultural aircraft fleet were in need of replacement. [1] Sasin Aircraft Service of Goulburn, an operator of a de Havilland Tiger Moth modified for use as an agricultural aircraft, [2] decided to convert de Havilland Canada DHC-1 Chipmunks for agricultural use and contracted Aerostructures at Bankstown to perform the necessary modifications. [3]

The starting point was a Mk. 10 or Mk. 21 version of the Chipmunk. The modifications included a redesigned fuselage to accommodate a 50 Imperial gallon (227 L) hopper located where the front seat was found in the original aircraft, and a completely new cockpit in the location of the original rear seat. [3] An air-driven spray pump was mounted under the forward fuselage. [2] The pilot sat 11 inches (28 cm) higher than in the original aircraft. [1] A turnover truss and a new energy-absorbing seat were provided to protect the pilot from injury in a crash; and cable cutters were mounted in front of the cockpit as protection against one of the main hazards to agricultural aircraft (flying into power or telephone lines). A small dorsal fin and anti-spin strakes were fitted to the rear fuselage as well. [1] [3]

Modifications to the wing included endplates instead of the standard wingtips, the removal of wing root leading edge extensions and drooping the trailing edges. [3] These modifications resulted in a lower stalling speed of 38 kn at a maximum takeoff weight (MTOW) of 2,300 lb compared to a 45 kn stalling speed at a 2,100 lb MTOW in the original aircraft. [1] The Chipmunk's original de Havilland Gipsy Major engine was retained, but the original metal propeller was replaced with a lighter fine-pitch wooden propeller. [2]

The prototype was built using two Chipmunks; the then- Department of Civil Aviation (now the Civil Aviation Safety Authority) found problems with the fuselage modifications, which necessitated modifying a second fuselage. [2] The prototype first flew in mid-1965 and was granted a Type Certificate and Certificate of Airworthiness on 1 September 1965; it was then damaged beyond repair in a crash at Goulburn the following day. [2] Two more aircraft were converted, one of which crashed in 1970. [3] The remaining Spraymaster was restored to stock Chipmunk configuration in the mid-2000s for use as a Warbird. [4]

Aerostructures proposed a more capable version with a 110-gallon (500 L) hopper, MTOW of 2,800 lb (1,270 kg), and a 210 hp Continental IO-360 engine. This was to be called the SA-29 Mk. 2. [2] A larger aircraft with four seats and a one-ton hopper was also proposed; in the event neither design left the drawing board. [2]

Aerostructures also performed a two-seat non-agricultural conversion called the Sundowner that had many of the same modifications as the Spraymaster, and which had wingtip fuel tanks as well. [5]

Specifications (DHC-1 Chipmunk)

Data from The Illustrated Encyclopedia of Aircraft in Australia and New Zealand [3]

General characteristics

Performance

See also

Aircraft of comparable role, configuration, and era

Related Research Articles

de Havilland Canada DHC-1 Chipmunk Family of Canadian training aircraft

The de Havilland Canada DHC-1 Chipmunk is a tandem, two-seat, single-engined primary trainer aircraft designed and developed by Canadian aircraft manufacturer de Havilland Canada. It was developed shortly after the Second World War and sold in large numbers during the immediate post-war years, being typically employed as a replacement for the de Havilland Tiger Moth biplane.

de Havilland Hornet Moth

The de Havilland DH.87 Hornet Moth is a single-engined cabin biplane designed by the de Havilland Aircraft Company in 1934 as a potential replacement for its highly successful de Havilland Tiger Moth trainer. Although its side-by-side two-seat cabin made it closer in configuration to the modern aircraft that military trainee pilots would later fly, there was no interest from the RAF and the aircraft was put into production for private buyers.

Bennett Airtruck New Zealand agricultural aircraft

The PL-11 Airtruck is a New Zealand agricultural aircraft.

de Havilland Australia DHA-3 Drover

The de Havilland Australia DHA-3 Drover is a small transport aircraft that was built by de Havilland Australia (DHA) in the 1940s and 1950s. The aircraft had some similarities with the two-engine British-built de Havilland Dove but used a trimotor configuration.

The Gippsland GA-200 Fatman is a low-wing single-engine agricultural aircraft built by GippsAero.

Thruxton Jackaroo

The Thruxton Jackaroo was a 1950s British four-seat cabin biplane converted from a de Havilland Tiger Moth by Jackaroo Aircraft Limited at Thruxton Aerodrome and Rollason Aircraft and Engines Limited at Croydon Airport.

Percival Merganser

The Percival Merganser was a light, civil transport of the late 1940s. It was a twin-engine, high-wing monoplane of all-metal, stressed skin construction with retractable tricycle undercarriage.

Yakovlev Yak-50 (1975) Soviet aerobatic plane

The Yakovlev Yak-50 aerobatic aircraft is a single-seat all-metal low-wing monoplane with retractable main wheels and exposed tail wheel. The control surfaces are fabric-covered to save weight. The aircraft is not equipped with flaps.

CAC Ceres

The Commonwealth Aircraft CA-28 Ceres was a crop-duster aircraft manufactured in Australia by the Commonwealth Aircraft Corporation (CAC) between 1959 and 1963. The aircraft was a development of the Wirraway trainer of World War II.

The Yeoman Cropmaster was an Australian agricultural aircraft developed from the CAC Wackett trainer of World War II.

Kingsford Smith Cropmaster

The KS-3 Cropmaster was an Australian agricultural aircraft developed from the CAC Wackett, an aircraft used for training purposes during World War II.

Curtiss-Reid Rambler

The Reid Rambler, later known under the Curtiss-Reid brand after Reid was purchased by Curtiss, was a biplane trainer/sport aircraft built in Canada in the early 1930s and used in small numbers as a trainer aircraft by the Royal Canadian Air Force.

Breda Ba.33

The Breda Ba.33 was an Italian light sport aircraft designed and built by the Breda company.

PWS-52 1930s Polish light aircraft

The PWS-52 was a Polish sports aircraft of 1930, a single-engine high-wing monoplane, constructed by the Podlaska Wytwórnia Samolotów (PWS), that remained a prototype.

PWS 3 1920s Polish light aircraft

The PWS 3 was a Polish sport aircraft, developed in 1927 by PWS, which remained a prototype.

IAR-22

The IAR-22 was a single engine basic trainer built in Romania in about 1934. It was a low-wing monoplane with two seats in tandem and a fixed conventional undercarriage.

The de Havilland Australia DHA-G2 was a Second World War Australian transport glider based on the earlier prototype DHA-G1. Only two prototype G1 and six production G2 gliders were built.

The Czerwiński Sparrow, sometimes known as the de Havilland Canada glider, was a single seat glider, designed and built by a group of de Haviiland engineers in Canada in 1942. It was intended to popularise gliding and be suitable for both basic training and thermal soaring.

The O'Neill Model J Magnum, also called the Magnum Jake and the Magnum Pickup, is a homebuilt aircraft design for bush flying operations similar to the de Havilland Beaver.

CANT Z.1010 Italian passenger aircraft in the mid-1930s

The CANT Z.1010 was a single engine, five seat Italian passenger aircraft flown in the mid-1930s. Only one was built.

References

  1. 1 2 3 4 "Sport and Business", Flight International, 13 January 1966, p.58 (online archive version). Retrieved: 28 December 2008
  2. 1 2 3 4 5 6 7 Allen, Eric. "Made in Australia, Three Aussie AGplanes, Airtruk - Cropmaster - Spraymaster", Aero Australia magazine, No. 19, July/September 2008, p42-48. Chevron Publishing Group Pty. Ltd., Lane Cove NSW.
  3. 1 2 3 4 5 6 Eyre, David. "SASIN/AEROSTRUCTURES SA29 SPRAYMASTER", The Illustrated Encyclopedia of Aircraft in Australia and New Zealand, p.189. Sunshine Books, Hornsby NSW, 1983. ISBN   0-86777-272-7
  4. ↑ "Tropical Warbird!", Classic Wings magazine, Issue 71 (Vol. 16, No. 3), p44. Classic Wings Downunder Ltd., Blenheim, NZ, ISSN 1172-9643.
  5. ↑ Aerostructures Sundowner description page. Retrieved: 28 December 2008
This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.