A hush house is an enclosed, noise-suppressed facility used for testing aircraft systems, including propulsion, mechanics, electronics, pneumatics, and others. [1] Installed or uninstalled jet engines can be run under actual load conditions.
A hush house is an enclosed, noise-suppressed facility used for testing aircraft systems, including propulsion, mechanics, electronics, pneumatics, and others. [1] Installed or uninstalled jet engines can be run under actual load conditions.
A hush house is large enough to accommodate an entire crewed or uncrewed aircraft. Some facilities are also equipped to test additional capabilities such as weight and balance, night vision and low lighting, water intrusion, heat soaking, and wind evaluation. [1]
Jet engines can be run while installed in the aircraft, which must be restrained by holdback devices to resist the engine thrust. Uninstalled engines (without the aircraft) can be tested while held in place by thrust frames.
The air intake and exhaust systems of indoor engine test cells and hush houses are designed to block the transmission of noise, while optimizing the engine air flows. The engine exhaust, after having been thoroughly mixed with cooling air, is generally discharged through a vertical stack. The gas path incorporates acoustic damping panels (often containing fibrous insulation protected from gas stream erosion by metal mesh) to reduce the sound energy of the gas stream and attenuate the noise transmitted to the surrounding outdoor area.
Because the engine exhaust flow is "augmented" with a relatively large flow of cooling air induced by a Venturi effect into the exhaust silencing system, the exhaust muffler of an indoor test facility is generally referred to as an augmenter tube, although the term "detuner" is commonly used in the UK.[ citation needed ]
Some outdoor run-up facilities used to test aircraft engines (installed or uninstalled) may also be outfitted with noise control structures, called Ground Run-Up Enclosures. [2] [3] [4]
The McDonnell FH Phantom is a twinjet fighter aircraft designed and first flown during World War II for the United States Navy. The Phantom was the first purely jet-powered aircraft to land on an American aircraft carrier and the first jet deployed by the United States Marine Corps. Although only 62 FH-1s were built it helped prove the viability of carrier-based jet fighters. As McDonnell's first successful fighter, it led to the development of the follow-on F2H Banshee, which was one of the two most important naval jet fighters of the Korean War; combined, the two established McDonnell as an important supplier of navy aircraft.
A gas turbine, also called a combustion turbine, is a type of continuous flow internal combustion engine. The main parts common to all gas turbine engines form the power-producing part and are, in the direction of flow:
The Boeing C-40 Clipper is a military version of the Boeing 737 Next Generation used to transport cargo and passengers. It is used by the United States Navy, Air Force, and Marine Corps. The Navy C-40A variant is named "Clipper", whereas the USAF C-40B/C variants are officially unnamed.
The Douglas F3D Skyknight is an American twin-engined, mid-wing jet fighter aircraft manufactured by the Douglas Aircraft Company in El Segundo, California. The F3D was designed as a carrier-based all-weather night fighter and saw service with the United States Navy and United States Marine Corps. The mission of the F3D was to find and destroy enemy aircraft at night.
The Douglas F4D Skyray is an American carrier-based fighter/interceptor built by the Douglas Aircraft Company. Although it was in service for a relatively short time (1956–1964) and never entered combat, it was the first carrier-launched aircraft to hold the world's absolute speed record, at 752.943 mph, (1211.744 km/h) and was the first United States Navy and United States Marine Corps fighter that could exceed Mach 1 in level flight. It was the last fighter produced by the Douglas Aircraft Company before it merged with McDonnell Aircraft and became McDonnell Douglas. The F5D Skylancer was an advanced development of the F4D Skyray that did not enter service.
The Grumman F9F Panther is one of the United States Navy's first successful carrier-based jet fighters, as well as Grumman’s first jet fighter. A single-engined, straight-winged day fighter, it was armed with four 20 mm (0.79 in) cannons and could carry a wide assortment of air-to-ground munitions.
A hush kit is an aerodynamic device used to help reduce the noise produced by older aircraft jet engines. These devices are typically installed on older turbojet and low-bypass turbofan engines, as they are much louder than later high-bypass turbofan engines.
Marine Corps Air Station Iwakuni or MCAS Iwakuni is a United States Marine Corps air station located in the Nishiki river delta, 1.3 NM southeast of Iwakuni Station in the city of Iwakuni, Yamaguchi Prefecture, Japan.
Marine Corps Air Station Miramar, formerly Naval Auxiliary Air Station (NAAS) Miramar and Naval Air Station (NAS) Miramar, is a United States Marine Corps installation that is home to the 3rd Marine Aircraft Wing, which is the aviation element of the 1st Marine Expeditionary Force. It is located in Miramar, San Diego, California, about 14 miles (23 km) north of Downtown San Diego.
Naval Air Facility Atsugi is a joint Japan-US naval air base located in the cities of Yamato and Ayase in Kanagawa, Japan. It is the largest United States Navy (USN) air base in the Pacific Ocean and once housed the squadrons of Carrier Air Wing Five (CVW-5), which deploys with the American aircraft carrier USS Ronald Reagan.
Strike Fighter Squadron 37 (VFA-37), also known as the "Ragin' Bulls", is a United States Navy F/A-18E Super Hornet fighter squadron stationed at Naval Air Station Oceana. They are a part of Carrier Air Wing 8 (CVW-8) and are attached to USS George H. W. Bush. Their radio callsign is Ragin' and their tail code is AJ.
Naval Air Station (NAS) Oceana or NAS Oceana is a United States Navy Naval Air Station located in Virginia Beach, Virginia.
Marine Fighter Attack Squadron 115 (VMFA-115) is a United States Marine Corps F/A-18 Hornet squadron. Officially nicknamed the "Silver Eagles" and on occasion Joe's Jokers after their first commanding officer Major Joe Foss, the squadron is based at Marine Corps Air Station Beaufort, South Carolina and falls under the command of Marine Aircraft Group 31 (MAG-31) and the 2nd Marine Aircraft Wing. The squadron has seen combat during World War II, the Korean and Vietnam Wars and has deployed in support of Operation Iraqi Freedom with a final deployment in 2008 to Al Asad Airbase in western Iraq. The Squadron radio callsign is "Blade".
Marine Fighter Attack Squadron 121 (VMFA-121), also known as the "Green Knights", is a United States Marine Corps aircraft squadron operating the F-35B Lightning II. The squadron is based at Marine Corps Air Station Iwakuni, Japan and falls under the command of Marine Aircraft Group 12 (MAG-12) and the 1st Marine Aircraft Wing. Their tail code is VK and their radio call sign is "Combat".
Marine Fighter Attack Squadron 242 (VMFA-242) is a United States Marine Corps squadron flying F-35B Lightning II STOVL Stealth Fighter. The squadron, known as the "Bats", is based at Marine Corps Air Station Iwakuni, Japan and falls under the command of Marine Aircraft Group 12 (MAG-12) and the 1st Marine Aircraft Wing. The radio callsign is "Profane".
Strike Fighter Squadron 106 (VFA-106), also known as the "Gladiators", is a United States Navy F/A-18 Hornet and F/A-18E/F Super Hornet Fleet Replacement Squadron stationed at Naval Air Station Oceana, Virginia.
The National Gas Turbine Establishment in Farnborough, part of the Royal Aircraft Establishment (RAE), was the prime site in the UK for design and development of gas turbine and jet engines. For over 50 years, Pyestock was at the forefront of gas turbine development.
Electronic Attack Squadron 141 (VAQ-141), also known as the "Shadowhawks", is an EA-18G Growler squadron of the United States Navy that is based at Marine Corps Air Station Iwakuni, located in Iwakuni, Yamaguchi, Japan. VAQ-141 falls under the cognizance of Commander, Electronic Attack Wing Pacific (COMVAQWINGPAC) and flies in support of Carrier Air Wing 5 (CVW-5) aboard the Nimitz-class aircraft carrier, USS Ronald Reagan (CVN-76).
A jet blast deflector (JBD) or blast fence is a safety device that redirects the high energy exhaust from a jet engine to prevent damage and injury. The structure must be strong enough to withstand heat and high speed air streams as well as dust and debris carried by the turbulent air. Without a deflector, jet blast can be dangerous to people, equipment, vehicles and other aircraft.
The Naval Outlying Landing Field North Carolina is a proposed Naval Outlying Landing Field by the United States Navy that would service both Naval Air Station Oceana and Marine Corps Air Station Cherry Point.