VoltAero Cassio

Last updated
Cassio
VoltAero Cassio.jpg
The testbed is a modified Cessna 337 Skymaster with two front electric motors
Role hybrid electric aircraft
National origin France
Manufacturer VoltAero
First flightmodified testbed : 10 March 2020 [1]
Introductionplanned 2023 [2]
StatusUnder development

The VoltAero Cassio is a family of hybrid electric aircraft being developed by startup company VoltAero. The company plans to produce three configurations of the Cassio aircraft: the four-place Cassio 330, the six-place Cassio 480, and the ten-place Cassio 600. [3]

Contents

Development

VoltAero was established in Royan in September 2017 by the CTO and test pilot of the 2014 Airbus E-Fan 1.0, with the support of the French Nouvelle-Aquitaine region. The company is assembling a testbed based on the Cessna 337 Skymaster, which was intended to fly in late February 2019. The clean-sheet, all-composite Cassio prototype should follow in 2020, deliveries were initially anticipated in late 2021 or early 2022. [4]

For ground-testing the propulsion system, a Skymaster airframe was modified into an iron bird, on static display at the June 2019 Paris Air Show. The Skymaster testbed should fly without its nose engine in September 2019, and with the hybrid power module replacing the rear engine before the end of the year. The initial power module uses a Nissan automobile engine, followed by an in-house multifuel engine development. Building three prototypes and a structural test article will need a new fundraising. The first production aircraft would be delivered by the end of 2022. [5]

By October 2019, VoltAero had upgraded its testbed with two Safran EngineUS 45 motors, each producing 70 kW (94 hp) maximum and 45 kW (60 hp) continuously, installed on the wing with tractor propellers. November flight tests from Royan – Médis Aerodrome will keep both piston engines for 15 hours, before removing the forward piston engine for 10 hours. The aft hybrid system has a 170 kW (228 hp) Nissan car engine developed with Solution F, with an additional 60 kW (80 hp) Emrax electric motor on the same shaft, for 100 hours of tests including endurance and demonstration flights. [6] By March 2020, flight trials had begun for the hybrid-electric with its push-pull triple propeller configuration, before unveiling the Cassio 2 on 24 March. [1]

In May 2020, VoltAero presented the production Cassio family: the 330 kW (440 hp) combined Cassio 330 offering four seats, to be delivered from 2022, the later 480 kW (640 hp) Cassio 480 seating six and the 600 kW (800 hp) Cassio 600 accommodating ten people. [7] The six-seater is planned for 2023 and the 10 seater for 2024. [8]

The prototype Cassio 330 hybrid-electric aircraft prototype was first publicly displayed at the 2023 Paris Air Show, in June 2023. Powered by a four-cylinder Kawasaki engine, it will be used for airframe design flight testing prior to the installation of a hybrid powerplant. [9]

In November 2024, VoltAero inaugurated its final assembly facility and headquarters, marking a significant advancement towards the certification and production of its Cassia electric-hybrid aircraft series. [10]

Design

The production configuration: a three-surface aircraft with a single pusher propeller and a twin boom tail 2020-05-VoltAero-Cassio.jpg
The production configuration: a three-surface aircraft with a single pusher propeller and a twin boom tail

To be certified under EASA CS-23 regulations, the production configuration is a three-surface layout with a forward fixed canard, an aft, mid-mounted wing, and a twin boom, high tail, framing a single pusher propeller powered by an internal combustion engine and electric motors. [7] The maximum gross weight should be 5 t (11,000 lb), with 400 kg (880 lb) of additional weight for the electric motors and the batteries in the nose and in the wingbox. [5] The Cassio will be powered by two 60 kW (80 hp) electric motors driving tractor propellers on the wing and a 170 kW (230 hp) piston engine and 150 kW (200 hp) motor driving a pusher propeller in the aft fuselage. [4]

The combination of fuel and batteries will give it a 1,200 km (650 nmi) range with nine people aboard. [4] It should fly up to 200 km as a pure electric aircraft, 200–600 km (110–320 nmi) as a battery-assisted mild hybrid and over 600 km using more its combustion engine. Its cruise speed should be 200 kn (370 km/h) cruise its endurance 3.5 h, which could be extended to 5 h. [5] The production four-seater targets a 1,800 ft (550 m) field capability within a 2.5 t (5,500 lb) MTOW. [7]

Lower noise should be allowed by the electric taxiing and take off, before hybrid power above 1,200 ft (370 m). Fuel consumption could be reduced by up to 20%, with hybrid cruise until the batteries have discharged to a 20% energy level, before recharging them with the thermal engine. The cost of ownership is targeted for €290/h ($323) and a 10 h per day availability should allow eight daily rotations.

Specifications (Cassio 1)

Data from Aviation Week [5]

General characteristics

Performance

See also

Related Research Articles

<span class="mw-page-title-main">Regional airliner</span> Small airliner

A regional airliner or a feeder liner is a small airliner that is designed to fly up to 100 passengers on short-haul flights, usually feeding larger carriers' airline hubs from small markets. This class of airliners is typically flown by the regional airlines that are either contracted by or subsidiaries of the larger airlines. Regional airliners are used for short trips between smaller towns or from a larger city to a smaller city. Feeder liner, commuter, and local service are all alternative terms for the same class of flight operations.

<span class="mw-page-title-main">Cessna Skymaster</span> 1961 utility aircraft family by Cessna

The Cessna Skymaster is an American twin-engine civil utility aircraft built in a push-pull configuration. Its engines are mounted in the nose and rear of its pod-style fuselage. Twin booms extend aft of the wings to the vertical stabilizers, with the rear engine between them. The horizontal stabilizer is aft of the pusher propeller, mounted between and connecting the two booms. The combined tractor and pusher engines produce centerline thrust and a unique sound. The Cessna O-2 Skymaster is a military version of the Cessna Model 337 Super Skymaster.

<span class="mw-page-title-main">Aero A.32</span>

The Aero A.32 was a biplane built in Czechoslovakia in the late 1920s for army co-operation duties including reconnaissance and tactical bombing. While the design took the Aero A.11 as its starting point, the aircraft incorporated significant changes to make it suited for its new low-level role.

<span class="mw-page-title-main">Aircraft diesel engine</span> Aircraft engine operating on the Diesel principle

The aircraft diesel engine or aero diesel is a diesel-powered aircraft engine. They were used in airships and tried in aircraft in the late 1920s and 1930s, but were never widely adopted until recently. Their main advantages are their excellent specific fuel consumption, the reduced flammability and somewhat higher density of their fuel, but these have been outweighed by a combination of inherent disadvantages compared to gasoline-fueled or turboprop engines. The ever-rising cost of avgas and doubts about its future availability have spurred a resurgence in aircraft diesel engine production in the early 2010s.

<span class="mw-page-title-main">SOCATA TBM</span> Family of single engine turboprop aircraft

The SOCATA TBM is a family of high-performance single-engine turboprop business and utility light aircraft manufactured by Daher. It was originally collaboratively developed between the American Mooney Airplane Company and French light aircraft manufacturer SOCATA.

<span class="mw-page-title-main">Electric aircraft</span> Aircraft powered directly by electricity, with no other engine needed

An electric aircraft is an aircraft powered by electricity. Electric aircraft are seen as a way to reduce the environmental effects of aviation, providing zero emissions and quieter flights. Electricity may be supplied by a variety of methods, the most common being batteries. Most have electric motors driving propellers or turbines.

<span class="mw-page-title-main">Hydrogen-powered aircraft</span> Type of airplane

A hydrogen-powered aircraft is an aeroplane that uses hydrogen fuel as a power source. Hydrogen can either be burned in a jet engine or another kind of internal combustion engine, or can be used to power a fuel cell to generate electricity to power an electric propulsor. It cannot be stored in a traditional wet wing, and hydrogen tanks have to be housed in the fuselage or be supported by the wing.

The Svenska Flygfabriken LN-3 Seagull is a two-seater single-engine pusher configuration amphibian kitplane made from composite material, powered by a D-Motor LF26, D-Motor LF39 or Rotax 912/914 engine. It is fitted with retracting conventional landing gear. The manufacturer is Svenska Flygfabriken AB, based in Sundsvall, Sweden. Work started on building the prototype in 2003, and the maiden flight was made on 5 February 2008 at Midlanda Airport. Take-offs and landings on land, ice and water have all been tested during the test program..

The Scaled Composites Model 367 BiPod is an experimental flying car developed by Scaled Composites. It was the final aircraft designed by Burt Rutan prior to his retirement.

<span class="mw-page-title-main">Tecnam P2012 Traveller</span> Italian utility aircraft

The Tecnam P2012 Traveller is an eleven-seat utility aircraft designed and manufactured by the Italian company Costruzioni Aeronautiche Tecnam, based in Capua, Italy, near Naples.

The Wilksch WAM series is a family of aero-engines for light and general aviation aircraft. WAM series engines are produced by Wilksch Airmotive in Gloucestershire, England. The engine outputs range between 100 hp (75 kW) and 190 hp (142 kW), and are suitable for both tractor and pusher configurations. Initially intended for homebuilt aircraft, the WAM engines may become certified for use on factory-built aircraft.

<span class="mw-page-title-main">Pipistrel Panthera</span> Slovenian light aircraft

The Pipistrel Panthera is a lightweight, all-composite, highly efficient four-seat aircraft under development by Pipistrel of Slovenia.

<span class="mw-page-title-main">NASA X-57 Maxwell</span> Cancelled experimental NASA electric aircraft

The NASA X-57 Maxwell was an experimental aircraft developed by NASA, intended to demonstrate technology to reduce fuel use, emissions, and noise. The first flight of the X-57 was scheduled to take place in 2023, but the program was cancelled due to problems with the propulsion system.

<span class="mw-page-title-main">Eviation Alice</span> Electric aircraft

The Eviation Alice is an electric aircraft designed to accommodate nine passengers and two crew members. First developed in Israel, its construction incorporates 95% composite material, is powered by two electric motors, and has a T-tail. The prototype first flew on 27 September 2022.

<span class="mw-page-title-main">Rolls-Royce ACCEL</span> British electric aircraft demonstrator

The Rolls-Royce ACCEL is an electric aircraft demonstrator developed by Rolls-Royce plc.

magniX is an electric motor manufacturer for electric aircraft, wholly owned by Singapore investor Clermont Group. The company is headquartered in Everett, Washington, United States.

A hybrid electric aircraft is an aircraft with a hybrid electric powertrain. As the energy density of lithium-ion batteries is much lower than aviation fuel, a hybrid electric powertrain may effectively increase flight range compared to pure electric aircraft. By May 2018, there were over 30 hybrid electric aircraft projects, and short-haul hybrid-electric airliners were envisioned from 2032.

The Ampaire Electric EEL is a hybrid electric aircraft developed by U.S. startup Ampaire, established in Hawthorne, California. The forward piston engine of a Cessna 337 Skymaster is replaced by an electric motor powered by a battery, in a parallel hybrid configuration. The demonstrator first flew on 6 June 2019.

The Safran EngineUS is a family of electric motors for aircraft propulsion developed by Safran, outputting up to 1,000 kW (1,300 hp).

<span class="mw-page-title-main">Project Fresson</span> Type of aircraft

Project Fresson is the development by Cranfield Aerospace of an electric propulsion system for the over 700 BN-2 Islanders currently operated, supported by Britten-Norman.

References

  1. 1 2 Dan Thisdell (11 March 2020). "VoltAero gets off ground in hybrid power push". Flightglobal.
  2. ↑ Weitering, Hanneke (15 December 2022). "Air New Zealand Signals Next Steps To Decarbonize Fleet". Aviation International News. Retrieved 31 December 2022.
  3. ↑ Kate O'Connor (May 8, 2020). "VoltAero Reveals Production Design For Hybrid-Electric Cassio". AVweb.
  4. 1 2 3 4 Graham Warwick (Oct 25, 2018). "E-Fan Experience Spawns French Hybrid-Electric Startup". Aviation Week & Space Technology.
  5. 1 2 3 4 Graham Warwick (May 28, 2019). "VoltAero Hybrid-Electric Regional Aircraft Development Testing Begins". Aviation Week & Space Technology.
  6. ↑ Graham Warwick, ed. (Oct 28, 2019). "The Week In Technology, Oct. 28-Nov. 1, 2019". Aviation Week & Space Technology.
  7. 1 2 3 "VoltAero opens a new era in electric aviation with the unveiling of its production-version Cassio hybrid-electric aircraft" (Press release). VoltAero. May 6, 2020.
  8. ↑ Dan Thisdell, Kate Sarsfield (12 May 2020). "VoltAero reveals new configuration for hybrid-electric Cassio". Flightglobal.
  9. ↑ O'Connor, Kate (19 June 2023). "VoltAero Unveils Cassio 330 Prototype". Avweb. Archived from the original on 20 June 2023. Retrieved 20 June 2023.
  10. ↑ "VoltAero readies for production of Cassio electric-hybrid aircraft with new facility". Globalair.com. 2024-11-08. Retrieved 2024-11-12.
This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.