2001 Omsk An-70 crash

Last updated

2001 Omsk An-70 crash
Antonov 70 crash 2.jpg
UR-NTK at the crash site
Accident
Date27 January 2001
SummaryMultiple engine failure
Site660 meters from departure runway
54°58′0″N73°18′30″E / 54.96667°N 73.30833°E / 54.96667; 73.30833 [ citation needed ]
Aircraft
Aircraft type Antonov An-70
OperatorAntonov Design Bureau
Registration UR-NTK
Flight originOmsk Airport (OMS/UNOO), Russia
DestinationYakutsk Airport (YKS/UEEE), Russia
Passengers22
Crew11
Fatalities0
Injuries4
Survivors33 (all)

On 27 January 2001, an Antonov An-70 prototype crashed close to Omsk Tsentralny Airport, Russia during testing of the aircraft. All 33 passengers and crew on board the aircraft survived.

Contents

The accident involved the sole surviving An-70 prototype, as the first prototype had been destroyed in a mid-air collision six years previously. This placed the future of the An-70 project in doubt; however, the aircraft was later repaired and returned to flight. [1]

Accident

The aircraft arrived at Omsk at 0:30 and was refueled with 38 tons of jet fuel. [2] 5 hours after landing, the aircraft lifted off the runway on its way to Yakutsk for cold weather testing. Within seconds of becoming airborne one of the Progress D-27 propfans reached an over-speed condition and automatically shut down. The forward propeller stopped rotating but due to the nature of the failure the aft propeller kept turning, producing negative thrust. At this point the flight crew increased power to the remaining three engines but a problem with the RPM sensors on one of them led to automatic engine shut-off. Thus, the An-70 ended up flying at low speed with only two properly functioning engines, with the third engine generating over 11,000 pounds of negative thrust and disrupting airflow across the wing. [2]

The crew successfully made a 180-degree turn to head back towards departure airport but crash landed hard in the snow and ice within several hundred yards of the runway. Of the 33 people aboard (11 crew and 22 specialists from Antonov), 4 were injured, 1 seriously. [3] The accident investigators found that the pilots acted with remarkable skill to turn the aircraft around and crash-land it on the field without lowering the landing gear.

UR-NTK at Kiev - Gostomel, Ukraine. 25 September 2008 Antonov An-70, Antonov AN1125062.jpg
UR-NTK at Kiev - Gostomel, Ukraine. 25 September 2008
Close up of port side fuselage damage Antonov 70 crash, Jan 2001. 4.jpg
Close up of port side fuselage damage

Aircraft

UR-NTK was one of two An-70 prototype transport planes produced. Prototype 1 was destroyed in a mid-air collision in 1995. The fuselage of Prototype 2 was completely fractured between the midsection and the tail by the heavy landing during this incident. [2] The plane was insured but only for $1 million - a fraction of its actual cost. The aircraft was disassembled on site and relocated to the local "Polyot" aircraft repair factory in Omsk and restored to flying condition. [2] The damaged airframe required months of repair and as of 2012 is the only AN-70 in existence, still performing important flight testing.

Investigation

Three possibilities for the accident were investigated. Engine/Prop malfunction, fuel or oil defects in sub-zero temperatures leading to fuel starvation due to water in the fuel system freezing, or an act of sabotage or terrorism. Sabotage & terrorism were investigated by Russia's FSB which found no corroborating evidence. The fuel crystallization theory was discounted very early by the team of experts investigating the accident, leaving an engine or a propeller malfunction the only remaining possibility. [2]

Causes

The cause of the crash landing of the An-70 near Omsk remained the subject of much debate for a long time and the reason for heated exchange of accusations between the Antonov Design Bureau and the OAO Motor-Sich - the manufacturer of the D-27 engine. The manufacturer of the SV-27 propeller - Aerosila - also received some blame.

A report released by the investigation team in mid-March, by Ukrainian "Aviation and Time" magazine, provided preliminary details into the cause. [2] According to the report, immediately after take-off one of the engines was automatically shut off by its electronic safeguards after it exceeded the safe RPM limit. The front set of blades of the contra rotating propeller assembly stopped but the aft part of the propeller assembly continued turning due to the damaged oil line that powered the blade actuators. This caused the negative air flow estimated at 5,000 kg/11,023 lbs. of thrust.

At the end of March 2001 Antonov's first deputy designer-general Dmitri Kiva provided further details about the cause announcing that the accident was caused by disintegration of the oil line leading to the propeller hub pitch mechanism that attaches to the engine. Kiva said that the pilots attempted to compensate for the loss of power by increasing the settings of the remaining three engines. [2] At some point another D-27 automatically shut off after the safe RPM limit has been exceeded.

Consequences

Port side propfan damage AN 70 Crash engines 1.jpg
Port side propfan damage

The aircraft was repaired for approximately $3 million and made its first flight after the catastrophe on 5 June of the same year. On 7 June 2001, the repaired An-70 made a successful appearance at the VVTV-2001 armaments expo in Omsk.

Previously in early May An-70 developers announced that the aircraft will be presented at the 2001 Paris Air Show, but after the VVTV-2001 show in Omsk, France excluded the An-70 from the air show citing the aircraft's alleged poor safety record.

The engine/propeller problems were compounded on the pages of Russian newspapers by the existing problems in relations between Russia and Ukraine. Much of this negative publicity was instigated by competitors of Antonov, specifically ZMKB "Progress" and OAO Motor-Sich in Russia and in the West. In reality, however, Ukrainian engine designers and manufacturers had little to do with the cause of the accident. The faulty propeller hub pitch mechanism was manufactured in Russia. [2]

See also

Notes

  1. "AN-70 Crash Disrupts..." Aviation Week & Space Technology. 5 February 2001.
  2. 1 2 3 4 5 6 7 8 "An-70". Archived from the original on 30 November 2014. Retrieved 29 November 2014.
  3. "An-70 News". www.cthomas.de. Archived from the original on 3 March 2016. Retrieved 30 March 2018.

Related Research Articles

<span class="mw-page-title-main">Air France Flight 4590</span> 2000 plane crash of an Air France Concorde in Paris

On 25 July 2000, Air France Flight 4590, a Concorde passenger jet on an international charter flight from Paris to New York, crashed shortly after takeoff, killing all 109 people on board and four on the ground. It was the only fatal Concorde accident during its 27-year operational history.

<span class="mw-page-title-main">Antonov An-72</span> Transport aircraft by Antonov

The Antonov An-72 is a Soviet/Ukrainian transport aircraft, developed by Antonov. It was designed as an STOL transport and intended as a replacement for the Antonov An-26, but variants have found success as commercial freighters.

<span class="mw-page-title-main">Antonov An-10</span> Soviet medium-range airliner with 4 turboprop engines, 1957

The Antonov An-10 Ukraina is a four-engined turboprop passenger transport aircraft designed in the Soviet Union.

<span class="mw-page-title-main">Antonov An-70</span> Ukrainian/Russian military transport aircraft prototype by Antonov

The Antonov An-70 is a four-engine medium-range transport aircraft, and the first aircraft to take flight powered only by propfan engines. It was developed in the late 1980s by the Antonov Design Bureau to replace the obsolete An-12 military transport aircraft. The maiden flight of the first prototype took place in December 1994 in Kyiv, now independent Ukraine. Within months the prototype had suffered a mid-air collision. A second airframe was produced to allow the flight-test programme to proceed. Both prototypes were produced by the Kyiv Aircraft Production Plant.

<span class="mw-page-title-main">Antonov An-140</span> Twin-turboprop regional airliner by Antonov

The Antonov An-140 is a turboprop regional airliner, designed by the Ukrainian Antonov ASTC bureau as a successor to the Antonov An-24, with extended cargo capacity and the ability to use unprepared airstrips.

<span class="mw-page-title-main">American Airlines Flight 157</span> 1949 aviation accident

American Airlines Flight 157, a Douglas DC-6, departed on November 29, 1949, from New York City bound for Mexico City with 46 passengers and crew. After one engine failed in mid-flight, a series of critical mistakes by the flight crew caused the pilot to lose control of the plane during the final approach to a routine stopover at Love Field in Dallas, Texas. The airliner slid off the runway and struck a parked airplane, a hangar, and a flight school before crashing into a business across from the airport. 26 passengers and two flight attendants died. The pilot, co-pilot, flight engineer, and 15 passengers survived.

<span class="mw-page-title-main">S7 Airlines Flight 778</span> 2006 aviation accident

S7 Airlines Flight 778(S7778/SBI778) was a scheduled domestic passenger flight from Moscow to Irkutsk, Russia. On 9 July 2006, at 06:44 local time, the Airbus A310-324 aircraft operating the route overran the runway during its landing in Irkutsk. The aircraft failed to stop and crashed through the airport's concrete perimeter fence, struck rows of private garages and burst into flames, killing 125 people.

<span class="mw-page-title-main">Progress D-27</span> Propfan engine

The Progress D-27 is a three-shaft propfan engine developed by Ivchenko Progress, and manufactured by Motor Sich in Ukraine. The gas generator was designed using experience from the Lotarev D-36 turbofan. The D-27 engine was designed to power more-efficient passenger aircraft such as the abandoned Yakovlev Yak-46 project, and it was chosen for the Antonov An-70 military transport aircraft. As of 2019, the D-27 is the only contra-rotating propfan engine to enter service.

Aviaarktika was a Soviet airline which started operations on 1 September 1930 and was absorbed by Aeroflot on 3 January 1960.

<span class="mw-page-title-main">Aviastar-TU Flight 1906</span> 2010 aviation accident

<span class="mw-page-title-main">Cathay Pacific Flight 780</span> 2010 non-fatal aircraft incident

Cathay Pacific Flight 780 was a flight from Juanda International Airport in Surabaya, Indonesia, to Hong Kong International Airport on 13 April 2010. On board were 309 passengers and a crew of 13. As Flight 780 neared Hong Kong, the crew were unable to change the thrust output of the engines. The aircraft, an Airbus A330-300, landed at almost twice the speed of a normal landing, suffering minor damage. The 57 passengers who sustained injuries were hurt in the ensuing slide evacuation; one of them received serious injuries.

<span class="mw-page-title-main">1955 MacArthur Airport United Air Lines crash</span> Airplane crash in New York

On April 4, 1955, a United Airlines Douglas DC-6 named Mainliner Idaho crashed shortly after taking off from Long Island MacArthur Airport, in Ronkonkoma, Islip, New York, United States.

<span class="mw-page-title-main">Sita Air Flight 601</span> 2012 aviation accident

Sita Air Flight 601 (ST601/STA601) was a Nepalese domestic passenger flight, operated by Sita Air from Tribhuvan International Airport in Nepal's capital Kathmandu to Tenzing-Hillary Airport in Lukla. On 28 September 2012, the Dornier 228 serving the route crashed while attempting an emergency landing at Kathmandu shortly after takeoff, killing all 19 people on board.

<span class="mw-page-title-main">Antonov An-74</span> Soviet/Ukrainian military transport aircraft

The Antonov An-74 is a Soviet/Ukrainian transport aircraft developed by Antonov. It is a variant of the An-72.

<span class="mw-page-title-main">1997 Irkutsk Antonov An-124 crash</span>

On 6 December 1997 a Russian Air Force Antonov An-124-100, en route from Irkutsk Northwest Airport to Cam Ranh Air Base in Vietnam, crashed in a residential area after take-off from Irkutsk-2 airport.

<span class="mw-page-title-main">Accidents and incidents involving the An-12 family</span>

The Antonov An-12 is a transport aircraft designed and manufactured by the Ukrainian manufacturing and services company Antonov. Given the long operational history of the An-12, more than 190 An-12s have crashed involving many casualties. The An-12 has also been involved in a number of aviation incidents.

<span class="mw-page-title-main">Aeroflot Flight N-826</span> 1969 aviation accident

On Sunday 3 August 1969 an Antonov An-24 operating Aeroflot Flight N-826 crashed resulting in the death of all 55 people on board. An investigation revealed the cause of the accident was an in flight failure of the propeller attached to "No. 1" (left) engine.

<span class="mw-page-title-main">Aeroflot Flight L-51</span> 1967 aviation accident

Aeroflot Flight L-51 was a scheduled domestic passenger flight operated by an Antonov An-24 that crashed on approach to Liepāja International Airport on 30 December 1967, resulting in the death of 43 of the 51 people on board. To date, it is the deadliest aviation accident in Latvian history. The investigation revealed the cause of the accident to be pilot error.

<span class="mw-page-title-main">Volga-Dnepr Airlines Flight 4066</span> 13 November 2020 aviation accident in Novosibirsk, Russia

On 13 November 2020, Volga-Dnepr Airlines Flight 4066 suffered an uncontained engine failure on take-off from Tolmachevo Airport, Novosibirsk, Russia for Vienna International Airport, Vienna, Austria. The aircraft was severely damaged, and was further damaged when it overran the runway on landing at Tolmachevo airport. The investigation into the accident is currently ongoing.

<span class="mw-page-title-main">Siberian Light Aviation Flight 51</span> 2021 aviation incident

Siberian Light Aviation Flight 51 was a passenger flight on September 12, 2021, by a Let L-410 Turbolet plane, from Irkutsk north to Kazatjinskoje, Irkutsk Oblast, Siberia, near Lake Baikal. The plane crashed about 4 kilometers from the airport. The cause is under investigation by the Interstate Aviation Committee, the Russian Accident Commission.

References