St. Clair Power Plant

Last updated

Saint Clair Power Plant
DTE St Clair.jpg
Detroit Edison's St. Clair Power Plant.
St. Clair Power Plant
CountryUnited States
Location East China, St. Clair County, Michigan
Coordinates 42°45′52″N82°28′21″W / 42.76444°N 82.47250°W / 42.76444; -82.47250
StatusDecommissioned
Commission date Unit 1: August, 1953
Unit 2: November, 1953
Unit 3: June, 1954
Unit 4: October, 1954
Unit 6: April, 1961
Unit 7: April, 1969
Oil turbine: May, 1968
2 internal combustion generators: December, 1970
Decommission dateUnit 5: 1979

Unit 4: 2017 Unit 1: 2019

Units 2, 3, 6, 7: May 2022 [1]
Owner(s) Detroit Edison
Thermal power station
Primary fuel Subbituminous coal,
distillate fuel oil
Cooling source St. Clair River
Power generation
Units operational6
Nameplate capacity 1,928 MWe
[ edit on Wikidata]

At one time, St. Clair Power Plant was the world's largest.

The Saint Clair Power Plant was a major coal- and oil-fired power plant owned by DTE Electric, a subsidiary of DTE Energy. It was located in St. Clair County, Michigan, on the west bank of St. Clair River. The plant was across M-29 from the newer Belle River Power Plant in East China, Michigan. The first four units of St. Clair were built in 1953–1954. [2] Since then, three more generating units were added to the plant. The St. Clair Power Plant generated 1982 megawatts in total. [3] It was Detroit Edison's second largest power producer. [4] The power plant has a large impact on the local economy, employing about 300 workers. [5] The plant shut down in May 2022. [6]

Contents

Units

A total of seven coal-fired boilers were ultimately built at St. Clair, although only six remain operational.

Units 1 – 4

Units 1 – 4 are 163 MW Babcock & Wilcox boilers tied to GE and Allis-Chalmers steam turbines. These are the four original units at St. Clair. Generating units 1–4 are St. Clair's base load units, usually running at full capacity. The flue gases from those units exit through south stack, which was erected in the late 1970s when new electrostatic precipitators were added to these units. When the plant was first built, there were four relatively short stacks, one for each unit. St. Clair Unit 4 retired early, in 2017, due to mechanical problems and Unit 1 was retired in March 2019.

Unit 5

Unit 5 is St. Clair's first decommissioned unit. Its cyclone boiler produced 300 MW, and was taken out of service in 1979 due to a mechanical problem with the boiler. The stack for unit five was removed in 2012.

Unit 6

Unit 6 is a tangentially fired Combustion Engineering dual furnace boiler tied to a Westinghouse turbine. Commissioned in 1961, this unit produces 321 MW.

Unit 7

Unit 7 is also a tangentially fired Combustion Engineering boiler tied to a Westinghouse steam turbine. It was commissioned in 1969. Unit 7 is rated at 451 MW, originally built to produce over 500 MW. This unit is St. Clair's largest generating unit, but has a small electrostatic precipitator, causing problems with the opacity when burning western coal. [7]

Other units

An oil-fueled gas turbine Unit 11, rated at 18.5 MWe, was added in 1968. Two smaller oil-fueled internal-combustion generators, totaling 5.4 MWe, were added as units 12A and 12B in 1970. [3]

History

St. Clair Power Plant came online in August 1953, and was the largest in the DTE Energy network. At that time, its capacity was 652 MW. Later, units 5, 6 and 7 were added to meet growing demands for power in Metro Detroit, with St. Clair producing 1571 MW. After the completion of unit 7 in 1969, St. Clair Power Plant was the world's largest. [8] In the middle to late 1970s, the plant was converted to burn Western subbituminous coal. The conversion resulted in lower unit power ratings and necessitated the installation of larger electrostatic precipitators on Units 1–4 and Unit 6. This also included building a new stack for units 1–4. In addition, low NOx burners and overfire air ports have been installed on all of St. Clair's generating units. [7]

On August 11, 2016, at around 6:30 pm local time, a generation unit at St. Clair Power Plant caught fire. This led to a complete shutdown of all units at the plant. No injuries were reported as a result of the fire. [9] [10] The fire took 15 hours to extinguish. [11] Fire equipment was borrowed from across St. Clair County, from Detroit and nearby Canadian fire departments. [12]

DTE plans to retire the plant in 2022 following the commissioning of the new Blue Water Energy Center. [13]

Coal sources

Coal blend used

St. Clair burns a blend of low-sulfur Western coal (from the Decker (Powder River Basin) and Spring Creek mines in Montana) and high-sulfur Pittsburgh-seam Eastern coal. Blending is done in the coal yard with variable speed feeders. Although the nominal blend is 85% Western and 15% Eastern coal, the exact blend depends on a number of factors including demand requirements, coal prices, stockpile inventory, and unit availability. In the summer months, for example, the blend trends toward 70/30 on Units 6 and 7 to gain additional generating capacity by firing more Eastern coal with its higher heating value. The higher sulfur content of the Eastern coal also helps prevent opacity excursions with the electrostatic precipitator on Unit 7. [7]

Transportation and stockpiling

The Western coal is delivered to Superior, Wisconsin, by unit train and then barged to St. Clair on 60,000-ton ships. Because the ships typically cannot operate on the Great Lakes from late December until late March, the plant must stockpile between 2.1 and 2.4 million tons for the winter season. Eastern coal is delivered by rail to an unloading facility. Because of decline in production, the plant's seasonal stockpiling of Eastern coal declined from 140,000 tons to 20,000–30,000 tons in 2004. [7]

Operational data

St. Clair is a base load power plant, dispatched after DTE Energy's Fermi 2 nuclear unit and the neighboring Belle River coal-fired power plant. Between 1999 and 2003, St. Clair's capacity factor averaged 57%, plant heat rate averaged 10,449 British thermal units per kilowatt-hour (3.1 kWh/kWh), giving an plant efficiency of 32%, and the equivalent forced outage rate averaged 18%. [7]

Connections to power grid

The plant is connected to the power grid by 2 double circuit 345,000 and 5 120,000 volt transmission lines, owned and operated by ITC Transmission. The St. Clair has one 345 kV line (St. Clair-Lambton #1) and one 230 kV line (St. Clair-Lambton #2) that interconnect with Hydro One across the St. Clair River in Ontario, Canada. One of the wires of a 345 kV line enters a substation at the Belle River Power Plant.

Environmental impact

The St. Clair and Belle River Complex, along with the rest of Detroit Edison's generating facilities are ISO 14001 certified.

Sulfur dioxide

With its oldest unit dating back to the 1950s, the plant was ranked 74th on the United States list of dirtiest power plants in terms of sulfur dioxide emissions per megawatt-hour of electrical energy produced in 2006.[ citation needed ] Sulfur emissions could be lowered by using flue-gas desulfurization units, better known as SO2 "scrubbers", like those of Lambton Generating Station across the St. Clair River. Currently, these scrubbers are being installed at DTE's Monroe Power Plant, and may eventually be added at the St. Clair site as well.

Waste water

All of the waste heat generated by the plant (about twice its electrical output) is released into the St. Clair River. This water is used in large condensers to cool the used steam back to its liquid form. Water used in the condensers is treated, filtered, and replaced back into the river. Other water used on site for cleaning boilers and to drive the turbines is treated in settling ponds where ash and particulate are suspended from the water. The water is purified and pumped back to the river. The particulate is taken to the St. Clair/Belle River ash landfill a few miles north.

See also

Related Research Articles

<span class="mw-page-title-main">Trenton, Michigan</span> City in Michigan, United States

Trenton is a city in Wayne County, Michigan, United States. At the 2010 census, the city population was 18,853.

<span class="mw-page-title-main">DTE Energy</span> Energy company based in Detroit

DTE Energy is a Detroit-based diversified energy company involved in the development and management of energy-related businesses and services in the United States and Canada. Its operating units include an electric utility serving 2.2 million customers and a natural gas utility serving 1.3 million customers in Michigan.

DTE Electric Company was founded in 1886.

<span class="mw-page-title-main">Lansing Board of Water & Light</span>

The Lansing Board of Water & Light is a publicly owned, municipal utility that provides electricity and water to the residents of the cities of Lansing and East Lansing, Michigan, and the surrounding townships of Delta, Delhi, Meridian and DeWitt. The Lansing Board of Water & Light also provides steam and chilled water services within the City of Lansing. It is the largest public utility in Michigan.

The Keystone Generating Station is a 1.71-gigawatt, coal power plant located on roughly 1,500 acres (610 ha) in Plumcreek Township, southeastern Armstrong County, Pennsylvania near Crooked Creek, just west of Shelocta, Pennsylvania.

<span class="mw-page-title-main">W. H. Sammis Power Plant</span> Coal-fired power station in Jefferson County, Ohio

The W. H. Sammis Power Plant was a 2.23-gigawatt coal power plant in Stratton, Jefferson County, Ohio. The plant was operated by Energy Harbor. It began operations in 1960.

<span class="mw-page-title-main">Conemaugh Generating Station</span>

The Conemaugh Generating Station is a 1,872 MW baseload coal-powered plant located on 1,750 acres (710 ha), across the Conemaugh River from New Florence in Western Pennsylvania. Track 3 of the Norfolk Southern Pittsburgh line runs next to the power plant.

<span class="mw-page-title-main">Monroe Power Plant</span> Coal-fired power station located in Monroe, Michigan

The Monroe Power Plant is a coal-fired power plant located in Monroe, Michigan, on the western shore of Lake Erie. It is owned by the DTE Energy Electric Company, a subsidiary of DTE Energy. The plant was constructed in the early 1970s and began operating in 1971. The plant has 4 generating units, each with an output of 850 megawatts. With all four generating units operating, the plant's total output is 3,300 megawatts. This makes it the eleventh largest electric plant in the United States.

<span class="mw-page-title-main">Belews Creek Power Station</span>

Belews Creek Steam Station is a 2.24-GW, two-unit coal-fired generating facility located on Belews Lake in Stokes County, North Carolina. It is Duke Energy’s largest coal-burning power plant in the Carolinas and consistently ranks among the most efficient coal facilities in the United States. During 2006, it was the fifth most efficient coal power plant in the United States with a heat rate of 9,023 Btu/kWh. The remaining 62.2% of energy released by the burning coal is in the form of heat. It is dumped into Belews Lake, a man-made lake created by Duke Power for cooling water purposes in the early 1970s. In 2008, it was the #1 most efficient coal power plant in the United States with a heat rate of 9,204 British thermal units per kilowatt-hour (2.697 kWh/kWh) or 37.1% conversion efficiency.

<span class="mw-page-title-main">Zaporizhzhia thermal power station</span> Thermal power station in Enerhodar, Ukraine

Zaporizhzhia thermal power station is a large thermal power plant (DRES) in the purpose-built city of Enerhodar in Ukraine. It is the most powerful thermal power station in Ukraine, with an installed capacity of 2,850 MWe. Its primary fuel is coal. It can also fire natural gas and fuel oil, and has tank storage for these reserve fuels adjacent to the coal bunkers.

<span class="mw-page-title-main">Littlebrook Power Station</span> Series of four oil and coal-fired power stations in Dartford, Kent

The Littlebrook Power Station were a series of four oil and coal-fired power stations situated on the south bank of the River Thames, next to the Queen Elizabeth 2 Bridge and the Dartford Tunnel in Dartford, Kent. The final power station, Littlebrook D, ceased operating in March 2015, and has now been demolished.

<span class="mw-page-title-main">A. B. Brown Generating Station</span>

The A. B. Brown Generating Station is a four-unit, 700 megawatt (MW) power plant, located on the northern bank of Ohio River, 8 miles (10 km) east of Mount Vernon, Indiana and 5 miles (8 km) southwest of Evansville, Indiana just west of the Posey-Vanderburgh County Line. Each of the two coal-fired units has a name-plate capacity of 265.2 MW. Bituminous coal is used as a primary fuel type, which can be substituted for natural gas. There are also two gas turbine units, 88.2 MW of nameplate capacity each. The facility is owned by Centerpoint Energy. Vectren announced a plan to retire the plant in 2023 and replace it with a natural gas power plant; however, this plan needs to be approved by the Indiana Utility Regulatory Commission.

Belle River Power Plant is a major coal-and-natural gas-fired power plant owned by Detroit Edison, a subsidiary of DTE Energy. It is located in St. Clair County, Michigan, on the peninsula formed by the St. Clair and Belle rivers. The plant was built across M-29 from the St. Clair Power Plant in East China, Michigan, and shares the coal delivery terminal with it. The Belle River plant also shares cooling water from the St. Clair River with its sister plant. Five oil-fueled internal combustion generators were built in 1981, with a total output 13.75 megawatts. Coal-fired unit 1 of the Belle River plant was completed in 1984, followed by a similar unit 2 in 1985. Each unit has a nameplate capacity of 697.5 MWe, however the coal-fired plant as a whole generates 1260 MWe all year around. In 1999, three peaker natural-gas fired turbines were added, with a total name-plate capacity of 256 MWe.

The Charles P. Crane Generating Station was a 400 megawatt (MW) coal power plant located on the Carroll Island Road in Bowleys Quarters, Maryland, 14 miles (23 km) east of Baltimore. The power plant was operated by C.P. Crane, LLC, a subsidiary of Avenue Capital Group. The station had two coal-fired generating units, rated at 190 and 209 MW nominal capacity, and powered by cyclone steam boilers. It also had a 16 MW oil-fired combustion turbine. The Crane station occupies 157 acres (64 ha) on the Middle River Neck Peninsula adjacent to the Seneca Creek tributary of the Gunpowder River, and is on the rural side of the Baltimore County Urban Rural Demarcation Line. The plant was closed in June 2018 and demolished via building implosion in August 2022.

<span class="mw-page-title-main">Lambton Generating Station</span> Decommissioned coal-fired power station in Lambton County, Ontario

The Lambton Generating Station was a coal-fuelled power plant located on the St. Clair River near Corunna, Ontario, delivering up to 950 MW of power to the grid. It is owned by Ontario Power Generation.

<span class="mw-page-title-main">Trenton Channel Power Plant</span>

The Trenton Channel Power Plant, also known as the Trenton Stacks, was a coal-burning power station located in Trenton, Michigan. Completed in 1924, it is owned by Detroit Edison, a subsidiary of DTE Energy.

The George F. Weaton Power Station was a coal-fired power plant located in Potter Township, Beaver County, Pennsylvania, along the Ohio River. It was formerly owned by Horsehead Corporation and was completed in 1958 by Kaiser Engineers, later ICF International, at a cost of $30 million. Although the primary purpose of the plant was to supply power to the company's nearby zinc smelting operation, excess electricity could be sold to the local grid market via the site's 138,000 and 69,000 volt transmission lines, owned and operated by Duquesne Light. The power plant itself consisted of two 375,000 lb/h Combustion Engineering steam generators, two 55 megawatt Westinghouse tandem compound double flow steam turbines, and two 65 megawatt Westinghouse generators. The plant was idled in September 2011 and officially closed in July 2012, after more than 50 years of service.

Butibori Power Project is a coal-based thermal power plant located at Butibori near Nagpur in the Indian state of Maharashtra. The power plant is operated by the Reliance Power.

<span class="mw-page-title-main">Marysville Power Plant</span> Power plant

The Marysville Power Plant, nicknamed the Mighty Marysville, was a coal-fired power plant in Marysville, Michigan on the shore of the St. Clair River. The plant was demolished on November 7, 2015, after the land was sold to a developer.

References

  1. ↑ "Electric Power Monthly - U.S. Energy Information Administration (EIA)".
  2. ↑ "DTE Energy News Room – Detroit Edison History". dteenergy.mediaroom.com. Retrieved June 15, 2008.
  3. 1 2 "Existing Electric Generating Units in the United States, 2006" (Excel). Energy Information Administration, U.S. Department of Energy. 2006. Retrieved July 14, 2008.
  4. ↑ "Power Plants by State – DETROIT EDISON CO". powerplantjobs.com. Retrieved June 15, 2008.
  5. ↑ "St. Clair Power Plant remains closed following blaze". Detroit Free Press. August 12, 2016.
  6. ↑ "Electric Power Monthly - U.S. Energy Information Administration (EIA)". www.eia.gov. Retrieved October 5, 2020.
  7. 1 2 3 4 5 "St. Clair Power Plant". Power Engineering International. 2004. Retrieved March 4, 2009.
  8. ↑ "Coal-Fired Plants in Michigan". Power Plants Around the World. 2009. Archived from the original on July 18, 2009. Retrieved March 4, 2009.
  9. ↑ "No injuries reported in explosion and fire at DTE Energy facility in East China Township". WXYZ Detroit. August 11, 2016. Retrieved August 12, 2016.
  10. ↑ "Crews Battle Fire at Michigan Power Plant; No Injuries". ABC News. August 11, 2016. Archived from the original on August 18, 2016. Firefighters from across St. Clair County were called to the plant as thick, billowing black and gray smoke rose from the burning structure.
  11. ↑ "After 15 Hour Battle, Fire Finally Extinguished At DTE Power Plant In St. Clair County". CBS News. August 12, 2016. Archived from the original on August 13, 2016. 'At the height of the incident, every fire department in St. Clair County was involved,' said Jeff Friedland, director of Homeland Security Emergency Management for St. Clair County. 'We had mutual aid from Macomb County, Sanilac County, Lapeer County and also Ontario, and we also had assistance from the city of Detroit, their fire department sent their fire boat out to help us support water supply.'
  12. ↑ Dennis Walus (August 24, 2016). "DETROIT FIREBOAT PROVIDES MUTUAL AID AT POWER PLANT FIRE". Archived from the original on August 25, 2016. On Thursday, August 14, the Detroit Fire Department authorized the response of Fireboat 1. Squad 2 was dispatched to the fireboat quarters to man the vesselt, and Fireboat 1 got underway for the approximately 60-mile trip upriver. The trip to the fire scene took about four hours for the fireboat.
  13. ↑ "DTE to shut St. Clair plant, offer workers jobs elsewhere". Detroit Free Press. June 8, 2016.
This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.