United Airlines Flight 863

Last updated
United Airlines Flight 863
United747-400SFO.jpg
Boeing 747-400s of United Airlines at San Francisco International Airport; San Bruno Mountain rises to a peak of 1,319 feet (402 m) in the background, excluding radio towers.
Occurrence
DateJune 28, 1998 (1998-06-28)
SummaryNear-CFIT
Site San Bruno Mountain, after takeoff from San Francisco International Airport
Aircraft
Aircraft type Boeing 747-422
Operator United Airlines
IATA flight No.UA863
ICAO flight No.UAL863
Call signUNITED 863
Registration N?????
Flight origin San Francisco International Airport, San Mateo County, California
Destination Sydney Airport, Sydney, New South Wales, Australia
Occupants307
Passengers288
Crew19
Fatalities0
Injuries0
Survivors307

On June 28, 1998, United Airlines Flight 863, a Boeing 747-400 flying United's regularly scheduled transpacific service from San Francisco International Airport to Sydney Airport was forced to shut down one of its right-wing engines and nearly collided with San Bruno Mountain while recovering from the engine failure. The aircraft was able to dump fuel over the Pacific Ocean and return to San Francisco for an overweight landing, but the occurrence prompted United Airlines to change pilot training requirements.

Contents

Flight

Flight 863 to Sydney departed from San Francisco International Airport at 10:39 pm PST on Sunday June 28, 1998 (UTC: 5:39 am, 29 June). [1] As it took off, the Boeing 747-400 entered fog at the end of runway 28R. [2] After lifting off, the crew experienced a "loud thumping noise" accompanied by vibration just after the aircraft's landing gear had retracted. [2] The first officer was handling the takeoff under the captain's supervision, and since the noise occurred just after the landing gear had been retracted, at approximately 300 feet (90 m) above ground level, the first officer initially believed one of the tires had failed. [2] At the same time, the exhaust gas temperature of the #3 engine (the inboard engine on the starboard wing) rose to 750 °C (1,380 °F), exceeding the takeoff limit of 650 °C (1,202 °F). [2] With the first officer still flying, the captain retarded the #3 engine throttle to idle, which stopped the temperature rise and aircraft vibration. [2]

There were two non-flying relief pilots in the cockpit during takeoff; both noticed the aircraft had lost approximately 40 knots indicated airspeed after the problems with #3 engine and shouted 'airspeed' to the first officer to alert him to the potential stall danger. [2] At that point, the stick shaker system activated and the captain took over control of the aircraft. [2] The captain later stated he held the aircraft level to gain airspeed and avoid a stall, [2] but it had drifted to the right due to the imbalanced thrust and narrowly missed colliding with San Bruno Mountain, which rises to a height of 1,319 feet (402 m) above sea level, excluding the television and radio towers on its summit.

Illustration of roll, pitch, and yaw axes. Flight 863 attempted to correct for the right drift by using roll, rather than yaw. Yaw Axis Corrected.svg
Illustration of roll, pitch, and yaw axes. Flight 863 attempted to correct for the right drift by using roll, rather than yaw.

According to the cockpit voice and flight data recordings, rather than using the rudder, the first officer had tried to compensate for the right drift by turning the aircraft to the left using ailerons, which control the aircraft's longitudinal "roll" axis rather than the vertical "yaw" axis which would have been the correct response to compensate for an asymmetrical thrust condition. The use of ailerons also deployed spoilers on the "down" wing, which increased the aircraft's net drag and decreased its net lift. A second activation of the stick shaker stall warning resulted. [1] [3] The relief pilots urged the flight crew to enter a shallow dive to gain airspeed and avoid a stall, [1] [3] but this soon brought the aircraft close to San Bruno Mountain. The ground proximity warning system then alerted the captain, who had since taken over flying the aircraft, to pull up to avoid striking the hill. [3]

This photograph, taken from a blimp over Burlingame, California (foreground), shows the runways at SFO (in the middle of the picture) and their proximity to San Bruno Mountain (in the background). Zeppelin-ride-020100925-131 (5028699869).jpg
This photograph, taken from a blimp over Burlingame, California (foreground), shows the runways at SFO (in the middle of the picture) and their proximity to San Bruno Mountain (in the background).

By later accounts, the plane narrowly cleared San Bruno Mountain by only 100 feet (30 m). [1] The aircraft had approached San Bruno Mountain so closely that air traffic control radars briefly stopped detecting the aircraft. An air traffic controller in the San Francisco tower was conversing with one of her colleagues and said, "... Is United 863 still ... oh there he is, he scared me, we lost radar, I didn't want to give you another airplane if we had a problem." [1] [4] In total, the aircraft had disappeared from radar for approximately 15 seconds. [5] Residents in houses along the flight path, in South San Francisco, Daly City, and San Francisco, called into the airport to complain about the noise and voice their fears the aircraft was about to crash. [1]

After the near-collision, UA863 was vectored out to sea to dump fuel to reduce weight and return to San Francisco for an overweight landing. [2] During the initial climbout, the first officer stated he had noted the aircraft was handling sluggishly and was slow to climb, which he instinctively responded to by "[pulling] the nose up just a bit more to climb away from the ground." [2] The first officer had limited experience, having made only one takeoff and landing in a 747 during the year preceding the occurrence. [3]

Aftermath

United Airlines revised its training protocols after the incident by implementing much more rigorous standards, which ultimately became industry-wide standards. All 9,500 of United's pilots were shown a recreation of the occurrence, filmed in one of United's simulators. [3] As a compromise, pilots were required to make at least three takeoffs and landings in a 90-day period, of which at least one had to be in an actual aircraft. [1] [3] Aviation media consultant Barry Schiff noted the incident in an article decrying the lack of basic stick-and-rudder skills, especially among pilots who had never flown a light aircraft. [6]

Related Research Articles

<span class="mw-page-title-main">American Airlines Flight 191</span> 1979 DC-10 crash in Chicago, US

American Airlines Flight 191 was a regularly scheduled domestic passenger flight from O'Hare International Airport in Chicago to Los Angeles International Airport. On the afternoon of May 25, 1979, the McDonnell Douglas DC-10 operating this flight was taking off from runway 32R at O'Hare International when its left engine detached from the wing, causing a loss of control. The aircraft crashed about 4,600 feet (1,400 m) from the end of runway 32R. All 271 occupants on board were killed on impact, along with two people on the ground. With 273 fatalities, it is the deadliest aviation accident to have occurred in the United States.

Aviation is the design, development, production, operation, and use of aircraft, especially heavier-than-air aircraft. Articles related to aviation include:

<span class="mw-page-title-main">Japan Air Lines Flight 123</span> 1985 plane crash in Japan

Japan Air Lines Flight 123 was a scheduled domestic passenger flight from Tokyo to Osaka, Japan. On August 12, 1985, the Boeing 747 flying the route suffered a severe structural failure and decompression 12 minutes into the flight. After flying under minimal control for a further 32 minutes, it crashed in the area of Mount Takamagahara, 100 kilometres from Tokyo.

A deadstick landing, also called a dead-stick landing or volplaning, is a type of forced landing when an aircraft loses all of its propulsive power and is forced to land. The "stick" does not refer to the flight controls, which in most aircraft are either fully or partially functional without engine power, but to the traditional wooden propeller, which without power would just be a "dead stick". When a pilot makes an emergency landing of an aircraft that has some or all of its propulsive power still available, the procedure is known as a precautionary landing.

<span class="mw-page-title-main">Pilot error</span> Decision, action, or inaction by an aircraft pilot

In aviation, pilot error generally refers to an action or decision made by a pilot that is a substantial contributing factor leading to an aviation accident. It also includes a pilot's failure to make a correct decision or take proper action. Errors are intentional actions that fail to achieve their intended outcomes. The Chicago Convention defines the term "accident" as "an occurrence associated with the operation of an aircraft [...] in which [...] a person is fatally or seriously injured [...] except when the injuries are [...] inflicted by other persons." Hence the definition of "pilot error" does not include deliberate crashing.

<span class="mw-page-title-main">China Airlines Flight 006</span> 1985 aviation accident

China Airlines Flight 006 was a daily non-stop flight from Taipei to Los Angeles International Airport. On February 19, 1985, the Boeing 747SP operating the flight was involved in an aircraft upset accident, following the failure of the No. 4 engine, while cruising at 41,000 ft (12,500 m). The plane rolled over and plunged 30,000 ft (9,100 m), experiencing high speeds and g-forces before the captain was able to recover from the dive, and then to divert to San Francisco International Airport.

<span class="mw-page-title-main">Birgenair Flight 301</span> Aviation accident in 1996

Birgenair Flight 301 was a flight chartered by Turkish-managed Birgenair partner Alas Nacionales from Puerto Plata in the Dominican Republic to Frankfurt, Germany, via Gander, Canada, and Berlin, Germany. On 6 February 1996, the Boeing 757-200 operating the route crashed shortly after take-off from Puerto Plata's Gregorio Luperón International Airport, killing all 189 people on board. The cause was pilot error after receiving incorrect airspeed information from one of the pitot tubes, which investigators believe was blocked by a wasp nest built inside it. The aircraft had been sitting unused for 20 days, and without pitot tube covers in place for the preceding two days before the crash.

<span class="mw-page-title-main">TWA Flight 843</span> Air crash during takeoff in 1992

TWA Flight 843 was a scheduled Trans World Airlines passenger flight that crashed after an aborted takeoff from John F. Kennedy International Airport to San Francisco International Airport (California) on July 30, 1992. Despite an intense fire after the crash, the crew was able to evacuate all 280 passengers from the aircraft. There was no loss of life, although the aircraft was destroyed by the fire.

Landing High Japan (ランディングハイジャパン) is an arcade video game in which the object is to pilot a commercial airliner, taking off from and landing at several Japanese airports. It is a part of the Landing series of airline simulation arcade games which also includes Midnight Landing (1987), Top Landing (1988) and Landing Gear (1995).

<span class="mw-page-title-main">China Airlines Flight 605</span> 1993 aviation accident

China Airlines Flight 605 was a daily non-stop flight departing from Taipei, Taiwan at 6:30 a.m. and arriving in Hong Kong at 7:00 a.m. local time. On 4 November 1993, the aircraft went off the runway and overran attempting to land during a storm. It was the first hull loss of a Boeing 747-400.

Throughout a normal flight, a pilot controls an aircraft through the use of flight controls including maintaining straight and level flight, as well as turns, climbing, and descending. Some controls, such as a "yoke" or "stick" move and adjust the control surfaces which affects the aircraft's attitude in the three axes of pitch, roll, and yaw. Other controls include those for adjusting wing characteristics and those that control the power or thrust of the propulsion systems. The loss of primary control systems in any phase of flight is an emergency. Aircraft are not designed to be flown under such circumstances; however, some pilots faced with such an emergency have had limited success flying and landing aircraft with disabled controls.

<span class="mw-page-title-main">Empire Airlines Flight 8284</span> 2009 aviation accident

Empire Airlines Flight 8284 was a cargo flight operated by Empire Airlines for FedEx Feeder from Fort Worth Alliance Airport to Lubbock Preston Smith International Airport, Texas. On January 27, 2009, it crashed on final approach to its destination. Both crew members survived with minor injuries but the aircraft was written off.

<span class="mw-page-title-main">Olympic Airways Flight 411</span> 1978 near plane crash in Athens, Greece

Olympic Airways Flight 411 was a flight from Ellinikon International Airport bound for John F. Kennedy International Airport and operated by Olympic Airways using a Boeing 747-200. On August 9, 1978, the flight came close to crashing in downtown Athens. Despite maneuvers near the edge of the flight envelope, none of the 418 passengers and crew suffered serious injury.

<span class="mw-page-title-main">TWA Flight 5787</span> 1969 aviation accident

Trans World Airlines Flight 5787 was an unscheduled training flight of a Boeing 707 from Atlantic City Airport in Pomona, New Jersey in 1969. The flight was planned as a proficiency check, testing crew response to a simulated single-engine failure during takeoff and landing. Because of a fatigue failure of a hydraulic pipe, hydraulic power was lost while flying at low speed on three engines, resulting in loss of control and a crash killing all on board.

<span class="mw-page-title-main">Tower Air Flight 41</span> 1995 aviation accident

Tower Air Flight 41 was a scheduled domestic passenger flight from John F. Kennedy International Airport (JFK) in New York City, to Miami International Airport (MIA) in Florida. On December 20, 1995, the Boeing 747-100 operating the flight veered off the runway during takeoff from JFK. All 468 people on board survived, but 25 people were injured. The aircraft was damaged beyond repair and written off, making the accident the 25th hull loss of a Boeing 747. The National Transportation Safety Board (NTSB) concluded that the captain had failed to reject the takeoff in a timely manner.

<span class="mw-page-title-main">Japan Air Lines Cargo Flight 46E</span> 1993 Aviation accident over Alaska

Japan Air Lines Cargo Flight 46E was a scheduled cargo flight on 31 March 1993, operated by Evergreen International Airlines, on behalf of Japan Air Lines, from Anchorage International Airport, in Anchorage, Alaska, to O'Hare International Airport, in Chicago. After departure, while climbing through 2,000 feet, the pylon for engine two detached, causing the whole engine to fall off the wing. The pilots managed to land the 747 back at Anchorage without further incident.

<span class="mw-page-title-main">Philippine Air Lines Flight 741</span>

Philippine Air Lines Flight 741 was a domestic flight operated by Philippine Air Lines that crashed shortly after takeoff from Manila International Airport, Manila.

References

  1. 1 2 3 4 5 6 7 Carley, William M. (19 March 1999). "United 747's Near Miss Initiates A Widespread Review of Pilot Skills" . The Wall Street Journal. ISSN   0099-9660. Archived from the original on 8 January 2015. Retrieved 13 January 2017.
  2. 1 2 3 4 5 6 7 8 9 10 Flight Crew, UA863 (June 1998). "ACN 406810". Aviation Safety Reporting System. Retrieved 13 January 2017.{{cite web}}: CS1 maint: numeric names: authors list (link) Search for Report Number (ACN) 406810.
  3. 1 2 3 4 5 6 Johnson, Glen (20 March 1999). "United pilot inexperienced in landings nearly crashed 747". Pittsburgh Post-Gazette. Associated Press. Archived from the original on 17 December 2015. Retrieved 13 January 2017.
  4. ↑ Orr, Bob (15 April 1999). "A High-Flying Brush With Death". CBS News. Archived from the original on 25 August 2014. Retrieved 13 January 2017.
  5. ↑ "747 Just Missed San Bruno Mountain in June". San Francisco Chronicle. March 19, 1999. Retrieved 22 August 2019.
  6. ↑ Schiff, Barry (5 June 1999). "Proficient pilot: Lazy-rudder syndrome". Aircraft Owners and Pilots Association. Retrieved 13 January 2017.
This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.