Virginia City Hybrid Energy Center

Last updated
Virginia City Hybrid Energy Center
VCHEC Exterior.jpg
Exterior view of the Virginia City Hybrid Energy Center showing coal transportation belt, fuel mixing, and smokestack
Virginia City Hybrid Energy Center
CountryUnited States
Location Wise County, near St. Paul, Virginia
Coordinates 36°54′55″N82°20′23″W / 36.91528°N 82.33972°W / 36.91528; -82.33972
StatusOperational
Commission date 2012
Owner(s) Dominion Virginia Power
Operator(s)Dominion Virginia Power
Thermal power station
Primary fuel Coal
Biomass
Cooling source Clinch River
Power generation
Nameplate capacity 600 MW
[ edit on Wikidata]

The Virginia City Hybrid Energy Center (VCHEC) is a power station located in St. Paul, in Wise County, Virginia. It is operated by Dominion Virginia Power, Dominion Resources Inc.'s electric distribution company in Virginia. The 600 MW plant began power generation in July 2012 after four years of construction. The plant deploys circulating fluidized bed boiler technology (CFB) to use a variety of fuel sources including bituminous coal, coal gob (a waste product from abandoned coal mines), and bio-fuels. VCHEC is placed under stringent environmental regulations by the Virginia Department of Environmental Quality (DEQ).

Contents

The plant is required to close by 2045 under the Virginia Clean Economy Act of 2020, [1] though market forces will limit how much it actually operates to a capacity factor of below 20% and may close early. [2]

History

The cost for construction was around $1.8 billion USD, and the plant uses diverse fuel sources to produce energy, (making it unique compared to other energy plants). [3] This generation facility uses coal as well as waste coal (which are called gob piles) in order to produce energy. [4] Biomass can also be used for up to 20% of the fuel burned in the plant to create energy; as of November 2019, biomass accounted for 7% of input fuel. [5] The plant had some challenges during construction which had to be overcome. It was difficult for the builders of the plant to find places where the coal and wood could be stored because the plant was built in a mountainous region. The mountains did not allow for much expansion, so they decided to build the coal storage areas higher than the plant so that gravity would allow the coal to work its way down to the plant to be burned for energy. [6] During February 2012, very close to the end of construction, there was a fire on the roof of the building that contained the boilers. It damaged many circuits and part of the roof, but was only a minor setback for the construction of the plant and the schedule was only delayed by one week. [6] The Virginia City Hybrid Energy Plant has an excellent track record for safety. It was discovered that in 5 million hours of working the plant, there were no accidents that resulted in a loss of time. [7] The plant began generating electric power in July 2012, and has provided jobs around the area of St. Paul, Virginia. [8]

Production

Dominion’s Virginia City Hybrid Energy Center produces electricity by burning coal and coal gob. Due to the mountainous region, the storage of fuel is set around the plant in higher elevation areas to minimize the work necessary to move it and to take advantage of the space available. [9] Both the coal and biomass fuels are stored in quantities for ten days of operation. The fuel is then processed and moved to the two Foster Wheeler fuel-flexible CFB boilers to power a single 668-MW Toshiba steam turbine. [9] The air quality control equipment includes a dry scrubber, baghouse particulate filter, selective catalytic reduction system (SCR), and activated carbon injection system(mercury). [9] According to industry publications, VCHEC also improves upon water use and reuse, using about one-tenth of water use compared to coal plants of a similar size and "approaching zero wastewater discharge when the plant is operating.” [10] [11]

Environmental Impact and Pollution Production

Expected Impact and Pollution Production

The total amount of pollutants and other products, fossil fuel combustion byproducts (FFB), such as ash and limestone, expected to be emitted was 2.4 million tons because of the way the coal will be burned in a CFB. It was expected for these FFB's to solidify into a cement like substance, allowing for easier disposal. [12] Current estimated numbers for mercury deposited include a 10.2 pounds annually and 204 pounds over an estimated twenty year span of time. [13] 3.4 pounds of this mercury is expected to end up in the Chesapeake Bay Watershed. These numbers are assumed based on the permitted amount of mercury emitted, at 71.93 pounds per year. [13]

The combined effect of CFB's sulfur dioxide removal abilities and use of "dry scrubbers" is expected to remove 99.6 percent of the sulfur dioxide based on Dominion's numbers, and the Department of Environmental Quality gives a 98 percent removal rate for permitting. [14] The burning of gob coal is expected to remove hazardous waste from prior coal mines, preventing toxins from continuing to leach off of them. [15] The biomass used in VCHEC is carbon neutral because all biomass used comes from waste wood, so no timber is cut. The use of this biomass would produce ash and require a source of water as a coolant. [16]

Actual Impact and Pollution Production

Virginia City Hybrid Energy Center has been issued notice of violations for carbon monoxide, particulate matter, and sulfur dioxide. Carbon monoxide emissions during 2012 and early 2013 had three events for one CFB Unit and another three events for a second CFB Unit. Excess emission was at 49.58% for Unit 1 and 72.22% for Unit 2. These resulted from issues with the startup process. CFB Unit 1 had two events in 2013 with excess Sulfur Dioxide emissions as a result of fuel problems; the second one was caused by more fuel being fed than normal. [17] CFB Unit 2 had one Sulfur Dioxide excess emissions citation from an issue during the shut down process. [17]

Photograph of a coal gob pile, like the ones used as fuel for the Virginia City Hybrid Energy Center Waste coal pile (2006).jpg
Photograph of a coal gob pile, like the ones used as fuel for the Virginia City Hybrid Energy Center

The use of coal gob has removed hazardous waste sites from 1907, the Hurricane Creek gob pile, which put the Clinch River at risk. [18] This has allowed for a process removing over a century's worth of waste piles at risk of polluting the Clinch River and other water sources. [19] Around 1.5 million tons were removed from around the stream. [20] Between 2012 and 2014, 1.1 million tons of gob were used as fuel. [21] Waste produced by the plant consists of fly ash and coal ash which are stored in the Curley Hollow CCR Landfill with a collection system to prevent leaching. [22] During 2012, the facility was able to capture around 95% of the sulfur dioxide produced. Satellite Aerosol Data comparing VCHEC to another plant showed the same temporal changes in aerosol and nitrogen dioxide before and after VCHEC opened, but there was a clear change in maximum values after VCHEC began production, meaning the amount of emissions were happening at the same time as the other plant, but more was being emitted after VCHEC's construction. [23]

Controversy

Since Dominion Energy initially proposed plans for VCHEC in 2007 they have been met with opposition from five major environmental advocacy groups: The Sierra Club, Southern Environmental Law Center, Southern Appalachian Mountain Stewards, Appalachian Voices, and Chesapeake Climate Action Network. During initial planning of VCHEC these five groups campaigned the Commonwealth of Virginia to shift their energy plans to more renewable options and not approve the proposed coal fired power plant. [24]

After construction plans were approved by the Commonwealth of Virginia the Southern Environmental Law Center responded by filing an appeal on 22 April 2008 to the Supreme Court of Virginia on grounds that the construction approval violates the Commerce Clause of the Constitution of the United States. [24]

On 21 May 2008 protest groups, listed above, organized a protest of citizens who opposed the construction of VCHEC and delivered a ‘Mile Long’ petition to Dominion Headquarters. [25] The petition was literally a mile long of paper delivered during a shareholders meeting, this did not stop the groundbreaking of the facility on 14 August 2008. Only a month later on 15 September 2008, 11 activists were arrested following a protest which blockaded the VCHEC construction site. [26] Activists from Mountain Justice, Rainforest Action Network, Asheville Rising Tide, Blue Ridge Earth First!, and Students for Democratic Society. This protest did not hinder the construction of VCHEC.

These protests and the opposition against the construction of VCHEC was showcased in the documentary The Electricity Fairy directed by Tom Hansell for Appalshop Films. [27]

See also

Related Research Articles

<span class="mw-page-title-main">Coal</span> Combustible sedimentary rock composed primarily of carbon

Coal is a combustible black or brownish-black sedimentary rock, formed as rock strata called coal seams. Coal is mostly carbon with variable amounts of other elements, chiefly hydrogen, sulfur, oxygen, and nitrogen. Coal is a type of fossil fuel, formed when dead plant matter decays into peat and is converted into coal by the heat and pressure of deep burial over millions of years. Vast deposits of coal originate in former wetlands called coal forests that covered much of the Earth's tropical land areas during the late Carboniferous (Pennsylvanian) and Permian times.

<span class="mw-page-title-main">Gasification</span> Form of energy conversion

Gasification is a process that converts biomass- or fossil fuel-based carbonaceous materials into gases, including as the largest fractions: nitrogen (N2), carbon monoxide (CO), hydrogen (H2), and carbon dioxide (CO2). This is achieved by reacting the feedstock material at high temperatures (typically >700 °C), without combustion, via controlling the amount of oxygen and/or steam present in the reaction. The resulting gas mixture is called syngas (from synthesis gas) or producer gas and is itself a fuel due to the flammability of the H2 and CO of which the gas is largely composed. Power can be derived from the subsequent combustion of the resultant gas, and is considered to be a source of renewable energy if the gasified compounds were obtained from biomass feedstock.

<span class="mw-page-title-main">Solid fuel</span>

Solid fuel refers to various forms of solid material that can be burnt to release energy, providing heat and light through the process of combustion. Solid fuels can be contrasted with liquid fuels and gaseous fuels. Common examples of solid fuels include wood, charcoal, peat, coal, hexamine fuel tablets, dry dung, wood pellets, corn, wheat, rye, and other grains. Solid fuels are extensively used in rocketry as solid propellants. Solid fuels have been used throughout human history to create fire and solid fuel is still in widespread use throughout the world in the present day.

<span class="mw-page-title-main">Environmental impact of electricity generation</span>

Electric power systems consist of generation plants of different energy sources, transmission networks, and distribution lines. Each of these components can have environmental impacts at multiple stages of their development and use including in their construction, during the generation of electricity, and in their decommissioning and disposal. These impacts can be split into operational impacts and construction impacts. All forms of electricity generation have some form of environmental impact, but coal-fired power is the dirtiest. This page is organized by energy source and includes impacts such as water usage, emissions, local pollution, and wildlife displacement.

<span class="mw-page-title-main">Alternative fuel</span> Fuels from sources other than fossil fuels

Alternative fuels, also known as non-conventional and advanced fuels, are fuels derived from sources other than petroleum. Alternative fuels include gaseous fossil fuels like propane, natural gas, methane, and ammonia; biofuels like biodiesel, bioalcohol, and refuse-derived fuel; and other renewable fuels like hydrogen and electricity.

<span class="mw-page-title-main">Waste-to-energy plant</span> Building that incinerates unusable garbage

A waste-to-energy plant is a waste management facility that combusts wastes to produce electricity. This type of power plant is sometimes called a trash-to-energy, municipal waste incineration, energy recovery, or resource recovery plant.

<span class="mw-page-title-main">Fossil fuel power station</span> Facility that burns fossil fuels to produce electricity

A fossil fuel power station is a thermal power station which burns a fossil fuel, such as coal or natural gas, to produce electricity. Fossil fuel power stations have machinery to convert the heat energy of combustion into mechanical energy, which then operates an electrical generator. The prime mover may be a steam turbine, a gas turbine or, in small plants, a reciprocating gas engine. All plants use the energy extracted from the expansion of a hot gas, either steam or combustion gases. Although different energy conversion methods exist, all thermal power station conversion methods have their efficiency limited by the Carnot efficiency and therefore produce waste heat.

<span class="mw-page-title-main">Bioenergy</span> Energy made from recently-living organisms

Bioenergy is energy made or generated from biomass, which consists of recently living organisms, mainly plants. Types of biomass commonly used for bioenergy include wood, food crops such as corn, energy crops and waste from forests, yards, or farms. The IPCC defines bioenergy as a renewable form of energy. Bioenergy can either mitigate or increase greenhouse gas emissions. There is also agreement that local environmental impacts can be problematic.

<span class="mw-page-title-main">Coal pollution mitigation</span>

Coal Pollution Mitigation, sometimes also known as Clean Coal, is a series of systems and technologies that seek to mitigate health and environmental impact of coal; in particular air pollution from coal-fired power stations, and from coal burnt by heavy industry. Clean Coal primarily focuses on removing sulfur dioxide (SO2) and nitrogen oxides (NOx), the most important gasses that cause acid rain; and particulates which cause visible air pollution, illness, and premature deaths. It also reduces fly ash and reduces emissions of radioactive materials. Mercury emissions can be reduced by up to 95%. Capturing carbon dioxide emissions from coal is also being pursued.

An integrated gasification combined cycle (IGCC) is a technology using a high pressure gasifier to turn coal and other carbon based fuels into pressurized gas—synthesis gas (syngas). It can then remove impurities from the syngas prior to the electricity generation cycle. Some of these pollutants, such as sulfur, can be turned into re-usable byproducts through the Claus process. This results in lower emissions of sulfur dioxide, particulates, mercury, and in some cases carbon dioxide. With additional process equipment, a water-gas shift reaction can increase gasification efficiency and reduce carbon monoxide emissions by converting it to carbon dioxide. The resulting carbon dioxide from the shift reaction can be separated, compressed, and stored through sequestration. Excess heat from the primary combustion and syngas fired generation is then passed to a steam cycle, similar to a combined cycle gas turbine. This process results in improved thermodynamic efficiency, compared to conventional pulverized coal combustion.

<span class="mw-page-title-main">Waste-to-energy</span> Process of generating energy from the primary treatment of waste

Waste-to-energy (WtE) or energy-from-waste (EfW) is the process of generating energy in the form of electricity and/or heat from the primary treatment of waste, or the processing of waste into a fuel source. WtE is a form of energy recovery. Most WtE processes generate electricity and/or heat directly through combustion, or produce a combustible fuel commodity, such as methane, methanol, ethanol or synthetic fuels, often derived from the product syngas.

<span class="mw-page-title-main">Southeast Steam Plant</span> Heat and power plant in Minnesota

The Southeast Steam Plant, formerly known as the Twin City Rapid Transit Company Steam Power Plant, is a combined heat and power plant on the Mississippi River in the city of Minneapolis, Minnesota in the United States owned by the University of Minnesota.

<span class="mw-page-title-main">Coal-fired power station</span> Type of thermal power station

A coal-fired power station or coal power plant is a thermal power station which burns coal to generate electricity. Worldwide there are over 2,400 coal-fired power stations, totaling over 2,000 gigawatts capacity. They generate about a third of the world's electricity, but cause many illnesses and the most early deaths, mainly from air pollution.

<span class="mw-page-title-main">Appalachian Voices</span>

Appalachian Voices is an American environmental organization. Their stated environmental concerns include eliminating air pollution, ending mountaintop removal, cleaning up coal ash pollution and promoting renewable energy and energy efficiency.

<span class="mw-page-title-main">Dominion Energy</span> American energy company

Dominion Energy, Inc., commonly referred to as Dominion, is an American energy company headquartered in Richmond, Virginia that supplies electricity in parts of Virginia, North Carolina, and South Carolina and supplies natural gas to parts of Utah, Idaho and Wyoming, West Virginia, Ohio, Pennsylvania, North Carolina, South Carolina, and Georgia. Dominion also has generation facilities in Indiana, Illinois, Connecticut, and Rhode Island.

<span class="mw-page-title-main">Biomass briquettes</span> Fuel source made from green waste

Biomass briquettes are a biofuel substitute made of biodegradable green waste with lower emissions of greenhouses gases and carbon dioxide then traditional fuel sources. This fuel source is used as an alternative for harmful biofuels. Briquettes are used for heating, cooking fuel, and electricity generation usually in developing countries that do not have access to more traditional fuel sources. Biomass briquettes have become popular in developed countries due to the accessibility, and eco-friendly impact. The briquettes can be used in the developed countries for producing electricity from steam power by heating water in boilers.

<span class="mw-page-title-main">Bioenergy with carbon capture and storage</span>

Bioenergy with carbon capture and storage (BECCS) is the process of extracting bioenergy from biomass and capturing and storing the carbon, thereby removing it from the atmosphere. BECCS can be a "negative emissions technology" (NET). The carbon in the biomass comes from the greenhouse gas carbon dioxide (CO2) which is extracted from the atmosphere by the biomass when it grows. Energy ("bioenergy") is extracted in useful forms (electricity, heat, biofuels, etc.) as the biomass is utilized through combustion, fermentation, pyrolysis or other conversion methods.

<span class="mw-page-title-main">Environmental impact of the energy industry</span>

The environmental impact of the energy industry is significant, as energy and natural resource consumption are closely related. Producing, transporting, or consuming energy all have an environmental impact. Energy has been harnessed by human beings for millennia. Initially it was with the use of fire for light, heat, cooking and for safety, and its use can be traced back at least 1.9 million years. In recent years there has been a trend towards the increased commercialization of various renewable energy sources. Scientific consensus on some of the main human activities that contribute to global warming are considered to be increasing concentrations of greenhouse gases, causing a warming effect, global changes to land surface, such as deforestation, for a warming effect, increasing concentrations of aerosols, mainly for a cooling effect.

The John W. Turk Jr. Coal Plant is a base load 600-megawatt coal-fired power station in Fulton, Arkansas, operated by the American Electric Power subsidiary Southwestern Electric Power Company (SWEPCO). It provides power to customers in Arkansas, Louisiana, and Texas.

R.E. Burger Power Station was a 568 megawatt (MW), coal power plant located south of Shadyside, Ohio in Belmont County, Ohio. The plant closed in 2011. It was operated by FirstEnergy.

References

  1. ↑ COURIER, DAVID MCGEE | BRISTOL HERALD. "Virginia City hybrid coal plant to operate until 2045, officials say". Bristol Herald Courier - Tricities. Retrieved 2022-03-28.
  2. ↑ "IEEFA U.S.: Virginia coal plant's future isn't bright: preparation for transition should commence now". Institute for Energy Economics & Financial Analysis. 2020-12-16. Retrieved 2022-03-28.
  3. ↑ Martino, Justin (April 2013). "CO-FIRING WITH BIOMASS: A Look at the Virginia City Hybrid Energy Center". Power Engineering. 117 (4): 18–25.
  4. ↑ ""Virginia City Hybrid Energy Center Hits 5-year Anniversary"". 13 July 2017.
  5. ↑ ""Facing backlash, Dominion says it's willing to have coal plant removed from green energy package"". 25 November 2019.
  6. 1 2 "Virginia City Hybrid Energy Center, Virginia City, Virginia". Power: 46–47. October 2012.
  7. ↑ "Virginia City Hybrid Energy Center Project Reaches Safety Milestone". PR Newswire. 21 June 2010.
  8. ↑ ""Virginia City Hybrid Energy Center"". Archived from the original on 2018-06-12. Retrieved 2018-03-13.
  9. 1 2 3 "Activated Carbon Injection Systems".
  10. ↑ "TOP PLANT: Virginia City Hybrid Energy Center, Virginia City, Virginia". October 2012.
  11. ↑ "TOP PLANT: Virginia City Hybrid Energy Center, Virginia City, Virginia". October 2012.
  12. ↑ Thomson, Vivian (May 17, 2012). "Virginia City Hybrid Energy Center Response to Data Request" (PDF). p. 17.
  13. 1 2 "Request for Comments by Department of Environmental Quality on State Air Pollution Board Individual Member Correspondence on the Proposed Virginia City Hybrid Energy Center in Wise County, Virginia" (PDF). Archived from the original (PDF) on 2018-04-06. Retrieved 2018-04-05.
  14. ↑ Buckheit, Bruce. "Further Data Gathering Activities In Support of VAPCB Consideration of Permit Applications Respecting the Virginia City Hybrid Energy Center" (PDF). Archived from the original (PDF) on 2018-04-06. Retrieved 2018-04-05.
  15. ↑ COURIER, ALLIE ROBINSON GIBSON | BRISTOL HERALD. "Officials: VCHEC production unlikely to fall to struggling coal industry". SWVa Today. Retrieved 2018-03-12.
  16. ↑ "Response to Data Request Bruce Buckheit, Member, Virginia Air Pollution Control Board" (PDF). Archived from the original (PDF) on 2017-01-25. Retrieved 2018-04-05.
  17. 1 2 "STATE AIR POLLUTION CONTROL BOARD ENFORCEMENT ACTION — ORDER BY CONSENT ISSUED TO VIRGINIA ELECTRIC AND POWER COMPANY, D/B/A DOMINION VIRGINIA POWER FOR THE VIRGINIA CITY HYBRID ENERGY CENTER" (PDF). Archived from the original (PDF) on 2017-01-26. Retrieved 2018-04-05.
  18. ↑ "Virginia City Hybrid Energy Center Aids in Waste Coal Clean Up". www.power-eng.com. Retrieved 2018-03-12.
  19. ↑ "Savage Acquire Businesses Specializing in Removal of Waste Coal Piles". Savage Services. 2017-04-18. Retrieved 2018-03-12.
  20. ↑ County., Mark D. Mitchel is Vice President – Generation Construction at Dominion Energy Virginia. "Mitchell: Pumped storage project would generate millions for coalfields". Roanoke Times. Retrieved 2018-03-12.
  21. ↑ "Virginia City Hybrid Energy Center Helping to Clean Streams While Generating Electricity for Customers". Global Renewable News. Retrieved 2018-03-12.
  22. ↑ "2014 Coal Ash Management Report - Dominion Energy" (PDF). www.dominionenergy.com. Dec 31, 2014.
  23. ↑ "Monitoring the Effects of Power Plant Emissions on Air Quality Using NASA EOS" (PDF). Retrieved 2023-12-23.
  24. 1 2 "Virginia City Hybrid Energy Center". Sierra Club. Retrieved 15 March 2018.
  25. ↑ "Wise Up Dominion!".
  26. ↑ "Mountain Justice". www.mountainjustice.org. Retrieved 2018-04-10.
  27. ↑ Hansell, Tom, director. The Electricity Fairy. Appalshop Films, 2010.
This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.