![]() MV Florida Highway, structurally identical to Fremantle Highway | |
History | |
---|---|
Name | Fremantle Highway |
Owner | Shoei Kisen |
Operator | K Line |
Builder | Imabari Shipbuilding |
Launched | 30 September 2013 |
Identification |
|
Status | in repair in Rotterdam |
General characteristics | |
Type | Ro-ro/car carrier |
Tonnage | 59,525 GT 18,549 DWT |
Length | 199 m (653 ft) |
Beam | 32 m (105 ft) |
Installed power | 12.240 kW (16.642 PS) |
Propulsion | single shaft, 1 screw |
Speed | 21 kn (39 km/h; 24 mph) |
Capacity | 6,200 cars |
Crew | 23 |
MV Fremantle Highway is a car carrier owned by the Japanese tonnage provider Shoei Kisen Kaisha, while the vessel is technically managed by Wallem Shipmanagement Japanese and operated by "K"-Line. Fremantle Highway is Panamanian-flagged.
On the night of 25 July 2023, a fire broke out in the loading area of the ship in the North Sea off the coast of the Netherlands. One of the 23-man crew died; the rest were rescued. A salvage operation to prevent sinking and an oil spill lasted until 3 August 2023, when the ship was salvaged and towed to Eemshaven. The ship was towed again and arrived in Rotterdam on 23 September 2023 for an attempt to repair it.
The ship, which is 199 m (652 ft 11 in) long with a beam of 32 m (105 ft), is powered by a two-stroke eight-cylinder diesel engine with an output of 12,240 kW (16,410 hp ). The engine acts on a propeller. Four diesel generators with a total output of 4,750 kW are available for power generation. A stern ramp on the starboard side and a side ramp approximately in the middle on the starboard side are available for cargo handling. The rear ramp can be loaded with up to 100 t. The maximum ceiling height on the vehicle decks is 5.1 m (17 ft).
Fremantle Highway was built in 2013 under the yard number 1617 at the Japanese shipyard Imabari Zōsen. The keel was laid on 17 May and the launch took place on 30 September 2013. She was completed on 17 December 2013.
Fremantle Highway caught fire off the coast of the Dutch island of Ameland around 11.45 pm (CET) on 25 July 2023 while en route from Bremerhaven, Germany, due to arrive in Egypt's Port Said on 2 August 2023. K Line and Shoei Kisen Kaisha stated that the ship was bound for Singapore and carried approximately 3,000 cars. [1]
One of the 23-man crew died, [2] while the others were all evacuated on a helicopter and lifeboat by the Netherlands Coastguard. All the seafarers were Indian nationals; 16 of them were injured. Fremantle Highway was subsequently towed out of the main shipping lanes. [3]
The German company BLG stated that they had loaded 2,500 cars and "high and heavy" cargo on Fremantle Highway at the port of Bremerhaven in addition to already loaded cars. [4] On 28 July, it was reported that there were almost 500 electric cars on the ship, which was significantly more than originally assumed, although all were recovered without significant damage and did not contribute to the fire. A total of 3,783 new cars are on the ship, as reported by the Dutch media.
The fire and potentially sinking ship was causing environmental risks, as Ameland is in the Wadden Sea area spanning the Netherlands, Denmark and Germany and has been declared a UNESCO World Heritage Site, with more than 10,000 aquatic and terrestrial species. [1]
According to the German Federal Environment Ministry, there were 1,600 tons of heavy fuel oil (1.6 million litres) and a further 200 tons of marine diesel oil on board as ship fuel. [5]
Dutch and German tugboats and fireboats were ordered to attend to the burning ship, as well as an oil-recovery vessel in case of a leak. [6] The ship was at a position north of the island of Terschelling, between two very busy shipping routes to and from Germany. [7] The salvage operation was led by the Netherlands Rijkswaterstaat, joined by the Netherlands Coastguard and contracted salvage companies, like Smit International, Multraship Towage and Salvage and Boskalis. The owner of Fremantle Highway contracted the Dutch heavylift company Royal Boskalis Westminster for the salvage operation. [8]
Since there was a risk of the ship becoming unstable due to water accumulation, only the bow was cooled with water. A towing connection was established on 28 July. Since the fire broke out, the ship could not be dragged because of the effects of streaming conditions, tide and wind to the 199 m long and 30 m (98 ft 5 in) high ship. However, the position could be altered by the tugboats Fairplay-30 and others. [9]
On 29 July, Fremantle Highway was towed away from its dangerous berth, eastward off the Wadden Sea island of Schiermonnikoog. Strong south-westerly winds blew smoke from the cargo ship directly over the tug. The authorities temporarily stopped the operation. [10]
On the afternoon of 30 July, two tugs managed to start towing to the provisional sea position north of Schiermonnikoog. The ship remained there until a port was found. [7] The still-burning freighter arrived at its new provisional anchorage around midday on 31 July after a risky transport along the Wadden Sea islands. [11]
On 1 August, a team of experts went on board of Fremantle Highway and deemed there were no remaining visible fires and that the hull of the ship was in an acceptable condition. That night, the wind picked up and the waves got bigger. It became more difficult for the salvage team to keep the ship in position. Another towing connection was fitted on 2 August to connect the ship to tugs from the front and from the rear. [12] The CEO of the salvage company Boskalis warned that enormous forces were already acting on the ship's high flanks. If the wind got any stronger, there was a risk that the ship would no longer be controllable. The north-west wind forecast for the following days would drive the ship towards the coast, said Peter Berdowski of Boskalis. [12] The company wanted the ship to move to the port of Eemshaven on short notice, which was the closest to reach. [12]
Wind forces of 7 to 8 Beaufort were forecasted for the first weekend in August 2023. The high hull and thus very large surface wind attack surface caused the Dutch Minister of Infrastructure and Water Management, Mark Harbers, to have the ship towed to the port of Eemshaven, 64 km (40 mi) away from the latest holding position. The towing operation began on the morning of 3 August around 5 am. [13] The towing convoy with the wrecked ship arrived there at noon. [14]
There has been much speculation that the battery pack from an electric car caused the fire, but this proved to be wrong when offloading the ship. [15] [16] Around 1,000 cars were recovered in essentially good condition - among them all the 498 electrical cars which were on board the ship. [17] However, the cause of the fire is unknown. [18] Investigations started when the ship was moored in Eemshaven. [19] [20]
A spokesperson for the International Maritime Organization (IMO) said that, in light of the growing number of fires on cargo ships, IMO will announce new safety standards for those transporting electric vehicles in 2024. The guidelines could include specifications on how fully a battery can be charged. [21] The IMO said that chemicals for extinguishing fires, special fire blankets, equipment such as battery-penetrating jet extinguishers, and bigger gaps left between electric vehicles on ships, could also become mandatory. [21]
Christian Meyer, minister for the environment of Lower Saxony, a German coastline state, demanded better safety and environmental standards for commercial ships. High-risk ships should not take any coastal routes and thus endanger the Wadden Sea National Park. Meyer recalled the past ship disasters with the MSC Zoe, in which several containers fell overboard and landed near Borkum in 2019, and the Pallas, which was wrecked off the German island of Amrum in 1998. [22]
German nature conservation organization NABU demanded that the protection of the Wadden Sea should have priority over economic interests. They also stated that maritime traffic had to be reorganized around marine protected areas in order to comply with the EU biodiversity strategy, and that the transport of battery-powered vehicles had to be carried out under much stricter transport and fire protection regulations. Germany should play an active advocate for these regulations at the IMO in cooperation with the Netherlands and Denmark. [23]
Politicians of the Wadden Sea islands and nature conservationists are demanding that the southern route into the German Bight, which runs through the Wadden Sea, be closed to dangerous transport. [19]
After the ship's cargo was unloaded in Eemshaven, the Japanese shipping company wanted to clarify in August 2023 whether the ship could be repaired or whether it had to be scrapped. [19] Following the first sightings in Eemshaven, insurance companies were assuming that the freight was a total loss. It was estimated at around 300 million euros. [19] However assessment by a salvage contractor showed that decks 1 to 5 and the engine room were unaffected. [24]
On 19 August 2023, the unburned vehicles from the lower decks began to be disembarked. Before leaving the ship, the cars were washed to remove any remaining pollutants.
On 8 September 2023, Boskalis reported that the ship had been returned to its owner. [25]
Later the ship was bought by Koole Contractors from the insurer at a price of €1. [24]
The ship was towed to Rotterdam, where it arrived on 23 September 2023. [26] [27] There the ship was cleaned and about a third of the ship was dismantled, including most of the upper decks. Around 2800 burned car wrecks were removed from the ship. [24]
In the meantime the ship was bought by Qingshan Shipyard Group of Xiamen, China for €11 million. [28] The ship will be placed upon a semi-submersable salvage ship and transported to China, where new upper-decks will be built. Due to a global shortage of car carriers, the one-year rebuild would be cost effective compared to €100 million and 4 years of build time for a new car carrier. Before the transport, the ship will be renamed to Floor. [24]
Ameland is a municipality and one of the West Frisian Islands off the north coast of the Netherlands. It consists mostly of sand dunes and is the third major island of the West Frisians. It neighbours islands Terschelling to the west and Schiermonnikoog to the east. This includes the small Engelsmanplaat and Rif sandbanks to the east.
Hyundai Glovis Co., Ltd. is a logistics company headquartered in Seoul, South Korea and part of the Hyundai Motor Group. Its predecessor company, Hankook Logitech Co. Ltd was formed in February 2001. Hyundai Glovis supplies ocean transportation logistics advice, cargo space, loading/unloading, and packaging services. It changed its name to Hyundai Glovis in June 2003.
Kawasaki Kisen Kaisha, Ltd. is a Japanese transportation company. It owns a fleet that includes dry cargo ships, container ships, liquefied natural gas carriers, Ro-Ro ships, tankers, and container terminals. It used to be the fourteenth largest container transportation and shipping company in the world, before becoming part of Ocean Network Express in 2017.
Mediterranean Shipping Company S.A., branded as MSC, is an international shipping line founded by Gianluigi Aponte in Italy in 1970. The company is owned by the Aponte family with its headquarters in Geneva, Switzerland, since 1978. It is the world's largest container shipping company by both fleet size and cargo capacity, controlling 20 per cent of global container capacity as at July 2024.
MV Tricolor was a 50,000 tonne Norwegian-flagged vehicle carrier built in 1987, notable for having been involved in three English Channel collisions within a fortnight.
SS Atlantic Empress was a Greek oil tanker that in 1979 collided with the oil tanker Aegean Captain in the Caribbean, and eventually sank, having created the fifth largest oil spill on record and the largest ship-based spill having spilled 287,000 metric tonnes of crude oil into the Caribbean Sea. It was built at the Odense Staalskibsværft shipyard in Odense, Denmark, and launched on 16 February 1974.
Alkimos was a Greek-owned merchant ship which was wrecked on the coast north of Perth, Western Australia in 1963. A nearby locality was later named after the vessel. The wreck is a popular diving venue.
MV MSC Fortunate, was a container ship owned by Kosmo SVCS Inc., and previously registered to Hyundai Merchant Marine. She was completed in August 1996 and sailed under the flag of Panama. She had a gross tonnage of 64,054 and was capable of speeds of up to 25 knots. Her cargo capacity was 5,551 twenty-foot equivalent units (TEU).
The MV Cougar Ace was a Singapore-flagged roll-on/roll-off car carrier vessel. The Cougar Ace was built by Kanasashi Co., of Toyohashi, Japan and launched in June 1993. Specifications cite a length of 199m, draft of 9.72m, beam of 32.26m and a maximum speed of 18.6 knots. Her Gross Tonnage is 55,328. She is owned by Mitsui O.S.K. Lines.
Pasha Bulker, later known as MV Drake and now MV Anthea, is a Panamax bulk carrier of 76,741 tonnes deadweight (DWT) operated by the Lauritzen Bulkers shipping company and owned by Japanese Disponent Owners. While waiting in the open ocean outside Newcastle harbour to load coal, Pasha Bulker ran aground during a major storm on 8 June 2007 on Nobbys Beach, New South Wales, Australia. It was refloated and moved to a safe location offshore on 2 July 2007 before being towed to Japan for major repairs on 26 July 2007.
Pfalz was a 6,557-ton cargo steamer operated by German shipping company Norddeutscher Lloyd. The ship became the target of the first shot fired by Australian forces in World War I, soon after departing the Port of Melbourne in Australia.
The Grimaldi Group is a private shipping company owned by the Grimaldi family and based in Naples, Italy. Grimaldi operates a large fleet of ro-ro, ro-ro/multipurpose, con-ro multipurpose, PCTC, ro-pax and cruise ferries vessels.
MSC Flaminia is a German container ship which caught fire on 14 July 2012, claiming three lives and forcing the crew to abandon ship in the middle of the Atlantic Ocean. After the fire had been brought under control, the stricken container ship was towed to Europe and arrived at Wilhelmshaven, Germany, on 9 September 2012. In March 2013, she departed Wilhelmshaven for Mangalia, Romania for repairs which were finished in July 2014. The ship is currently sailing under the name CMA CGM San Francisco.
MV Baltic Ace was a Bahamian-flagged car carrier, that sank in the North Sea on 5 December 2012 after a collision with the Cyprus-registered container ship Corvus J. Built by Stocznia Gdynia in Poland, the ship had been in service since 2007.
K Line European Sea Highway Services GmbH (KESS) is a roll-on/roll-off shipping line based in Bremen, Germany and is a subsidiary of the Japanese shipping line K Line.
The MV Modern Express was a Panama-registered car carrier that developed a list in the Bay of Biscay in January 2016, while carrying earthmoving equipment, trucks and logs. It was a Pure Car Truck Carrier (PCTC) built in 2001 in South Korea, managed by Cido Shipping.
The German Central Command for Maritime Emergencies is the authority for mutual maritime emergency management in the German EEZ of North Sea and in the Baltic Sea. The federal office provides radar and air surveillance, piloting and emergency tugs for ships that are unable to manoeuvre. Head of CCME is Frigate captain Robby Renner.
Felicity Ace was a 60,000 tonne roll-on/roll-off cargo ship built by Shin Kurushima Dockyard in 2005. It was owned and operated by Mitsui O.S.K. Lines of Japan, and the ship was registered in Panama. She caught fire in February 2022 south of the Azores, whilst transporting vehicles from Germany to the United States. The ship then capsized and sank in early March with an estimated cargo worth over $400 million.
On 24 October 2023, one person was killed and four others disappeared after two cargo ships, the Isle of Man-flagged Verity and the Bahamian-flagged Polesie, collided in the North Sea near Germany's Heligoland islands, with the Verity sinking.