Mauro Solar Riser

Solar Riser
Role	Electric aircraft
National origin	United States
Manufacturer	Ultralight Flying Machines (UFM)
Designer	Larry Mauro
First flight	29 April 1979
Introduction	1979
Retired	1979
Status	Sole example in the EAA AirVenture Museum
Primary user	Larry Mauro
Produced	1979
Number built	One

The Mauro Solar Riser is an American biplane ultralight electric aircraft that was the first manned aircraft to fly on solar power. It was also only the second solar-powered aircraft to fly, after the unmanned AstroFlight Sunrise, which had first flown 4+1⁄2 years earlier. ^{[1] [2]}

Design and development

The president of Ultralight Flying Machines, Larry Mauro, created the Solar Riser by converting a stock UFM Easy Riser hang glider to solar power. Normally foot-launched, the Solar Riser had wheeled landing gear added. Power is supplied by a Bosch electric starter motor of 3.5 hp (2.6 kW) connected to a 30 volt DC Nickel-cadmium battery pack taken from a Hughes 500 helicopter, powering a 41 in (104.1 cm) propeller through a reduction drive made from a timing belt and two pulleys. The battery was charged by a series of photovoltaic solar panels mounted in the top wing that provided 350 Watts of power. The solar cells were not sufficient to provide all power in flight, so all flights were made by recharging the battery on the ground from the solar cells and then flying using energy stored in the battery. A charge in bright sunshine for an hour and a half yielded a flight of 3–5 minutes. ^{[1] [2]}

Because the battery power was enough to launch the aircraft for a soaring flight it was theoretically possible to launch on battery power, soar while the batteries are being charged by sunlight and then continue powered flight. The Solar Riser did not employ the most efficient cells available at the time and the upper wing had room for twice the number of cells to be installed. Early plans called for upgrading and increasing the number of cells so that sustained electric flight could be made using only solar energy and not battery power, but these plans were never completed. ^{[1] [2]}

Operational history

With Larry Mauro as the pilot, the Solar Riser made the first man-carrying flight on solar power at noon on 29 April 1979 at Flabob Airport at Rubidoux, California, near Riverside. The aircraft reached a maximum height of about 40 ft (12 m) and flew 0.5 mi (0.8 km). ^[3] A number of other flights of similar height and duration were flown, including demonstration flights at EAA AirVenture Oshkosh before the aircraft was retired to a museum. ^{[1] [2] [4]}

Aircraft on display

• EAA AirVenture Museum - sole example ^{[1] [2]}

Specifications (Solar Riser)

Data from EAA Museum ^[5] and AstroFlight ^[2]

General characteristics

• Crew: one
• Length: 8 ft 0 in (2.44 m)
• Wingspan: 30 ft 0 in (9.14 m)
• Empty weight: 123 lb (56 kg)
• Gross weight: 275 lb (125 kg)
• Powerplant: 1 × Bosch starter motor powered by a 30V DC 15 A-hour Nickel-cadmium battery, charged by a 36V 10A 350W solar array, 3.5 hp (2.6 kW)
• Propellers: 3 ft 7 in (1.09 m) diameter

Performance

• Maximum speed: 20 mph (32 km/h, 17 kn)
• Range: 0.50 mi (0.80 km, 0.43 nmi)
• Endurance: 3-5 minutes
• Service ceiling: 40 ft (12 m)

See also

• Renewable energy portal
• Energy portal

• Electric aircraft

Aircraft of comparable role, configuration, and era

• AstroFlight Sunrise
• Solar-Powered Aircraft Developments Solar One

References

1. Experimental Aircraft Association (2011). "UFM/MAURO SOLAR RISER" . Retrieved March 6, 2011.
2. AIAA/SAE/ASME 20th Joint Propulsion Conference (1984). "AIAA paper 84-1429" (PDF). Archived from the original (PDF) on July 7, 2011. Retrieved March 6, 2011.
3. "Era of Solar-Powered Airplane Begins With Half-Mile Flight", Sacramento (CA) Bee, April 30, 1979, p. 12
4. Glider Rider, June 1979 page 31 by Michael Jones
5. Experimental Aircraft Association (2011). "UFM/MAURO SOLAR RISER – Specifications" . Retrieved March 6, 2011.

External links

• Photo of Solar Riser