Champion Lancer

Last updated
Champion 402 Lancer
ChampionLancer-N9931Y.jpg
General information
TypeCivil training aircraft
Manufacturer Champion Aircraft Corporation
Number built25 [1] -36 [2]
History
Manufactured1963 [2] [1]
Introduction date1963
First flight1961 [2] [1]
Developed from Champion 7FC Tri-Traveler

The Champion 402 Lancer is a twin-engine trainer produced by Champion Aircraft, a high-wing monoplane based on the tricycle gear Champion 7FC Tri-Traveler, but with wing-mounted Continental O-200-A engines. [3] The Lancer first flew in 1961 and production began in 1963. [4] The Lancer seats two in a tandem configuration with dual flight controls; the pilot in command or student pilot normally occupies the front seat.

Contents

Design and development

The Lancer achieved its goal of being the least expensive American-built twin engine airplane. Other design goals included simplicity, ease of maintenance, low operating costs, and the ability to operate from rough or unimproved strips. The high wing and high engine position give good propeller clearance in achieving that last goal. The Lancer is of metal tube construction with fiberglass covering and has fixed landing gear and propellers. [2]

The Lancer was designed specifically for flight schools seeking an inexpensive way to train students for a multi-engine rating, a role in which the craft's modest performance and payload were anticipated to matter little. [3] To increase its appeal to flight schools, the Lancer has a mock landing gear retraction switch that operates green “safe” and red “unsafe” lights in the cockpit, allowing a student pilot to feign operation of retractable landing gear on takeoff and landing during instructional flights (the actual landing gear is permanently fixed). [5] In a peculiar combination, the front seat is equipped with a control yoke, while the rear-seat pilot has a centre stick. [N 1] Both seats are equipped with engine controls mounted overhead, with solo flight being performed from the front seat. Braking is controlled with a lever on the right-hand side of the front-seat instrument panel; differential braking is not possible, and no brake controls are provided for the rear-seat pilot. [3] [4] [5] Other features included single-slotted wing flaps with 4 adjustment positions, and pilot-adjustable trim tabs for the elevator and rudder; [3] [N 2] elevator trim is adjusted using a sidewall-mounted lever. [5] [N 3]

The prototype Lancer underwent development between 1961 and the start of production in 1963. The changes included relocating the engine nacelles to their final position above the wing, [2] strengthening the wings to accommodate the engines, and redesigning the empennage to provide for twin-engine control requirements. [3] The Federal Aviation Administration type certificate was approved on 7 March 1963. [6]

Flight characteristics

The Lancer's performance when flying on a single engine is notably poor; in a column for AOPA Pilot , author Barry Schiff summarized the airplane's single-engine performance by writing that "...it doesn’t have any". [5] Since the Lancer's fixed-pitch propellers cannot be feathered in flight, the failed engine's propeller generally continues to windmill, creating prodigious drag and yaw. [4] [5] [7] With the other engine delivering full power, the Lancer's advertised engine-out ceiling is only 2,000 feet (610 m) at standard temperature and pressure [4] [7] – an altitude below ground level in many geographical areas, particularly once adverse density altitude conditions are taken into account. An engine-out situation typically results in a descent rate of about 250 ft/min (1.3 m/s), [5] and the Lancer's single-engine, best-rate-of-climb speed VYSE–generally a gauge of engine-out climb performance for other airplanes–has been characterized as actually being a "single-engine, least-rate-of-coming-down-speed." [7] Flying magazine noted that the craft could generally maintain altitude at or below 2,200 feet (670 m) and was reasonably easy to fly at airfield traffic pattern altitude [N 4] on a single engine, but that an engine-out go-around would be potentially risky, and that a pilot is best advised "...to commit [himself or herself] to land–then land". [3]

Criticisms of the Lancer are not limited to its single-engine performance or lack thereof. The engine nacelle placement hampers visibility, [4] [5] [7] particularly for the rear-seat pilot, [5] and for both pilots during banked turns. [4] Schiff compares the engine nacelles to "...horse blinders that [result] in disorienting tunnel vision". [5] The close proximity of the engines and propellers to the front-seat pilot's head create elevated noise levels described as "remarkable" [4] or even "paralyzing". [7] The sidewall-mounted elevator trim lever looks very similar to the throttle lever of the single-engine Aeronca Champion, but pushing the lever forward results in nose-down trim rather than increased engine power as in most Champion types; this creates a risk that an experienced Champion pilot may confuse the two controls when piloting the Lancer, with potentially catastrophic consequences if he/she instinctively pushes the lever fully forward to arrest an unwanted rate of descent. [5] The 1 inch (25 mm) wide vertical center bar in the windshield impairs the pilot's view of the runway on landing. [3]

With both engines functioning, the Lancer is relatively slow in cruise and exhibits a mediocre climb rate, particularly given its twin-engine layout and resultant higher operating costs compared to a single-engine airplane. Its lackluster performance is generally attributed to abundant form drag from the wing and tailplane struts and unusually large strut-braced fixed main landing gear legs, which are about 3 inches (76 mm) in diameter and 5 feet (1.5 m) long. [3] [4] [5] In most respects, the Lancer's flight performance is equal or slightly inferior to that of the popular Cessna 150, [5] an airplane that uses a single O-200 engine rather than two. [8]

Operational history

A Champion Lancer, sitting derelict at Arlington Municipal Airport, Arlington, Washington, United States, in 2017 ChampionLancer402N9924Y.jpg
A Champion Lancer, sitting derelict at Arlington Municipal Airport, Arlington, Washington, United States, in 2017

Some flight schools initially viewed the Lancer's marginal single-engine performance favorably, as students trained in a Lancer found other twin-engine types comparatively easy to fly. [3] However, sales were very limited; production began in 1963 and ended later in the same year with only 25 [1] to 36 [2] aircraft built. As of March 2019, the highest serial number of any 402 Lancer in the FAA aircraft registry was 25. [9]

As of 2018, FAA flight test standards require a pilot to demonstrate feathering a propeller during the practical test to obtain a multiengine rating; [10] this effectively makes it impossible to complete the test in a Lancer with its fixed-pitch props.

Despite the aircraft's drawbacks, Lancer ownership has been described as potentially attractive because it is "...an oddity and rarity of aviation..." and "Its appearance does attract and invite attention." [4]

As of March 2019, nine Lancers remain on the FAA registry, [9] the type certificate is held by American Champion, [6] and the Lancer's ICAO aircraft type designator is CH40. [11] The National Transportation Safety Board Aviation Accident Database indicates that 12 accidents and incidents involving 9 individual Champion 402 aircraft occurred between 27 May 1964 and 27 July 1993 in the United States. [12] The only fatal Lancer accident in the database occurred on 18 January 1970 in Tarentum, Pennsylvania after a fuel system fault caused both engines to fail; the subsequent off-airport forced landing substantially damaged the aircraft and killed the pilot and sole occupant. [13] Of the 12 reported accidents and incidents, 4 involved single-engine operations. [14] [15] [16] [17]

Specifications (Champion 402)

Data from Flying , unless otherwise noted

General characteristics

Performance

Related Research Articles

<span class="mw-page-title-main">Landing</span> Transition from being in flight to being on a surface

Landing is the last part of a flight, where a flying animal, aircraft, or spacecraft returns to the ground. When the flying object returns to water, the process is called alighting, although it is commonly called "landing", "touchdown"a or "splashdown" as well. A normal aircraft flight would include several parts of flight including taxi, takeoff, climb, cruise, descent and landing.

<span class="mw-page-title-main">United Airlines Flight 232</span> 1989 aviation accident

United Airlines Flight 232 was a regularly scheduled United Airlines flight from Stapleton International Airport in Denver to O'Hare International Airport in Chicago, continuing to Philadelphia International Airport. On July 19, 1989, the DC-10 serving the flight crash-landed at Sioux Gateway Airport in Sioux City, Iowa, after suffering a catastrophic failure of its tail-mounted engine due to an unnoticed manufacturing defect in the engine's fan disk, which resulted in the loss of all flight controls. Of the 296 passengers and crew on board, 112 died during the accident, while 184 people survived. Thirteen of the passengers were uninjured. It was the deadliest single-aircraft accident in the history of United Airlines.

de Havilland Canada DHC-3 Otter Utility aircraft family

The de Havilland Canada DHC-3 Otter is a single-engined, high-wing, propeller-driven, short take-off and landing (STOL) aircraft developed by de Havilland Canada. It was conceived to be capable of performing the same roles as the earlier and highly successful Beaver, including as a bush plane, but is overall a larger aircraft.

<span class="mw-page-title-main">Rutan Long-EZ</span> Homebuilt aircraft with canard layout

The Rutan Model 61 Long-EZ is a tandem 2-seater homebuilt aircraft designed by Burt Rutan's Rutan Aircraft Factory. The Long-EZ has a canard layout, a swept wing with wingtip rudders, and a pusher engine and propeller. The tricycle landing gear has fixed main wheels with streamlined spats and a retractable nosewheel. Its predecessor was the VariEze, plans for which were first available to homebuilders in 1976. The prototype Long-EZ, N79RA, first flew on June 12, 1979.

<span class="mw-page-title-main">Mitsubishi MU-2</span> Utility transport aircraft

The Mitsubishi MU-2 is a Japanese high-wing, twin-engine turboprop aircraft with a pressurized cabin manufactured by Mitsubishi Heavy Industries. It made its maiden flight in September 1963 and was produced until 1986. It is one of postwar Japan's most successful aircraft, with 704 manufactured in Japan and San Angelo, Texas, in the United States.

<span class="mw-page-title-main">Piper PA-38 Tomahawk</span> Aircraft in Florida, US

The Piper PA-38-112 Tomahawk is a two-seat, fixed tricycle gear general aviation airplane, originally designed for flight training, touring and personal use.

<span class="mw-page-title-main">Cessna 402</span> American light twin-engine aircraft

The Cessna 401 and 402 are a series of 6 to 10 seat, light twin-piston engine aircraft. All seats are easily removable so that the aircraft can be used in an all-cargo configuration. Neither the Cessna 401 nor the 402 were pressurized, nor were they particularly fast for the installed power. Instead, Cessna intended them to be inexpensive to purchase and operate.

<span class="mw-page-title-main">Grand Aire Express</span>

Grand Aire Express was an American airline based in Swanton, Ohio, US. It operated passenger and cargo charter services worldwide, as well as charter management services. Its main base began in Monroe, Michigan and then moved to Toledo Express Airport, Toledo, Ohio. with additional bases in Louisville, KY and El Paso, TX. Grand Aire Express closed down/disestablished in June 2003; however, the parent company Grand Aire Inc., is still in operation, providing On-Demand Air Charter and FBOArchived February 4, 2012, at the Wayback Machine services from their world-headquarters at the Toledo Express Airport in Swanton, Ohio.

<span class="mw-page-title-main">Cirrus VK-30</span> Single-engine pusher-propeller homebuilt aircraft

The Cirrus VK-30 is a single-engine pusher-propeller homebuilt aircraft originally sold as a kit by Cirrus Design, and was the company's first model, introduced in 1987.

<span class="mw-page-title-main">Pinnacle Airlines Flight 3701</span> 2004 aviation accident

On October 14, 2004, Pinnacle Airlines Flight 3701 crashed near Jefferson City, Missouri, while flying from Little Rock National Airport to Minneapolis–Saint Paul International Airport. The two pilots, the only occupants, were killed. Federal investigators determined the crash was due to the pilots' unprofessional behavior and disregard for training and procedures.

<span class="mw-page-title-main">Berkut 360</span>

The Berkut 360 is a tandem-seating, two-seat homebuilt canard aircraft with pusher configuration and retractable landing gear, built primarily of carbon fiber and fiberglass.

<span class="mw-page-title-main">American Champion Scout</span> Two-seat, high-wing, single-engined airplane

The 8GCBC Scout is a two-seat, high-wing, single-engined fixed conventional gear general aviation airplane that entered production in the United States in 1974. Designed for personal and commercial use, it is commonly found in utility roles such as bush flying—thanks to its short takeoff and landing (STOL) ability—as well as agriculture, pipeline patrol, and glider and banner towing.

<span class="mw-page-title-main">Mineral Wells Airport</span> Airport in Texas

Mineral Wells Airport is a public airport four miles southeast of Mineral Wells, Texas. The National Plan of Integrated Airport Systems for 2011–2015 called it a general aviation facility. It is owned and operated by the city of Mineral Wells. The airport, and the city, lie in Palo Pinto County and Parker County. The terminal is in Parker County.

Aero Valley Airport is a privately owned, public use airport 3 nautical miles (5.6 km) northwest of Roanoke, in Denton County, Texas, United States.

<span class="mw-page-title-main">2011 Reno Air Races crash</span> P-51 Mustang crash in Nevada

On September 16, 2011, The Galloping Ghost, a highly modified North American P-51D Mustang racing aircraft, crashed into spectators while competing at the Reno Air Races in Reno, Nevada, killing the pilot, Jimmy Leeward, and ten people on the ground. Sixty-nine more people on the ground were injured. It was the third-deadliest airshow disaster in U.S. history, following accidents in 1972 and 1951.

<span class="mw-page-title-main">Rowley P-40F</span> American homebuilt aircraft

The Rowley P-40F was an American homebuilt aircraft that was designed by Richard J Rowley and marketed by his company 76th Fighter Squadron Inc, of Meadow Lake Airport, Colorado, first flown in 1986. When it was available the aircraft was supplied in the form of plans for amateur construction.

<span class="mw-page-title-main">2014 Wichita King Air crash</span> Aviation disaster in Kansas, US

On October 30, 2014, a Beechcraft King Air B200 twin turboprop crashed into a building hosting a FlightSafety International (FSI) training center shortly after taking off from Wichita Mid-Continent Airport in Wichita, Kansas. The pilot, the only person on board, was killed along with three people in the building; six more people in the building were injured.

<span class="mw-page-title-main">2019 Alaska mid-air collision</span> Collision of two sightseeing flights over George Inlet, Alaska

On May 13, 2019, a de Havilland Canada DHC-2 Beaver floatplane operated by Mountain Air Service collided with a Taquan Air de Havilland Canada DHC-3 Turbine Otter floatplane over George Inlet, Alaska, United States. The DHC-2 broke up in mid-air with the loss of all four passengers and the pilot. The DHC-3 pilot was able to maintain partial control, but the aircraft sustained substantial damage in the collision and the subsequent forced landing; the pilot suffered minor injuries, nine passengers suffered serious injuries, and one passenger was killed. Both aircraft were conducting sightseeing flights under visual flight rules, which state that the pilot of each aircraft is responsible for visually ensuring adequate separation from other air traffic, commonly known as "see and avoid".

<span class="mw-page-title-main">2019 Boeing B-17 Flying Fortress crash</span>

On October 2, 2019, a Boeing B-17 Flying Fortress privately owned by the Collings Foundation crashed at Bradley International Airport, Windsor Locks, Connecticut, United States. Seven of the thirteen people on board were killed, and the other six, as well as one person on the ground, were injured. The aircraft was destroyed by fire, with only a portion of one wing and the tail remaining.

References

Notes
  1. ↑ Single-engine tandem Champion models generally have centre sticks for both pilots, while the single-engine side-by-side Aeronca Chief family generally uses dual control yokes.
  2. ↑ Aileron trim was ground-adjustable only.
  3. ↑ The elevator trim lever in single-engine tandem Champion models is typically mounted overhead between the seats.
  4. ↑ The test flight was performed in and around Houston, Texas, a geographical area with an altitude very close to sea level, although density altitude is said to have been high during the test.
Citations
  1. 1 2 3 4 Simpson 1991, p. 12.
  2. 1 2 3 4 5 6 "Champion Lancer". www.planeandpilotmag.com. Plane & Pilot. 1 August 2009. Retrieved 21 November 2018.
  3. 1 2 3 4 5 6 7 8 9 Schlaeger, Gerald J. (January 1964). "Pilot Report: Champion Lancer". Flying : 45, 58, 60.
  4. 1 2 3 4 5 6 7 8 9 "N9931Y, The Unusual Twin Engine 1963 Champion Lancer 402, Rev. 1". Airport-Data.com. 5 March 2007. Retrieved 7 October 2014.
  5. 1 2 3 4 5 6 7 8 9 10 11 12 Schiff, Barry (April 2011). "Proficient Pilot". AOPA Pilot . 54 (4). Retrieved 7 October 2014.
  6. 1 2 3 4 "Type Certificate Data Sheet No. AC3E" (PDF). Federal Aviation Administration . Retrieved 23 March 2019.
  7. 1 2 3 4 5 "The Pilot's Lounge #126: The Less-Than-Great Planes". AVweb.com. 19 May 2008. Retrieved 7 October 2014.
  8. ↑ Simpson 1991, p. 96.
  9. 1 2 Federal Aviation Administration (23 March 2019). "Make and Model Inquiry Results, Champion 402" . Retrieved 23 March 2019.
  10. ↑ "Order 8900.2C: General Aviation Airman Designee Handbook" (PDF). www.faa.gov. Federal Aviation Administration. 26 June 2018. pp. 7–26. Retrieved 20 November 2018. The feathering of one propeller must be demonstrated in flight in multiengine airplanes equipped with propellers which can be feathered and unfeathered.
  11. ↑ "Aircraft type designators" (PDF). International Civil Aviation Organization. Retrieved 23 March 2019.
  12. ↑ National Transportation Safety Board (20 November 2018). "Make and Model Inquiry Results, Champion 402" . Retrieved 20 November 2018.
  13. ↑ National Transportation Safety Board (20 November 2018). "NTSB Identification: NYC70AN073" . Retrieved 20 November 2018.
  14. ↑ National Transportation Safety Board (20 November 2018). "NTSB Identification: Unknown" . Retrieved 20 November 2018.
  15. ↑ National Transportation Safety Board (20 November 2018). "NTSB Identification: Unknown" . Retrieved 20 November 2018.
  16. ↑ National Transportation Safety Board (20 November 2018). "NTSB Identification: NYC71DHH01" . Retrieved 20 November 2018.
  17. ↑ National Transportation Safety Board (20 November 2018). "NTSB Identification: FTW81FPD19" . Retrieved 20 November 2018.
Bibliography
This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.