Windflow Technology

Last updated

Windflow Technology
TypePublic
NZX: WTL
IndustryWind Power
Headquarters
Christchurch
,
New Zealand
Key people
Geoff Henderson
Products wind turbines
Revenue
  • NZ$1.8M (2016)
  • NZ$3.7M (2015)
  • NZ$2.1M (2014)

Windflow Technology was a company based in Christchurch, New Zealand known for its unique wind turbine gearbox design and two-bladed turbines.

Contents

Founded in 2000 the company was listed on the New Zealand Stock Exchange in 2003. [1] In October 2008, Mighty River Power purchased a 19.95% share of Windflow Technology. [2] [3] However the company delisted in November 2018 due to its uncertain future. [1]

History

Windflow's prototype wind turbine, installed at Gebbies Pass. Windflow's prototype windmill.jpg
Windflow's prototype wind turbine, installed at Gebbies Pass.

The operation of a Windflow Technology turbine installed at Gebbies Pass near Christchurch encountered opposition from local residents who raised concerns about noise. The neighbouring valley was very sheltered, and therefore had very little background sound. Because of this, Windflow offered to comply with low sound levels of 30 dBA, 10 dBA lower than the District Council's usual requirement of 40 dBA. However, sound levels were at 35 dBA, so Windflow modified the gearbox, which reduced the turbine's sound. Sound levels were again measured and this time they were within the requirement of its resource consent. [4] The turbine was dismantled in 2016. [5]

Windflow Technology set up New Zealand Windfarms to own and run the Te Rere Hau Wind Farm near Palmerston North. Initially, this was wholly owned but was sold off. [6] [7] Windflow Technology supplied 97 turbines for this wind farm [1] [8] It was also contracted to supply turbines for Mighty River Power's proposed Long Gully Wind Farm but Mighty River pulled out of the project. [9] [10]

The company achieved ISO 9001:2000 certification for the design and production of its Windflow 500 wind turbine in 2008. [11] In September 2010, the Windflow 500 gained Class 1A of the International Electrotechnical Commission (IEC) design standard IEC 61400-1 (edition 3) through Lloyd's Register. [11] [12] [13]

Although Windflow Technology signed a contract to install a Windflow 500 turbine on the island of Shetland in September 2011 it was not until 2012 that they announced their first export of their technology for a turbine on Westray, Orkney. [14] [15] The expansion into the UK was encouraged by the UK government's "feed-in tariff". [16] The company was to install eight turbines in Scotland. [17]

In February 2013, Windflow's first exported turbine (a 500 kW turbine) was installed at Hammer Farm on Westray. [18] One turbine was erected at New Holland Farm on the Orkney mainland. [19] [20] On Harris in the Outer Hebrides the North Harris Trust worked with Windflow Technology Ltd to install their two-bladed machines that can deal with the turbulent wind conditions found amongst the North Harris hills. Three turbines were installed at Monan in 2014–2015. [21] [22] Another turbine was installed at Ludenhill on Orkney, one at Easter Aberchalder, near Inverness, and one north of Edinburgh. [17] [23]

From March 2020 the UK turbines were maintained by Constantine Wind Energy. [1]

In March 2012, the company signed a licensing agreement with a subsidiary of large US company General Dynamics (GD Satcom) to manufacture and sell the Windflow designed 500 kW turbines to customers in North and South America, Africa and U.S. territories and military bases worldwide. [16]

In May 2015, Windflow Technology Ltd announced the installation and first operation of the prototype 45-500 wind turbine at a site in Mitchell County, Texas USA. The turbine was installed to supply power for the Mitchell County Desalination Plant, which will supplement water supplies to areas in the County not covered by municipal water utilities. [24] [25]

Windflow went into voluntary liquidation in December 2019. [1] [9] [26]

See also

Related Research Articles

<span class="mw-page-title-main">Genesis Energy Limited</span> New Zealand electricity generating and retailing company

Genesis Energy Limited, formerly Genesis Power Limited is a New Zealand publicly listed electricity generation and electricity, natural gas and LPG retailing company. It was formed as part of the 1998–99 reform of the New Zealand electricity sector, taking its generation capacity from the breakup of the Electricity Corporation of New Zealand (ECNZ) and taking retail customers from three local power boards in the Lower North Island. The New Zealand Government owns a 51% share of the company.

<span class="mw-page-title-main">Mercury Energy</span> New Zealand electricity generating and retailing company

Mercury NZ Limited is a New Zealand electricity generation and multi-product utility retailer of electricity, gas, broadband and mobile telephone services. All the company's electricity generation is renewable. Mercury has a pre-paid electricity product sub-brand GLOBUG. Mercury Energy is also the largest electricity retailer in New Zealand.

<span class="mw-page-title-main">Infratil</span> New Zealand investment company

Infratil Limited is a New Zealand-based infrastructure investment company. It owns renewable energy, digital infrastructure, airports, and healthcare assets with operations in New Zealand, Australia, Asia, the US and Europe. Infratil was founded by the late Lloyd Morrison, a Wellington-based merchant banker. Morrison's company, H. R. L. Morrison & Co, is responsible for Infratil's management and administration.

Community Energy Scotland is an independent Scottish charity established in 2008 that provides advice and financial support for renewable energy projects developed by community groups in Scotland. The stated aim of Community Energy Scotland is 'to build confidence, resilience and wealth at community level in Scotland through sustainable energy development'.

<span class="mw-page-title-main">Wind power in Australia</span>

Wind power is one of the main renewable energy sources in the world. In 2020, wind power contributed 10% of Australia's total electricity supply and 37.5% of its renewable energy supply.[1] Wind resource testing conditions in Australia are optimal, as abundant wind resources are located close to residential areas in the southern parts of the country and on the slopes of the Great Dividing Range in the east.[2] About half of the wind farms are located around the coast but none are positioned offshore.

<span class="mw-page-title-main">Renewable energy in Scotland</span>

The production of renewable energy in Scotland is a topic that came to the fore in technical, economic, and political terms during the opening years of the 21st century. The natural resource base for renewable energy is high by European, and even global standards, with the most important potential sources being wind, wave, and tide. Renewables generate almost all of Scotland's electricity, mostly from the country's wind power.

<span class="mw-page-title-main">Te Rere Hau Wind Farm</span> New Zealand wind farm company

Te Rere Hau is a wind farm owned and operated by New Zealand Windfarms Ltd. It is situated on the Tararua Ranges, approximately 11 km east of Palmerston North in New Zealand.

<span class="mw-page-title-main">European Marine Energy Centre</span>

The European Marine Energy Centre (EMEC) Ltd is a UKAS accredited test and research center focusing on wave and tidal power development based in the Orkney Islands, UK. The centre provides developers with the opportunity to test full-scale grid-connected prototype devices in unrivalled wave and tidal conditions.

<span class="mw-page-title-main">Wind power in New Zealand</span> Overview of wind power in New Zealand

Wind power constitutes a small but growing proportion of New Zealand's electricity. As of December 2020, wind power accounts for 690 MW of installed capacity and over 5 percent of electricity generated in the country.

<span class="mw-page-title-main">Tararua Wind Farm</span>

The Tararua Wind Farm is a wind farm owned and operated by Mercury NZ Ltd. It is located on 700ha of farmland on the Tararua Ranges of New Zealand. It has become New Zealand's largest capacity wind farm, with a total capacity of 161MW.

Turitea Wind Farm is a 222-megawatt wind farm near Turitea, Palmerston North, New Zealand. The farm is owned and operated by Mercury Energy.

Long Gully Wind Farm was a proposed wind farm in Wellington, New Zealand. Long Gully is an area adjacent to Zealandia.

The Harapaki Wind Farm is a wind farm project in the Hawke's Bay region of New Zealand. Construction began in June 2021 and is expected to continue for three years.

The Puketiro Wind Farm was a renewable energy project proposed for land owned by the Greater Wellington Regional Council (GWRC) in the Puketiro Forest near Pauatahanui, north of Wellington, New Zealand. However, the project did not subsequently proceed.

Xinjiang Goldwind Science & Technology Co., Ltd., commonly known as Goldwind, is a Chinese multinational wind turbine manufacturer headquartered in Beijing, China. Goldwind was a state-owned enterprise before 2007, with largest shareholders including Hexie Health Insurance, China Three Gorges Renewables Group, and the National Social Security Fund, state-controlled corporations holding almost 40% shares. Its founder, Wu Gang, is a Communist Party member and had a seat in the 12th National People's Congress.

<span class="mw-page-title-main">West of Duddon Sands Wind Farm</span>

West of Duddon Sands Wind Farm (WoDS), occasionally also known as West Duddon Wind Farm is an offshore wind farm located 14 kilometres (8.7 mi) south west of Walney Island off the coast of Barrow-in-Furness in Cumbria, in the Irish Sea, England. It was developed by Scottish Power and Ørsted A/S.

<span class="mw-page-title-main">WEL Networks</span> New Zealand electricity distribution company

WEL Networks Limited is an electricity distribution company, serving the northern and central Waikato region of New Zealand. WEL is the sixth largest electricity distribution company in New Zealand, with 100,142 connections and 7,021 km (4,363 mi) of lines and underground cables. The company is 100% owned by the WEL Energy Trust.

The Waipipi Wind Farm is a wind powered electricity generation project in New Zealand owned and operated by Mercury NZ Ltd. This site is located between Patea and Waverley in South Taranaki. The wind farm consists of 31 wind turbines over 980 hectares, generating up to 133 MW at a cost of approximately $277 million. The 4.3 MW machines are the largest wind turbines installed in New Zealand.

The Puketoi Wind Farm is a proposed wind farm project in the Tararua District of New Zealand. The project is planned by Mercury Energy.

References

  1. 1 2 3 4 5 Harris, Catherine (22 December 2019). "Wind turbine maker Windflow Technology put into liquidation". Stuff. Retrieved 6 June 2020.
  2. ↑ "Mighty River Power takes stake in NZ's Windflow". Reuters. 16 October 2008. Retrieved 6 June 2020.
  3. ↑ "Windflow attracts Mighty River Power" (Press release). New Zealand Stock Exchange. 30 June 2008. Retrieved 19 September 2008.
  4. ↑ "Windflow gets ok for Christchurch turbine". The Press. 9 October 2004.
  5. ↑ Hutching, Chris (23 August 2017). "Windflow sorts $21m debt, agrees to Gebbies Pass turbine conditions". Stuff. Retrieved 6 June 2020.
  6. ↑ Steeman, Marta (27 November 2014). "Windflow aims another blow at NZ Windfarms". Stuff. Retrieved 6 June 2020.
  7. ↑ Law, Tina (1 July 2008). "Generator buys Windflow stake". The Press.
  8. ↑ "Wind bridges energy shortfall", Electrical Automation, August/September 2007.
  9. 1 2 Evans, Gavin (24 December 2019). "Wind turbine business Windflow Technology runs out of time, money". The New Zealand Herald. ISSN   1170-0777 . Retrieved 6 June 2020.
  10. ↑ Heather, Ben (9 June 2010). "Mighty River pulls out of wind project". Stuff. Retrieved 6 June 2020.
  11. 1 2 "Windflow marks Major Engineering Achievement - NZX, New Zealand's Exchange". www.nzx.com. 15 September 2010. Retrieved 6 June 2020.
  12. ↑ "Windflow turbine wins OK". The Timaru Herald. 16 October 2010.
  13. ↑ "Windflow marks Major Engineering Achievement". www.scoop.co.nz. 15 September 2010. Retrieved 6 June 2020.
  14. ↑ BusinessDesk (23 September 2011). "Windflow Technology signs first UK turbine deal | Stuff.co.nz". Stuff. Retrieved 23 September 2011.{{cite web}}: |author= has generic name (help)
  15. ↑ Heatley, Phil (18 October 2012). "Export of Windflow Technology wind turbine". The Beehive. Retrieved 6 June 2020.
  16. 1 2 Hartley, Simon (4 March 2013). "Windflow chases UK, US markets". Otago Daily Times Online News. Retrieved 6 June 2020.
  17. 1 2 "Projects – Windflow Technology Ltd - UK". 26 December 2016. Archived from the original on 26 December 2016. Retrieved 6 June 2020.
  18. ↑ "Chch wind company seizes lucrative UK Energy offer". www.scoop.co.nz. 19 March 2013. Retrieved 6 June 2020.
  19. ↑ "Windflow to ship second 500-kW turbine to UK". Renewablesnow.com. Retrieved 6 June 2020.
  20. ↑ "New Holland Farm – Windflow Technology Ltd - UK". 5 November 2016. Archived from the original on 5 November 2016. Retrieved 6 June 2020.
  21. ↑ "North Harris Trust. Wind Turbines". www.north-harris.org. Retrieved 6 June 2020.
  22. ↑ "Monan – Windflow Technology Ltd - UK". 2 November 2016. Archived from the original on 2 November 2016. Retrieved 6 June 2020.
  23. ↑ "Windflow Technology Preliminary Announcement - NZX, New Zealand's Exchange". www.nzx.com. 14 September 2017. Retrieved 6 June 2020.
  24. ↑ "New Prototype Turbine Commissioned in Texas - NZX, New Zealand's Exchange". www.nzx.com. Retrieved 5 June 2020.
  25. ↑ "Two-Bladed Wind Turbine Powers Texas Desalination Plant". North American Windpower. 1 May 2015. Retrieved 5 June 2020.
  26. ↑ Harris, Catherine (24 December 2019). "Founder of failed Windflow Technology still sees opportunity for wind power". Stuff. Retrieved 6 June 2020.

Further reading

This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.