Mission type | Flight test |
---|---|
Operator | SpaceX |
Mission duration | 1 hour, 6 minutes, 10 seconds |
Orbits completed | <1 |
Spacecraft properties | |
Spacecraft | Starship Ship 29 |
Spacecraft type | Starship |
Manufacturer | SpaceX |
Start of mission | |
Launch date | June 6, 2024, 12:50:00 UTC (7:50 am CDT) [1] |
Rocket | Super Heavy (B11) |
Launch site | Starbase, OLM-A |
End of mission | |
Landing date | |
Orbital parameters | |
Regime | Suborbital [2] |
Apoapsis altitude | 213 km (132 mi) [3] |
Inclination | 26.8° [4] |
![]() Mission patch |
Starship flight test 4 was the fourth flight test of the SpaceX Starship launch vehicle. The prototype vehicles flown were the Starship Ship 29 upper-stage and Super Heavy Booster 11. [5] [6] SpaceX performed the flight test on June 6, 2024.
The main test objectives of this flight, both of which were accomplished, were for the Super Heavy booster to simulate a landing at a "virtual tower" just above the surface of the Gulf of Mexico, and for Starship to survive at least peak heating during atmospheric re-entry. [7]
This marked the first integrated test flight where both Starship and Super Heavy successfully reentered and performed a powered vertical landing over the ocean surface.
Starship flight test 3 in March 2024 attained full duration burns of both stages and reached orbital velocity. However, both stages were destroyed during atmospheric return, prompting a SpaceX-led mishap investigation overseen by the FAA. The FAA stated that a completed license modification, incorporating corrective actions and meeting other requirements, was required for a launch license to be granted for this flight, the fourth flight test. [8] [9]
SpaceX stated in early April that it would intend to attempt a booster landing with the tower arms on the fifth flight test if the booster virtual landing is successful during the fourth flight test. [10] In late April, a NASA official confirmed SpaceX remained on track for the fourth test flight to occur in May 2024. [11]
The communications license necessary for Flight 4 was granted by the FCC on April 18. [12] On May 17, SpaceX asked that the FAA make a public safety determination regarding the third flight test, which would allow SpaceX to launch the test flight while the mishap investigation is in progress if determined there was no public safety danger. [13] The FAA concluded the investigation on May 28 and determined that the third flight test had not threatened public safety. [14] [15] SpaceX received regulatory approval to launch from the FAA on June 4. [16]
Starship flight test 4 was initially scheduled to launch on June 5, but was pushed back a day to June 6. [17] For this fourth flight test, the FAA listed three specific outcomes that would not trigger a mishap-investigation: the ship burning up during reentry, the flaps not having sufficient control of the ship, or the Raptor 2 engines failing to relight for landing. [18]
Booster 11 and Ship 29 were first spotted around August 2022. Both stages underwent multiple cryogenic proof tests in late 2023, with Ship 29 performing a spin prime test in March 2024. [19] Following Starship's third test flight, Ship 29 was lifted onto Suborbital Pad B for two static fire tests in late March, and was later returned to the High Bay for pre-flight modifications. A 33-engine static-fire was conducted on Booster 11 on Orbital Launch Mount A on April 5. Booster 11's hot-staging ring was installed in early May. [20] Ship 29 was lifted onto Booster 11 on May 15, [21] followed by a partial propellant load test on May 16. [22] A wet dress rehearsal (WDR) was conducted on May 20. [23]
On May 28, SpaceX performed a second wet dress rehearsal of S29 and B11, [24] and on May 30, SpaceX installed the flight termination system (FTS or AFSS) on B11 and S29. [25] On June 5, S29 was stacked on top of B11 for the fourth and final time. [19] SpaceX intentionally omitted two TPS (Thermal Protection System) tiles and replaced one with a thinner tile to test how the loss of tiles would affect the ship. [26]
During Starship's third test flight, the booster was destroyed just before splashdown due to engine failures caused by filter blockage of liquid oxygen to the engines. The ship was destroyed during reentry, due to excessive roll rates caused by clogged roll control valves. As a result, modifications were made to Booster 11's oxygen tanks to improve propellant filtration capability, while hardware and software changes were implemented to improve Raptor startup reliability. Additional roll control thrusters were added to the ship to improve attitude control redundancy. [27] [28]
Several changes were spotted on Ship 29, including updates to the TPS tile adhesive and layout. B11 received upgrades such as reinforcements of tanks and additions to improve rigidity and durability. [29] The largest horizontal tanks in the orbital tank farm were made operational, supplementing the older vertical tanks that were being retired. Suborbital Pad B was decommissioned in May 2024, and vehicle testing operations were moved to Massey's Test Site to make room for the construction of Orbital Launch Mount B. [30]
The mission profile for Starship flight test 4 was very similar to that of the third flight test, with the propellant transfer demonstration, the payload bay door demonstration, and the Raptor engine relight demonstration being omitted. There was also the addition of the jettisoning of the Super Heavy's hot staging ring two seconds after the shutdown of the boostback burn, and Starship was to attempt a landing flip and landing burn. [31] [32]
One of the 33 Raptor engines on Booster 11 failed to stay lit during the initial burn, and one of the thirteen used for the landing burn failed to light. Neither engine failure affected the outcome of the flight because of redundancy in the multiple-engine design. To reduce mass during descent, a temporary design change on this test flight was used to jettison the booster hot-staging ring. [33] [ non-primary source needed ] Longer term, the hot-staging ring is intended to be redesigned for lighter weight and tight integration with the booster and will not be jettisoned.
B11 successfully conducted a powered vertical landing over the Gulf of Mexico, splashing down into the ocean. [34]
After completing the engine burn to an orbital energy trajectory, Ship 29 successfully re-entered the atmosphere, maintaining attitude control despite significant visible damage to the structure and loss of some number of heat shield tiles. Following the hypersonic velocity descent through the atmosphere, S29 performed a powered vertical landing above the ocean before splashing into the Indian Ocean. [35] Elon Musk said that the ship maintained subsonic control but landed approximately 6km away from the target splashdown location. [36]
Time | Event | June 6, 2024 |
---|---|---|
−01:15:00 | SpaceX Flight Director conducts a poll and verifies go for propellant loading | Success |
−00:49:00 | Starship fuel loading (liquid methane) underway | Success |
−00:47:00 | Starship oxidizer loading (liquid oxygen) underway | Success |
−00:40:00 | Super Heavy fuel loading (liquid methane) underway | Success |
−00:37:00 | Super Heavy oxidizer loading (liquid oxygen) underway | Success |
−00:19:40 | Booster engine chill | Success |
−00:03:30 | Booster propellant load complete | Success |
−00:02:50 | Ship propellant load complete | Success |
−00:00:30 | SpaceX flight director verifies GO for launch | Success |
−00:00:10 | Flame deflector activation | Success |
−00:00:03 | Booster engine ignition | 33 engines ignited with 1 shutting down at T+00:00:03 |
00:00:02 | Liftoff | Success |
00:01:02 | Max q during ascent (moment of peak mechanical stress on the rocket) | Success |
00:02:46 | Booster most engines cutoff (MECO) | Success |
00:02:51 | Starship engine ignition and stage separation (hot-staging) | Success |
00:02:57 | Booster boostback burn startup | Success |
00:03:47 | Booster boostback burn shutdown | Success |
00:04:04 | Hot-stage jettison | Success |
00:07:04 | Booster is transonic | Success |
00:07:09 | Booster landing burn startup | 12 of 13 engines ignited [37] |
00:07:30 | Booster landing burn shutdown and splashdown | Success |
00:08:37 | Starship engine cutoff (SECO) | Success |
00:44:54 | Starship entry | Vehicle damaged on re-entry |
01:00:50 | Estimated time of max q during Starship's descent | Success |
01:03:17 | Starship is transonic | Success |
01:03:38 | Starship is subsonic | Success |
01:05:36 | Starship landing flip | Success |
01:05:39 | Starship landing burn | Success |
01:05:56 | Starship splashdown | Within the target area but 6 km off the center of the target |
The flight was hailed as a success and marked the first time the Super Heavy booster and Ship achieved controlled splashdowns. A FAA clause for Flight 4, which would allow SpaceX to continue with additional flights of the same profile without a mishap investigation as long as no public safety issues occurred, was upheld as the flight did not encounter a mishap outside of the three exceptions. [38] [39] On June 12, the FAA announced that they would not be requiring a mishap investigation for Flight 4 because all flight events occurred within the scope of planned and authorized activities. [40] This was the first Starship flight test to not require an investigation.
A reusable launch vehicle has parts that can be recovered and reflown, while carrying payloads from the surface to outer space. Rocket stages are the most common launch vehicle parts aimed for reuse. Smaller parts such as rocket engines and boosters can also be reused, though reusable spacecraft may be launched on top of an expendable launch vehicle. Reusable launch vehicles do not need to make these parts for each launch, therefore reducing its launch cost significantly. However, these benefits are diminished by the cost of recovery and refurbishment.
Falcon 9 is a partially reusable, human-rated, two-stage-to-orbit, medium-lift launch vehicle designed and manufactured in the United States by SpaceX. The first Falcon 9 launch was on 4 June 2010. The first Falcon 9 commercial resupply mission to the International Space Station (ISS) launched on 8 October 2012. In 2020 it became the first commercial rocket to launch humans to orbit. In 2022, it became the U.S. rocket with the most launches in history and with a near perfect safety record, having suffered two flight failures.
Falcon 9 prototypes were experimental flight test reusable rockets that performed vertical takeoffs and landings. The project was privately funded by SpaceX, with no funds provided by any government until later on. Two prototypes were built, and both were launched from the ground.
SpaceX manufactures launch vehicles to operate its launch provider services and to execute its various exploration goals. SpaceX currently manufactures and operates the Falcon 9 Block 5 family of medium-lift launch vehicles and the Falcon Heavy family of heavy-lift launch vehicles – both of which are powered by SpaceX Merlin engines and employ VTVL technologies to reuse the first stage. As of 2024, the company is also developing the fully reusable Starship launch system, which will replace the Falcon 9 and Falcon Heavy.
SpaceX has privately funded the development of orbital launch systems that can be reused many times, similar to the reusability of aircraft. SpaceX has developed technologies over the last decade to facilitate full and rapid reuse of space launch vehicles. The project's long-term objectives include returning a launch vehicle first stage to the launch site within minutes and to return a second stage to the launch pad, following orbital realignment with the launch site and atmospheric reentry in up to 24 hours. SpaceX's long term goal would have been reusability of both stages of their orbital launch vehicle, and the first stage would be designed to allow reuse a few hours after return. Development of reusable second stages for Falcon 9 was later abandoned in favor of developing Starship, however, SpaceX developed reusable payload fairings for the Falcon 9.
Starbase is an industrial complex for Starship rockets, located near Brownsville, Texas, United States. It has been under construction since the late 2010s by SpaceX, an American aerospace manufacturer. Starbase is composed of a spaceport near the Gulf of Mexico, a production facility at the Boca Chica village, and a small structure test site along the Texas State Highway 4.
As of 2023, SpaceX operates four launch facilities: Cape Canaveral Space Launch Complex 40 (SLC-40), Vandenberg Space Force Base Space Launch Complex 4E (SLC-4E), Kennedy Space Center Launch Complex 39A (LC-39A), and Brownsville South Texas Launch Site (Starbase). Space Launch Complex 40 was damaged in the AMOS-6 accident in September 2016 and repair work was completed by December 2017. SpaceX believes that they can optimize their launch operations, and reduce launch costs, by dividing their launch missions amongst these four launch facilities: LC-39A for NASA launches, SLC-40 for United States Space Force national security launches, SLC-4E for polar launches, and South Texas Launch Site for commercial launches.
The Falcon 9 first-stage landing tests were a series of controlled-descent flight tests conducted by SpaceX between 2013 and 2016. Since 2017, the first stage of Falcon 9 missions has been routinely landed if the rocket performance allowed it, and if SpaceX chose to recover the stage.
Starship is a two-stage fully reusable super heavy-lift launch vehicle under development by SpaceX. As of July 2024, it is the most massive and powerful vehicle ever to fly. SpaceX has developed Starship with the intention of lowering launch costs using economies of scale. SpaceX aims to achieve this by reusing both rocket stages, increasing payload mass to orbit, increasing launch frequency, creating a mass-manufacturing pipeline and adapting it to a wide range of space missions. Starship is the latest project in SpaceX's reusable launch system development program and plan to colonize Mars.
Falcon 9 booster B1048 was a reusable orbital-class Block 5 Falcon 9 first-stage booster manufactured by SpaceX. B1048 was the third Falcon 9 Block 5 to fly and the second Block 5 booster to re-fly. It became the second orbital-class booster to fly a third time and is the first booster ever to be launched five times. B1048 service came to an end on its fifth flight when an engine shut down prematurely on launch. Whilst the primary mission was unaffected and the Starlink payload deployed successfully, B1048 was unable to land. In a subsequent investigation, SpaceX found that isopropyl alcohol, used as cleaning fluid, was trapped and ignited causing the engine to be shut down. To address the issue, in a following launch SpaceX indicated that the cleaning process was not done.
SpaceX Starship flight tests include fifteen launches to date of prototype rockets during 2019–2024 for the SpaceX Starship launch vehicle development program. Eleven test flights were of single-stage Starship spacecraft flying low-altitude tests (2019–2021), while four were orbital trajectory flights of the entire Starship launch vehicle (2023–2024), consisting of a Starship spacecraft second-stage prototype atop a Super Heavy first-stage booster prototype. None of the flights to date has carried an operational payload. Additional flight tests are planned in 2024.
Raptor is a family of rocket engines developed and manufactured by SpaceX. A notable trait of this engine family is the use of a full-flow staged combustion cycle (FFSC). They are powered by cryogenic liquid methane and liquid oxygen, a mixture known as methalox.
Starship flight test 1 was the maiden flight of the integrated SpaceX Starship launch vehicle. SpaceX performed the flight test on April 20, 2023. The prototype vehicle was destroyed less than four minutes after lifting off from the SpaceX Starbase in Boca Chica, Texas. The vehicle became the most powerful rocket ever flown, breaking the half-century-old record held by the Soviet Union's N1 rocket. The launch was the first "integrated flight test," meaning it was the first time that both the Super Heavy booster and the Starship spacecraft flew together as a fully integrated Starship launch vehicle.
Super Heavy is the first stage of the SpaceX Starship super heavy-lift launch vehicle, which it composes in combination with the Starship second-stage. As of 2024, Super Heavy prototypes are being flight tested. Super Heavy flew for the first time on April 20, 2023, during the first orbital launch attempt of the Starship rocket.
Starship is a spacecraft and second stage under development by American aerospace company SpaceX. Stacked atop its booster, the Super Heavy, it composes SpaceX's new super heavy-lift space vehicle, also called Starship. The spacecraft is designed to transport both crew and cargo to a variety of destinations, including Earth orbit, the Moon, and Mars. It is intended to enable long duration interplanetary flights with a crew of up to 100 people. It will also be capable of point-to-point transport on Earth, enabling travel to anywhere in the world in less than an hour. Furthermore, the spacecraft will be used to refuel other Starship vehicles to allow them to reach higher orbits and other space destinations. Elon Musk, the CEO of SpaceX, estimated in a tweet that 8 launches would be needed to completely refuel a Starship in low Earth orbit, extrapolating this from Starship's payload to orbit and how much fuel a fully fueled Starship contains. To land on bodies without an atmosphere, such as the Moon, Starship will fire its engines and thrusters to slow down.
Starship flight test 2 was the second flight test of the SpaceX Starship launch vehicle. SpaceX performed the flight test on November 18, 2023. The mission's primary objectives were for the vehicle to hot stage—a new addition to Starship's flight profile—followed by the second stage attaining a near-orbital trajectory with a controlled reentry over the Pacific Ocean, while the booster does a boostback burn with a propulsive splashdown in the Gulf of Mexico.
Starship flight test 3 was the third flight test of the SpaceX Starship launch vehicle. SpaceX performed the flight test on March 14, 2024.
Starship flight test 5 will be the fifth flight test of a SpaceX Starship launch vehicle. The prototype vehicles planned to be flown are the Ship 30 upper-stage and Booster 12. This fifth flight test is expected to include the first attempted "catch" of the Super Heavy booster using the Orbital Launch Mount tower at the Starbase launch site.
Starship flight test 6 will be the sixth flight test of a SpaceX Starship launch vehicle. According to NASASpaceflight, the prototype vehicles expected to be flown are the Ship 31 upper-stage and Booster 13.