Shuttle Carrier Aircraft

Last updated

Shuttle Carrier Aircraft
NASA's Shuttle Carrier Aircraft 905 (front) and 911 (rear).jpg
NASA's Shuttle Carrier Aircraft 905 (front) and 911 (back)
Role Outsize cargo freight aircraft
Manufacturer Boeing
First flight18 February 1977
Introduction1977
Retired2012
StatusRetired, both aircraft preserved
Primary users NASA
Boeing
Number built2
Developed from Boeing 747-100

The Shuttle Carrier Aircraft (SCA) are two retired extensively modified Boeing 747 airliners that NASA used to transport Space Shuttle orbiters. One (N905NA) is a 747-100 model, while the other (N911NA) is a short-range 747-100SR.

Contents

The SCAs were used to ferry Space Shuttles from landing sites back to the Shuttle Landing Facility at the Kennedy Space Center. The orbiters were placed on top of the SCAs by Mate-Demate Devices, large gantry-like structures that hoisted the orbiters off the ground for post-flight servicing then mated them with the SCAs for ferry flights.

In approach and landing test flights conducted in 1977, the test shuttle Enterprise was released from an SCA during flight and glided to a landing under its own control. [1]

Design and development

The Lockheed C-5 Galaxy was considered for the shuttle-carrier role by NASA but rejected in favor of the 747. This was due to the 747's low-wing design in comparison to the C-5's high-wing design, and also because the U.S. Air Force would have retained ownership of the C-5, while NASA could own the 747s outright.

Shuttle Carrier Aircraft N905NA, still in American Airlines livery, with Enterprise in 1978 Shuttle Enterprise at Ellington Airfield 1978 4.jpg
Shuttle Carrier Aircraft N905NA, still in American Airlines livery, with Enterprise in 1978

The first aircraft, a Boeing 747-123 registered N905NA, was originally manufactured for American Airlines. With a decline in air traffic and failure to fill their 747s, American Airlines sold it to NASA. It still wore the visible American cheatlines while testing Enterprise in the 1970s. It was acquired in 1974 and initially used for trailing wake vortex research as part of a broader study by NASA Dryden, as well as Shuttle tests involving an F-104 flying in close formation and simulating a release from the 747.

The aircraft was extensively modified for NASA by Boeing in 1976. [2] While first-class seats were kept for NASA passengers, its main cabin and insulation were stripped, [3] and the fuselage was strengthened. Mounting struts were added on top of the 747, located to match the fittings on the Shuttle that attach it to the external fuel tank for launch. [4] With the Shuttle riding on top, the center of gravity was altered. Vertical stabilizers were added to the tail to improve stability when the Orbiter was being carried. The avionics and engines were also upgraded.

An internal escape slide was added behind the flight deck [5] in case of catastrophic failure mid-flight. In the event of a bail-out, explosives would be detonated to make an opening in the fuselage at the bottom of the slide, allowing the crew to exit through the slide and parachute to the ground. The slide system was removed following the Approach and Landing Tests because of concerns over the possibility of escaping crew members being ingested into an engine. [6]

Flying with the additional drag and weight of the Orbiter imposed significant fuel and altitude penalties. The range was reduced to 1,000 nautical miles (1,900 km; 1,200 mi), compared to an unladen range of 5,500 nautical miles (10,200 km; 6,300 mi), requiring an SCA to stop several times to refuel on a transcontinental flight. [7] Without the Orbiter, the SCA needed to carry ballast to balance its center of gravity. [3] The SCA had an altitude ceiling of 15,000 feet (4,600 m) and a maximum cruise speed of Mach 0.6 with the orbiter attached. [7] A crew of 170 took a week to prepare the shuttle and SCA for flight. [8]


Studies were conducted to equip the SCA with aerial refueling equipment, a modification already made to the U.S. Air Force E-4 (modified 747-200s) and 747 tanker transports for the IIAF. However, during formation flying with a tanker aircraft to test refueling approaches, minor cracks were spotted on the tailfin of N905NA. While these were not likely to have been caused by the test flights, it was felt that there was no sense taking unnecessary risks. Since there was no urgent need to provide an aerial refueling capacity, the tests were suspended.

Atlantis atop Shuttle Carrier Aircraft N905NA after being repainted with NASA livery in 1998 Atlantis on Shuttle Carrier Aircraft.jpg
Atlantis atop Shuttle Carrier Aircraft N905NA after being repainted with NASA livery in 1998

By 1983, SCA N905NA no longer carried the distinct American Airlines tricolor cheatline. NASA replaced it with its own livery, consisting of a white fuselage and a single blue cheatline. [9] That year, after secretly being fitted with an infrared countermeasures system to protect it from heat-seeking missiles, [10] it was also used to fly Enterprise on a tour in Europe, with refueling stops in Goose Bay, Canada; Keflavik, Iceland; England; and West Germany. It then went to the Paris Air Show. [8]

Shuttle Carrier Aircraft N911NA, shortly after purchase, with newly built shuttle Endeavour in 1991. SCA and Endeavour at Ellington Field, 1991.jpg
Shuttle Carrier Aircraft N911NA, shortly after purchase, with newly built shuttle Endeavour in 1991.

In 1988, in the wake of the Challenger accident, NASA procured a surplus 747SR-46 from Japan Airlines. Registered N911NA, it entered service with NASA in 1990 after undergoing modifications similar to N905NA. It was first used in 1991 to ferry the new shuttle Endeavour from the manufacturers in Palmdale, California to Kennedy Space Center.

Humorous note on mount reminding technicians how to connect the orbiter to the SCA Shuttle mounting point.JPG
Humorous note on mount reminding technicians how to connect the orbiter to the SCA

Based at the Dryden Flight Research Center within Edwards Air Force Base in California [3] the two aircraft were functionally identical, although N911NA has five upper-deck windows on each side, while N905NA has only two.

The rear mounting points on both aircraft were labeled with humorous instructions to "attach orbiter here" or "place orbiter here", clarified by the precautionary note "black side down". [11] [12]

Shuttle Carriers were capable of operating from alternative shuttle landing sites such as those in the United Kingdom, Spain, and France. Because Shuttle Carrier's range is reduced while mated to an orbiter, additional preparations such as removal of the payload from the orbiter may have been necessary to reduce its weight. [13]

Boeing transported its Phantom Ray unmanned combat aerial vehicle (UCAV) demonstrator from St. Louis, Missouri, to Edwards on a Shuttle Carrier Aircraft on December 11, 2010. [14]

Approach and Landing Tests

Space Shuttle Enterprise detaches from Shuttle Carrier Aircraft N905NA during ALT-13 OV-101 first flight.jpg
Space Shuttle Enterprise detaches from Shuttle Carrier Aircraft N905NA during ALT-13

The Approach and Landing Tests were a series of taxi and flight trials of the prototype Space Shuttle Enterprise, conducted at Edwards Air Force Base in 1977. They verified the shuttle's flight characteristics when mated to the Shuttle Carrier Aircraft and when flying on its own, prior to the Shuttle system becoming operational. There were 3 taxi tests, 8 captive flight tests and 5 free flight tests. [5]

Ferry flights

Atlantis being mated to Shuttle Carrier Aircraft N911NA at using the Mate-Demate Device Shuttle mate demate facility.jpg
Atlantis being mated to Shuttle Carrier Aircraft N911NA at using the Mate-Demate Device

During the decades of Shuttle operations, the SCAs were most often used to transport the orbiters from Edwards Air Force Base, the shuttle's secondary landing site, to the Shuttle Landing Facility (SLF) at the Kennedy Space Center where the orbiter was processed for another launch. The SCAs were also used to transport the orbiters between manufacturer Rockwell International and NASA during initial delivery and mid-life refits. [15]

At the end of the Space Shuttle program the SCA was used to deliver the retired orbiters from the Kennedy Space Center to their museums.

Discovery was flown to the Udvar-Hazy Center of the Smithsonian Institution's National Air and Space Museum at the Dulles International Airport on April 17, 2012, making low-level passes over Washington, D.C. landmarks before landing. Enterprise, which had been on display at the Smithsonian was transported to the Intrepid Sea, Air & Space Museum in New York City on April 27, 2012, making low-level passes over the city's landmarks, before landing at John F. Kennedy International Airport, where it was transferred by barge to the museum.

The last ferry flight took Endeavour from Kennedy Space Center to Los Angeles between September 19 and 21, 2012 with refueling stops at Ellington Field and Edwards Air Force Base. After leaving Edwards the SCA with Endeavour performed low level flyovers above various landmarks across California, from Sacramento to the San Francisco Bay Area, before finally being delivered to Los Angeles International Airport (LAX). From there the orbiter was transported through the streets of Los Angeles and Inglewood to its final destination, the California Science Center in Exposition Park.

Retirement

N911NA sits on display at the Joe Davies Heritage Airpark in Palmdale, California, in June 2015 Shuttle Carrier Aircraft N911NA on display in Palmdale, California in June 2015.jpg
N911NA sits on display at the Joe Davies Heritage Airpark in Palmdale, California, in June 2015

Shuttle Carrier N911NA was retired on February 8, 2012, after its final mission to the Dryden Flight Research Facility at Edwards Air Force Base in Palmdale, California, and was used as a source of parts for NASA's Stratospheric Observatory for Infrared Astronomy (SOFIA) aircraft, another modified Boeing 747. [16] N911NA is now preserved and on display at the Joe Davies Heritage Airpark in Palmdale, California as part of a long-term loan to the city from NASA. [17] [18]

N905NA on display with mockup Space Shuttle Independence at Space Center Houston Shuttle Independence and NASA 905 at Space Center Houston.jpg
N905NA on display with mockup Space Shuttle Independence at Space Center Houston

Shuttle Carrier N905NA was used to ferry the retired Space Shuttles to their respective museums. After delivering Endeavour to the Los Angeles International Airport in September 2012, the aircraft was flown to the Dryden Flight Research Facility, where NASA intended it to join N911NA as a source of spare parts for NASA's SOFIA aircraft, [16] [19] but when NASA engineers surveyed N905NA they determined that it had few parts usable for SOFIA. In 2013, a decision was made to preserve N905NA and display it at Space Center Houston with the mockup Space Shuttle Independence mounted on its back. [20] N905NA was flown to Ellington Field where it was carefully dismantled, ferried to the Johnson Space Center in seven major pieces (a process called The Big Move), reassembled, and finally mated with the replica shuttle in August 2014. [21] The display, called Independence Plaza, opened to the public for the first time on January 23, 2016. [22]

Specifications

SCA 3-view schematic Shuttle Carrier Aircraft diagram.svg
SCA 3-view schematic

Data from Boeing 747-100 specifications [23] Jenkins 2000 [7]

General characteristics

Performance

See also

Aircraft of comparable role, configuration, and era

Related lists

Related Research Articles

<span class="mw-page-title-main">Space Shuttle</span> Partially reusable launch system and space plane

The Space Shuttle is a retired, partially reusable low Earth orbital spacecraft system operated from 1981 to 2011 by the U.S. National Aeronautics and Space Administration (NASA) as part of the Space Shuttle program. Its official program name was Space Transportation System (STS), taken from a 1969 plan for a system of reusable spacecraft where it was the only item funded for development.

Space Shuttle <i>Enterprise</i> Space Shuttle test vehicle, used for glide tests

Space Shuttle Enterprise was the first orbiter of the Space Shuttle system. Rolled out on September 17, 1976, it was built for NASA as part of the Space Shuttle program to perform atmospheric test flights after being launched from a modified Boeing 747. It was constructed without engines or a functional heat shield. As a result, it was not capable of spaceflight.

<span class="mw-page-title-main">Space Shuttle program</span> 1972–2011 United States human spaceflight program

The Space Shuttle program was the fourth human spaceflight program carried out by the U.S. National Aeronautics and Space Administration (NASA), which accomplished routine transportation for Earth-to-orbit crew and cargo from 1981 to 2011. Its official name, Space Transportation System (STS), was taken from a 1969 plan for a system of reusable spacecraft of which it was the only item funded for development. It flew 135 missions and carried 355 astronauts from 16 countries, many on multiple trips.

<span class="mw-page-title-main">Armstrong Flight Research Center</span> United States aerospace research facility

The NASA Neil A. Armstrong Flight Research Center (AFRC) is an aeronautical research center operated by NASA. Its primary campus is located inside Edwards Air Force Base in California and is considered NASA's premier site for aeronautical research. AFRC operates some of the most advanced aircraft in the world and is known for many aviation firsts, including supporting the first crewed airplane to exceed the speed of sound in level flight, highest speed by a crewed, powered aircraft, the first pure digital fly-by-wire aircraft, and many others. AFRC operates a second site next to Air Force Plant 42 in Palmdale, California, known as Building 703, once the former Rockwell International/North American Aviation production facility. There, AFRC houses and operates several of NASA's Science Mission Directorate aircraft including SOFIA, a DC-8 Flying Laboratory, a Gulfstream C-20A UAVSAR and ER-2 High Altitude Platform. As of 2023, Bradley Flick is the center's director.

<span class="mw-page-title-main">Spaceplane</span> Spacecraft capable of aerodynamic flight in atmosphere

A spaceplane is a vehicle that can fly and glide like an aircraft in Earth's atmosphere and maneuver like a spacecraft in outer space. To do so, spaceplanes must incorporate features of both aircraft and spacecraft. Orbital spaceplanes tend to be more similar to conventional spacecraft, while sub-orbital spaceplanes tend to be more similar to fixed-wing aircraft. All spaceplanes to date have been rocket-powered for takeoff and climb, but have then landed as unpowered gliders.

<span class="mw-page-title-main">Richard N. Richards</span> American astronaut and aviator (born 1946)

Richard Noel "Dick" Richards, , is a retired American naval officer and aviator, test pilot, chemical engineer, and a former NASA astronaut. He flew aboard four Space Shuttle missions in the 1980s and 1990s.

<span class="mw-page-title-main">C. Gordon Fullerton</span> American astronaut (1936–2013)

Charles Gordon Fullerton was a United States Air Force colonel, a USAF and NASA astronaut, and a research pilot at NASA's Dryden Flight Research Facility, Edwards, California. His assignments included a variety of flight research and support activities piloting NASA's B-52 launch aircraft, the Boeing 747 Shuttle Carrier Aircraft (SCA), and other multi-engine and high performance aircraft.

The Department of Defense Manned Space Flight Support Office (DDMS) coordinated all United States Department of Defense (DoD) contingency support to NASA's human spaceflight programs. The office was deactivated in 2007 and replaced by a staff element that is part of the United States Space Force's 45th Space Wing staff at Patrick Space Force Base in Florida.

<span class="mw-page-title-main">Shuttle Landing Facility</span> Airport located at Kennedy Space Center

The Shuttle Landing Facility (SLF), also known as Launch and Landing Facility (LLF), is an airport located on Merritt Island in Brevard County, Florida, United States. It is a part of the Kennedy Space Center and was used by Space Shuttle for landing until July 2011. It was also used for takeoffs and landings for NASA training jets such as the Shuttle Carrier Aircraft and for civilian aircraft.

<span class="mw-page-title-main">Boilerplate (spaceflight)</span> Nonfunctional spacecraft or payload

A boilerplate spacecraft, also known as a mass simulator, is a nonfunctional craft or payload that is used to test various configurations and basic size, load, and handling characteristics of rocket launch vehicles. It is far less expensive to build multiple, full-scale, non-functional boilerplate spacecraft than it is to develop the full system. In this way, boilerplate spacecraft allow components and aspects of cutting-edge aerospace projects to be tested while detailed contracts for the final project are being negotiated. These tests may be used to develop procedures for mating a spacecraft to its launch vehicle, emergency access and egress, maintenance support activities, and various transportation processes.

<span class="mw-page-title-main">Fitzhugh L. Fulton</span> American test pilot

Fitzhugh L. "Fitz" Fulton, Jr., , was a civilian research pilot at NASA's Dryden Flight Research Center, Edwards, California, from August 1, 1966, until July 3, 1986, following 23 years of distinguished service as a pilot in the U.S. Air Force.

<span class="mw-page-title-main">Approach and Landing Tests</span> Trials of the prototype Space Shuttle Enterprise

The Approach and Landing Tests were a series of sixteen 1977 taxi and flight trials of the prototype Space Shuttle Enterprise to test the vehicle's flight characteristics, eleven while mated to the Shuttle Carrier Aircraft and five in crewed free flight.

<span class="mw-page-title-main">Mate-Demate Device</span>

A Mate-Demate Device (MDD) is a specialized crane designed to lift a Space Shuttle orbiter onto and off the back of a Shuttle Carrier Aircraft. Four Mate-Demate Devices were built.

<span class="mw-page-title-main">Conroy Virtus</span> Proposed American large transport aircraft intended to carry the Space Shuttle

The Conroy Virtus was a proposed American large transport aircraft intended to carry the Space Shuttle. Designed, beginning in 1974, by John M. Conroy of the Turbo-Three Corporation, it was to incorporate a pair of Boeing B-52 Stratofortress fuselages to form a new craft using existing parts for cost-savings. While the project was seriously considered, it proved impractically large and NASA chose to develop the Boeing 747–based Shuttle Carrier from surplus commercial aircraft instead.

<span class="mw-page-title-main">Drop test</span> Method of testing aircraft/spacecraft

A drop test is a method of testing the in-flight characteristics of prototype or experimental aircraft and spacecraft by raising the test vehicle to a specific altitude and then releasing it. Test flights involving powered aircraft, particularly rocket-powered aircraft, may be referred to as drop launches due to the launch of the aircraft's rockets after release from its carrier aircraft.

<span class="mw-page-title-main">United States Air Force Plant 42</span> United States Air Force-owned aircraft manufacturing facility in Palmdale, California

United States Air Force Plant 42 is a classified aircraft manufacturing plant owned by the United States Air Force in the Antelope Valley, about 60 miles from downtown Los Angeles. It is also used by the National Aeronautics and Space Administration (NASA).

Larry LaRose is an American NASA flight engineer.

<i>Spirit of Mojave</i> 747 mothership for air launch hypersonic vehicle testbed

Spirit of Mojave, previously Cosmic Girl is a Boeing 747-400 aircraft. A former passenger airliner operated by Virgin Atlantic, it was purchased by Virgin Galactic in 2015 to be used as the first stage launch platform for the air launch stage of the smallsat orbital launch vehicle, the LauncherOne. In 2017, the aircraft was transferred to the orbital launch subsidiary, Virgin Orbit, and its livery updated to Virgin Orbit. LauncherOne attempted its first launch on 25 May 2020; the launch was a failure. The first successful launch took place on 17 January 2021.

References

  1. NASA Dryden Flight Research Center (1977). "Shuttle Enterprise Free Flight". National Aeronautics and Space Administration. ECN-8607. Archived from the original on March 7, 2013. Retrieved November 28, 2007.
  2. Jenkins, Dennis R. (2000). Boeing 747-100/200/300/SP. AirlinerTech Series. Vol. 6. Specialty Press. pp. 36–38. ISBN   1-58007-026-4.
  3. 1 2 3 Brack, Jon (September 17, 2012). "Inside the Space Shuttle Carrier Aircraft". National Geographic. Retrieved September 17, 2012.
  4. How was Enterprise Held and Released from the Carrier 747
  5. 1 2 Approach and Landing Test Evaluation Team (February 1978). Space Shuttle Orbiter Approach and Landing Test: Final Evaluation Report (PDF). Houston: National Aeronautics and Space Administration Lyndon B. Johnson Space Center. Retrieved April 21, 2020.
  6. Creech, Gray (August 22, 2003). "Gravel Haulers: NASA's 747 Shuttle Carriers" (Press release). National Aeronautics and Space Administration. Retrieved April 20, 2020.
  7. 1 2 3 Jenkins (2000) , pp. 38–39.
  8. 1 2 Gilette, Felix (August 9, 2005). "How the Space Shuttle Flies Home". Slate. Retrieved June 1, 2019.
  9. Comparison of photos taken in 1982 and 1983 at Airliners.net
  10. Rogoway, Joseph Trevithick and Tyler (January 27, 2022). "Space Shuttle Carrying 747 Was Secretly Modified To Defend Itself From Heat-Seeking Missiles (Updated)". The Drive. Retrieved January 29, 2022.
  11. 2003 Edwards Air Force Base Air Show, see Shuttle Carrier images.
  12. Shuttle Carrier Aircraft N911NA album on Photobucket
  13. "Space Shuttle Transoceanic Abort Landing (TAL) Sites" (PDF). National Aeronautics and Space Administration. December 2006. Retrieved July 1, 2009.
  14. Boeing Phantom Ray to catch shuttle ride at Lambert
  15. "STS Chronology". National Aeronautics and Space Administration.
  16. 1 2 NASA's Shuttle Carrier Aircraft 911's Final Flight
  17. Gibbs, Yvonne (September 12, 2014). "Final Journey: SCA 911 on Display at Davies Airpark" (Press release). National Aeronautics and Space Administration. Retrieved June 15, 2018.
  18. Gibbs, Yvonne (September 24, 2014). "NASA Armstrong Fact Sheet: Shuttle Carrier Aircraft". National Aeronautics and Space Administration. Retrieved June 15, 2018.
  19. Landis, Tony. "A graphic history of 35 years of Space Shuttle ferry flights now adorns the upper forward fuselage of NASA Shuttle Carrier Aircraft 905". National Aeronautics and Space Administration.
  20. "Houston's Shuttle Gets New Name, Familiar Ride". Spaceflight Insider. October 8, 2013.
  21. Hays, Brooks (August 14, 2014). "Shuttle replica lifted and put on top of 747 carrier". SpaceDaily. United Press International.
  22. Cofield, Calla (January 29, 2016). "Seeing Is Believing: Enormous Shuttle Program Artifact Inspires Wonder". Space.com. Retrieved December 20, 2022.
  23. Boeing 747-100 Technical Specifications, Boeing

Further reading