Recognizing the limitations of the earlier Su-9 and Su-11 in intercepting the new Boeing B-52 Stratofortress, particularly in terms of radar and aircraft performance, the Sukhoi OKB quickly began the development of a heavily revised and more capable aircraft. A variety of development aircraft evolved, including the Sukhoi T-49, which shared the fuselage of the Su-9 (including its single engine), but used cheek-mounted intakes to leave the nose clear for a large radome for the RP-22 Oryol-D ("Eagle") radar (NATO "Skip Spin"), and the T-5, essentially a heavily modified Su-11 with a widened rear fuselage containing two Tumansky R-11 engines.
These led to the T-58, which combined the twin engines with a modified version of the T-49's nose, but with side inlets further back, behind the cockpit. It was approved for production on 5 February 1962, as the Su-15, and the prototype first flew on 30 May 1962. It entered service testing 5 August 1963, but its service entry was delayed by political infighting with the Yakovlev OKB over production line capacity in Novosibirsk, which was also building the Yak-28P. The Su-15 proved to be superior in most respects other than range, and it was officially commissioned on 3 April 1965. Series production began the following year, and it entered service with the PVO in 1967, replacing Su-9s, Su-11s, and Yakovlev Yak-25s. The initial Su-15 received the NATO reporting name "Flagon-A". A simplified trainer version, the Su-15UT (NATO "Flagon-C"), with no radar or combat capability, entered service in 1970.
Initial delta-winged Su-15s had poor take-off and landing characteristics, and so Sukhoi investigated a new wing design with extended wingtips (increasing wing area) and boundary layer control. Su-15s with the new wing went into production in 1969. They were dubbed "Flagon-D" by NATO, although the Soviet designation was unchanged.
Also in 1969 testing began of the upgraded Su-15T with the Volkov Taifun ("Typhoon") radar, which was based on the MiG-25's powerful RP-25 Smerch-A ("Tornado") radar (NATO "Foxfire"). The Taifun proved troublesome, however, and ceased production after only 10 aircraft had been built. It was followed in December 1971 by the Su-15TM (NATO "Flagon-E"), with the improved Taifun-M radar (NATO "Twin Scan") and provision for UPK-23-250gun pod or R-60 (AA-8 "Aphid") short-range air-to-air missiles. Aerodynamic demands forced a redesign of the radome with an ogival shape, earning a new NATO reporting name, "Flagon-F", although again the Soviet designation did not change. A comparable combat-capable trainer, the Su-15UM (NATO "Flagon-G"), followed from 1976. The final Su-15UMs, the last Su-15s produced, came off the line in 1979.
Various OKB proposals for upgraded Su-15s with better engines and aerodynamics to satisfy a VVS requirement for a long-range tactical fighter were rejected in favour of the Mikoyan MiG-23 fighter.
Design
Su-15 Flagon ASukhoi Su-15Su-15 Flagon CA Su-15TM preserved at the Ukrainian Air Force museum in VinnytsiaAt the Aviation museum of Zhulyany Airport, Kyiv, Ukraine
Although many components of the Su-15 were similar or identical to the previous Su-9 and Su-11, including Sukhoi's characteristic rear-fuselage air brake, the Su-15 abandoned the shock-inlet cone nose intake for side-mounted intake ramps with splitter plates feeding two powerful turbojet engines, initially the Tumansky R-11F2S-300. The change allowed room in the nose for a powerful search radar, initially the RP-22 Oryol-D (NATO 'Skip Spin'). The early Su-15 ("Flagon-A") had pure delta wings like its predecessors, but these were replaced from the 11th production series onward by a new double-delta wing of increased span and area, with a small wing fence above each outer pylon and blown flaps to improve landing characteristics. This was accompanied by a new tail of greater anhedral and a vertical fin of reduced height.
The Su-15 had maximum speed of Mach 2.5 and a rate of climb of 228m/s (750 ft/s, 45,000 ft/min), a very important parameter for an interceptor aircraft. Take-off and landing speeds were comparatively high, with a take-off speed of 395km/h (245mph) for early delta-winged 'Flagon-A's and 370km/h (230mph) for the larger-winged 'Flagon-F'. While the controls were responsive and precise, the aircraft was unforgiving of pilot error.
Despite its powerful radar, the Su-15, like most Soviet interceptors before the late 1980s, was heavily dependent on ground control interception (GCI), with aircraft vectored onto targets by ground radar stations. It was fitted with the Lazur-S datalink system[2], which transmitted instructions to the pilot to accomplish the interception. The later Su-15TM had a Vozdukh-1M datalink and SAU-58 (sistema automaticheskogo upravleniya, automatic control system) capable of carrying out completely automatic, 'hands-off' interceptions until the last moments of the interception.
Primary armament of the Su-15 was the R-8/K-8 (AA-3 "Anab"; later R-98) air-to-air missile. Early models carried two missiles, but 'Flagon-D' and later versions could carry four. Like most Soviet missiles, the R-98 was made in both infrared and semi-active radar homing versions, and standard practice was to fire the weapons in pairs (one semi-active radar homing, one IR homing) to give the greatest chance of a successful hit. The IR homing missile was normally fired first in order to prevent the possibility of the IR missile locking on to the radar homing missile. Later 'Flagon-F' models often carried two R-98s and one or two pairs of short-range R-60 (AA-8 'Aphid') missiles. Late-model 'Flagons' also sometimes carried a pair of UPK-23-250 23mm gun pods on the fuselage pylons, each containing a two-barrel GSh-23L cannon.
Operational history
The Su-15 formed a significant part of the V-PVO's interceptor force, and was designed to intercept easier targets such as the American B-52 and U-2 and the British V bombers, leaving the more difficult targets such as the XB-70 and B-58 to the faster MiG-25P. The Taifun radar of the Su-15TM was optimised for counter-countermeasure operation, as opposed to range. As an interceptor, the task of the Su-15TM was to fly under autopilot, using GCI commands sent through the datalink. The radar would only be turned on as the interceptor approached the target in order to provide targeting parameters for the radar homing K-8/R-8/R-98 missiles, the high power of the radar allowing it to 'burn through' enemy ECM signals. If all else failed, IR homing versions of the K-8 would provide a last opportunity to shoot down the intruder, along with any gun pods the Su-15 might be carrying.
The Su-15 was optimised for the high-altitude interception role with its fast climb-rate and high speed at high altitude but lacked look-down/shoot-down capability, even with the Su-15TM's more sophisticated Taifun radar. This eventually led to the MiG-23P, which did have look-down/shoot-down capability, becoming the preferred asset of the V-PVO, especially once NATO switched to low-level penetration tactics. Even so, the Su-15 remained an important part of the V-PVO until the fall of the Soviet Union.
As one of the V-PVO's principal interceptors, the Su-15 was involved in several attacks on foreign aircraft that inadvertently crossed into Soviet airspace:
In 1978, Korean Air Lines Flight 902 veered into Soviet airspace and was attacked over Murmansk by a PVO Su-15. Although the civilian aircraft survived the missile hit, two passengers were killed, and the damaged plane subsequently made a forced landing on a frozen lake.
In 1981, a Soviet Su-15, from a base in Georgia, collided with a Canadair CL-44 of Transporte Aéreo Rioplatense (TAP; Argentinian airline), killing the three Argentinians and one Briton on board. The TAP aircraft was allegedly transporting weapons bought secretly from Israel by Iran, when it allegedly strayed into Soviet airspace. While some aviation experts believed the collision was accidental, the Soviet Su-15 pilot claimed that he had been deliberately rammed.[3]
In the Korean Air Lines Flight 007 incident in 1983, a South Korean Boeing 747 was fired upon near Moneron Island, after it veered into restricted Soviet airspace, by a Su-15TM based on Sakhalin, with the 747's control surfaces having been disabled as a result of a direct hit to the aircraft's tail. The crippled airliner then crashed into the Sea of Japan off the coast of Moneron, killing all 246 passengers and 23 crew.
The Su-15 was also credited with shooting down five reconnaissance balloons sent to spy on Soviet territory in 1975.
Although it was produced in large numbers (1,290 of all types), the Su-15, like other highly sensitive Soviet aircraft, was never exported to the Warsaw Pact or any other country due to its sophisticated systems. Some Su-15 were reported to be deployed in Egypt in 1972 but were used with Soviet crews. At one point, the Su-15 was considered for use as a strike fighter, but proved to be too specialised as an interceptor to be used in that role.
After the fall of the Soviet Union, the Su-15 was abruptly retired from the new Russian Air Force in 1993 to comply with the Treaty on Conventional Armed Forces in Europe. Most were hastily scrapped in favour of more advanced interceptors, including the Su-27 and MiG-31, but some are in reserve storage for emergency use. In Ukraine, the last Su-15s (at Kramatorsk and Belbek) were withdrawn from use in 1996.
Variants
T-58
Prototype of Su-15.
Su-15 (Flagon-A)
First production version.
T-58VD (Flagon-B)
One-off prototype using three Kolesov lift jets in the centre fuselage to provide STOL capability. Not mass-produced.
Su-15UT (Flagon-C)
Trainer version without radar and combat capability, in use since 1970.
Su-15 (Flagon-D)
Version with extended wingtips built since 1969.
Su-15T (Flagon-E)
Version equipped with Volkov Taifun radar.
Su-15TM (Flagon-F)
Improved Su-15T version equipped with Taifun-M radar and additional aerodynamic modifications, in use since 1971. New radome design for improving radar performances.
Su-15UM (Flagon-G)
Trainer version of Su-15TM without radar but with combat capability, built between 1976 and 1979.
U-58UM
Prototype of Su-15UM with Taifun-M radar, not entered serial production.
Su-15Sh
Proposed supersonic ground-attack aircraft, offered in 1969. Not built.
Su-15-30
Proposed version sharing the radar and missiles of the MiG-25; not built.
Su-15bis
Converted Su-15TM with R-25-300 engines of 69.9 kN (15,652 lb) afterburning thrust for improved performance; approved for series production, but not built because of a shortage of the engines.
Su-19 (T-58PS)
Proposed advanced version with Tumansky R-67-300 three spool turbofan engines, each producing 78.44 KN of afterburning thrust. Sukhoi Su-19 would have ogival wing, improved avionics suite with new Look down - shoot down radar and additional pylons for missiles. Not built.
Some Western reports indicate that the Su-15TM was also designated Su-21 and the Su-15UM Su-21U. These reports are apparently incorrect. Designation Su-21 was reserved for Su-17M4 but never used.[4]
The Mikoyan-Gurevich MiG-25 is a supersonic interceptor and reconnaissance aircraft that is among the fastest military aircraft to enter service. Designed by the Soviet Union's Mikoyan-Gurevich bureau, it is an aircraft built primarily using stainless steel. It was to be the last plane designed by Mikhail Gurevich, before his retirement.
The Sukhoi Su-7 is a swept wing, supersonic fighter aircraft developed by the Soviet Union in 1955. Originally, it was designed as a tactical, low-level dogfighter, but was not successful in this role. On the other hand, the soon-introduced Su-7B series became the main Soviet fighter-bomber and ground-attack aircraft of the 1960s. The Su-7 was rugged in its simplicity, but its Lyulka AL-7 engine had such high fuel consumption that it seriously limited the aircraft's payload, as even short-range missions required that at least two hardpoints be used to carry drop tanks rather than ordnance.
The Sukhoi Su-11 was an interceptor aircraft used by the Soviet Union during the Cold War.
The Sukhoi Su-17 is a variable-sweep wing fighter-bomber developed for the Soviet military. Developed from the Sukhoi Su-7, the Su-17 was the first variable-sweep wing aircraft to enter Soviet service and featured updated avionics. The aircraft also has variants which were designed to be exported to non-Soviet states such as the Sukhoi Su-22 and the less popular Su-20.
The Tupolev Tu-28 was a long-range interceptor aircraft introduced by the Soviet Union in the 1960s. The official designation was Tu-128, but this designation was less commonly used in the West. It was the largest and heaviest fighter ever in service.
The Sukhoi Su-9 was a single-engine, all-weather, missile-armed interceptor aircraft developed by the Soviet Union.
The Yakovlev Yak-25 was a swept wing, turbojet-powered interceptor and reconnaissance aircraft built by Yakovlev and used by the Soviet Union.
The Yakovlev Yak-28 is a swept wing, turbojet-powered combat aircraft used by the Soviet Union. Produced initially as a tactical medium bomber, it was also manufactured in reconnaissance, electronic warfare, interceptor, and trainer versions, known by the NATO reporting names Brewer, Brewer-E, Firebar, and Maestro respectively. Based on the Yak-129 prototype first flown on 5 March 1958, it began to enter service in 1960.
The Yakovlev Yak-27 was a family of Soviet supersonic aircraft developed in 1958 from the Yak-121 prototype. The most built variant was the tactical reconnaissance Yak-27R.
The Kaliningrad K-5, also known as RS-1U or product ShM, was an early Soviet air-to-air missile.
The Kaliningrad K-8 (R-8) was a medium-range air-to-air missile developed by the Soviet Union for interceptor aircraft use.
The Lavochkin La-250 "Anakonda" was a high-altitude interceptor aircraft prototype developed in the Soviet Union by the Lavochkin design bureau in the 1950s. Its nickname "Anaconda" was invented during the flight test and referred to both the elongated body shape as well as the relatively critical flight characteristics of the machine.
The RP-21 Sapfir was a radar system developed by the Soviet Union for use in the updated MiG-21PF fighter, and used in later versions of the MiG-21.
The Sukhoi T-3 was a prototype Soviet fighter aircraft.
The Sukhoi P-1 was a prototype Soviet interceptor.
The Mikoyan-Gurevich Ye-8 was a supersonic jet fighter developed in the Soviet Union, intended to replace the MiG-21. Only two prototypes were built in 1960–61. The original MiG-21's air intakes were moved under the fuselage, freeing up the nose where a larger and more powerful radar, able to deliver longer range air-to-air missiles, could be built in. Canards were built to both sides of the nose, in front of the cockpit,.
The Mikoyan-Gurevich I-75 was the final design of a series of three experimental swept-wing interceptors developed in the Soviet Union in the mid-late 1950s by the Mikoyan-Gurevich design bureau from their Mikoyan-Gurevich I-3 airframe. All the aircraft in the I-3 program were affected by delays in the development of the Klimov VK-3 turbojet engine, its cancellation and ultimate replacement by the Lyulka AL-7F turbojet engine.
The Mikoyan-Gurevich Ye-150 family was a series of prototype interceptor aircraft designed and built by the Mikoyan-Gurevich design bureau in the Soviet Union from 1955.
The Mikoyan-Gurevich I-7 was a development of the Mikoyan-Gurevich I-3 experimental fighter. Planned as a Mach 2-class aircraft, the I-7 was the second of a series of three experimental fighter aircraft from the Mikoyan-Gurevich design Bureau. Like the Mikoyan-Gurevich I-3, the I-7 was to be one of the components of the automated Uragan-1 then under development by protivovozdushnaya oborona strany, the Soviet defense system.
The Sukhoi S-6 was a design proposal for a two-seat tactical bomber which was developed in the Soviet Union. Roughly based on the Su-15U, further development eventually led to the Sukhoi T-6-1 and via the T-6-2 to the Sukhoi Su-24.
Butowski, Piotr and Pankov, Valeriy and Ponomaryev, Vadim. Su-15 Flagon. Monografie Lotnicze #14. Gdańsk: AJ-Press, 1994 ( ISBN83-86208-04-X) (in Polish).
External links
Wikimedia Commons has media related to Sukhoi Su-15 .
This page is based on this Wikipedia article Text is available under the CC BY-SA 4.0 license; additional terms may apply. Images, videos and audio are available under their respective licenses.
