FedEx Express Flight 80

Last updated
FedEx Express Flight 80
Fedex Flight 80 wreckage.jpg
The wreckage of FedEx 80
Accident
DateMarch 23, 2009
SummaryCrashed on hard landing due to bounced landing caused by pilot fatigue
Site Narita International Airport, Narita, Chiba Prefecture, Japan
35°45′35″N140°22′40″E / 35.75972°N 140.37778°E / 35.75972; 140.37778
Aircraft
Aircraft type McDonnell Douglas MD-11F
Operator FedEx Express
IATA flight No.FX80
ICAO flight No.FDX80
Call signFEDEX 80
Registration N526FE
Flight origin Guangzhou Baiyun International Airport, Guangzhou, China
Destination Narita International Airport, Narita, Chiba Prefecture, Japan
Occupants2
Passengers0
Crew2
Fatalities2
Injuries0
Survivors0

FedEx Express Flight 80 was a scheduled cargo flight from Guangzhou Baiyun International Airport in the People's Republic of China, to Narita International Airport in Narita, Chiba Prefecture (near Tokyo), Japan. On March 23, 2009, the McDonnell Douglas MD-11F (N526FE) [1] operating the flight crashed at 6:48 am JST (21:48 UTC, March 22), while attempting a landing on Runway 34L in gusty wind conditions. The aircraft became destabilized at flare and touchdown resulting in an unrecovered "bounced" landing with structural failure of the landing gear and airframe, and came to rest off the runway, inverted, and burning fiercely. [2] [3] The captain and first officer, the jet's only occupants, were both killed. [4]

Contents

Accident

After making an approximately 1,800-mile (1,600 nmi; 2,900 km) overnight flight from Guangzhou, China, the air crew made an early morning approach to Narita Airport outside Tokyo. [5] Other traffic landing just ahead of the accident aircraft reported "wind shear" at an altitude of under 600 meters (2,000 ft)," and this information was relayed to the FedEx aircrew. [3] Surface winds at the time of the accident were reported from 320° at 26 knots (30 mph; 13 m/s; 48 km/h) gusting to 40 knots (46 mph; 21 m/s; 74 km/h). [6] After making a hard landing on runway 34L, the plane bounced three times, coming back down on its nose gear first (a condition called "porpoising") resulting in the loss of directional and altitudinal control. The left wing struck the ground as the gear failed, causing the aircraft to veer to the left, burst into flames and invert as the airframe broke up, and came to rest upside down in the grass to the left of the runway. [2] [3] [7] It took firefighters about two hours to extinguish the blaze, which completely destroyed the aircraft and its contents. [7]

Fatalities

The only people on board the aircraft were the Captain, Kevin Kyle Mosley, 54, of Hillsboro, Oregon, and First Officer Anthony Stephen Pino, 49, of San Antonio, Texas. [4] Both pilots were taken to the Japanese Red Cross Narita Hospital (成田赤十字病院 Narita Seki Jūji Byōin) where they were pronounced dead. Captain Mosley, a former United States Marine Corps (1977–1983) fighter pilot, had been with FedEx Express since July 1, 1996 and had accumulated more than 12,800 total career flight hours, including 3,648 hours on the MD-11. [8] First Officer Pino, a former C-5 Galaxy pilot in the United States Air Force (1981–2004), joined FedEx Express in 2006 and had accumulated more than 6,300 total career flight hours, 879 of them on the MD-11. [4] Nobody on the ground was injured.

Runway closure

Runway 16R/34L (length 13,125 feet (4,000 m)) was closed for many hours after the accident (with passenger flight cancellations or delays), leaving the shorter 16L/34R as the only available active runway. [9] [10] As a result, many flights operated by larger aircraft had to be canceled or diverted to other airports such as nearby Haneda Airport, as 16L/34R is too short (length 7,150 feet (2,180 m)) for some types to operate safely, and some large aircraft types such as Boeing 777-300ER and Airbus A340-600 are restricted from using taxiway "B" (Bravo) which services that runway because of inadequate horizontal clearances. [11]

Aircraft

The aircraft involved in the accident, photographed two days before the accident at the same airport. FedEx MD-11F(N526FE) (3382499520).jpg
The aircraft involved in the accident, photographed two days before the accident at the same airport.
The aircraft involved when still in service with Delta Air Lines. N813DE MD-11 Delta Air Lines MAN 26JUL02 (8249724266).jpg
The aircraft involved when still in service with Delta Air Lines.

The aircraft was built in 1994 [12] as an MD-11 passenger airliner. It was acquired temporarily by NASA to use as the test bed for their Propulsion-Controlled Aircraft system (PCA) in 1995. [13] [14] Later it was owned and operated by Delta Air Lines from 1996 to 2004 under the FAA registration N813DE in such configuration. [15] The trijet was sold to FedEx in October 2004 when Delta retired its MD-11 fleet in favor of switching to more-efficient twin-engine Boeing 767s and Boeing 777s on its long-haul routes. Following its acquisition by FedEx, the plane was stored at Phoenix Goodyear Airport in Goodyear, Arizona [16] pending its conversion there to an MD-11F by Dimension Aviation, Inc. [ permanent dead link ], Boeing's Douglas Products Division airframe conversion contractor located at that field. The aircraft entered service with FedEx in its all-cargo configuration in late 2006 as N526FE. It was powered by three Pratt & Whitney PW4462 engines. [17]

Cause

The Japan Transport Safety Board (JTSB) [18] dispatched six investigators to the airport. [19] The United States' National Transportation Safety Board (NTSB) sent a team to Japan to assist with the investigation. [10] [20] [21] The crash was FedEx's second fatal accident involving a jet aircraft, following the loss of a FedEx owned B747-249F that crashed February 18, 1989, near Kuala Lumpur, while still painted in the Flying Tigers livery after the acquisition of the Flying Tigers Line by FedEx in December 1988. This was the first fatal accident at Narita Airport. [1] [10]

The accident was attributed by the JTSB to a series of "porpoising oscillations" that developed during touchdown, [22] : 97  following a high sink rate during the final approach. The first officer executed a late flare, in which sink rate was not suppressed until the plane was nearly on the runway, but which also would minimize "float" that might carry the plane further down the runway and reduce its safe stopping distance, or carry it off the centerline in the existing crosswinds. This high touchdown sink rate, coupled with large nose-up inputs, caused the first bounce. A large nose-down input was applied, causing a touchdown on the nose gear. This deviates from approved procedures for the MD-11 during a bounce, which specifies the pilot is to hold a pitch angle of 7.5 deg and use thrust to adjust the descent rate. The plane bounced off this second touchdown, pitching upward. The large control inputs by the first officer resulted in a hard touchdown on the main landing gear. This final touchdown was hard enough (1,200 ft/min (370 m/min)) to cause the left wing to fail as the left main landing gear transferred force up into the wing, exceeding its design limit. The JTSB report suggested the fire might have been averted if the landing gear fuse pin had failed as designed, but that much of the touchdown force was horizontal to the pin rather than vertical, keeping it intact. The report also cited the crew's use of autothrottle during landing despite gusty wind conditions.[ citation needed ]

As a result of this accident the Japan Transport Safety Board published its final report on April 26, 2013, in which it made a number of new safety recommendations including that "in order to reduce the occurrence of MD-11 series airplanes' severe hard landing and bounce in which an overload is transferred to the MLGs and their supporting structure, the Boeing Company should improve the controllability and maneuver characteristics by improving the LSAS (Longitudinal Stability Augmentation System) functions, reducing the AGS (Auto Ground Spoilers) deployment delay time and other possible means. Possible improvement on LSAS functions may include: a function to limit large nose-down elevator input during touchdown phase, which is a common phenomenon in severe hard landing cases accompanied by structural destruction for MD-11; and a function to assist bounce recovery and go-around in case of bounce. In order to help pilots to conduct recovery operation from large bounces and judge the necessity of go-around, studies should be made to install a visual display and an aural warning system which show gear touchdown status on MD-11 series airplanes." [22] : 97 

The investigation into the two pilots' performance during flight 80 found that both exhibited signs of lack of sleep and fatigue, and the first officer was heard on the cockpit voice recorder talking about how he had not slept very much prior to operating the flight. [22] : 14  A look at both pilots' activity in the days leading up to the flight found that, based on accounts from hotel staff, credit card transactions, and other signs of activity, neither pilot could have had more than four hours of consecutive sleep in the twenty-four hours leading up to the crash.[ citation needed ]

Additionally, the pilot flying, First Officer Anthony Pino, usually served as a relief pilot, taking control in the middle of long-haul flights. He therefore had little experience in landing the MD-11, and performed landings very infrequently.[ citation needed ]

Similar FedEx MD-11F accident

On July 31, 1997, another FedEx MD-11F (N611FE), operating as FedEx Express Flight 14, was written off after a similar destabilized landing accident at Newark Liberty International Airport. After a flight from Anchorage, Alaska, that aircraft crashed at the airport just before midnight when it bounced twice after a hard touchdown on Runway 22R, resulting in the failure of the right main landing gear. As in the Narita accident, the plane also caught fire as the airframe broke up, flipped over, and came to rest inverted off the runway. The captain, first officer, and three passengers on board all survived the 1997 Newark crash and were able to escape from the burning aircraft with only minor injuries. [23]

The crashes of both FedEx Express Flights 80 and 14 were covered on Season 14 of Mayday (Air Crash Investigation), episode 5 (episode 114 overall), titled The Final Push. [24]

See also

Related Research Articles

<span class="mw-page-title-main">McDonnell Douglas MD-11</span> Wide body airliners developed from the DC-10

The McDonnell Douglas MD-11 is an American tri-jet wide-body airliner manufactured by American manufacturer McDonnell Douglas (MDC) and later by Boeing. Following DC-10 development studies, the MD-11 program was launched on December 30, 1986. Assembly of the first prototype began on March 9, 1988. Its maiden flight occurred on January 10, 1990, and it achieved Federal Aviation Administration (FAA) certification on November 8. The first delivery was to Finnair on December 7 and it entered service on December 20, 1990.

<span class="mw-page-title-main">China Airlines Flight 642</span> August 1999 plane crash in Hong Kong

China Airlines Flight 642 was a flight that crashed at Hong Kong International Airport on 22 August 1999. It was operating from Bangkok to Taipei with a stopover in Hong Kong.

This is a list of aviation-related events from 1997.

<span class="mw-page-title-main">Oakland County International Airport</span> Airport in Waterford Township, Michigan

Oakland County International Airport is a county-owned public-use airport located in Waterford Township, Oakland County, Michigan, United States. The airport is located approximately one mile from the center of Waterford Township and Oakland County. It is included in the Federal Aviation Administration (FAA) National Plan of Integrated Airport Systems for 2017–2021, in which it is categorized as a non primary commercial service facility.

<span class="mw-page-title-main">Ann Arbor Municipal Airport</span> Airport in City of Ann Arbor

Ann Arbor Municipal Airport is a general aviation airport in Washtenaw County, Michigan, United States. It is included in the Federal Aviation Administration (FAA) National Plan of Integrated Airport Systems for 2017 to 2021, in which it is categorized as a regional general aviation facility.

<span class="mw-page-title-main">Cuyahoga County Airport</span> Airport in Richmond Heights, Willoughby Hills

Cuyahoga County Airport, also known as Robert D. Shea Field, is a public use airport in northeastern Cuyahoga County, Ohio, United States. Owned and operated by Cuyahoga County since 1946, it also serves Lake County and Geauga County. The airport is located 10 nautical miles east of downtown Cleveland and sits on the border of three cities: Highland Heights, Richmond Heights and Willoughby Hills. It is included in the National Plan of Integrated Airport Systems for 2011–2015, which categorized it as a general aviation reliever airport for Cleveland Hopkins International Airport.

<span class="mw-page-title-main">Ohio State University Airport</span> Airport in Columbus, United States of America

Ohio State University Airport is a public airport six miles (10 km) northwest of downtown Columbus, in Franklin County, Ohio, United States. It is owned and operated by Ohio State University in Columbus. It is also known as the OSU Don Scott Airport, named after Donald E. Scott, an OSU alumnus who died during his training as a pilot in the United Kingdom during World War II. The airport's main entrance is located on Case Road, and is easily accessible from OH-315 and Interstate 270.

<span class="mw-page-title-main">FedEx Express Flight 647</span> 2003 aviation accident

FedEx Express Flight 647 was a flight between Metropolitan Oakland International Airport (OAK), Oakland, California and Memphis International Airport (MEM), Memphis, Tennessee that crashed during landing on December 18, 2003.

<span class="mw-page-title-main">Mountain Air Cargo</span> Airline of the United States

Mountain Air Cargo (MAC) is an American cargo airline based in Denver, North Carolina. It is a major contract carrier for FedEx Express, operating in the eastern United States and the Caribbean region. Previous turboprop operations in South America have been discontinued by FedEx, which now operates jet aircraft in that area. MAC is one of the largest feeder airlines in the United States. Its main maintenance facility is at Kinston Regional Jetport. All of the ATR, C208, and C408 aircraft operated by Mountain Air are owned by FedEx Express, and are operated by MAC on a "dry lease" basis.

<span class="mw-page-title-main">FedEx Express Flight 14</span> 1997 plane crash in Newark, New Jersey, U.S.

FedEx Express Flight 14 was a scheduled cargo flight from Singapore to Newark, New Jersey, via Malaysia, Taiwan, and Alaska. On July 31, 1997, the aircraft flying this route crashed during landing on its final segment at Newark International Airport (EWR), inverting and catching fire, injuring all five people on board.

<span class="mw-page-title-main">Avient Aviation Flight 324</span> 2009 aviation accident

On 28 November 2009 at 08:12 (UTC+8), Avient Aviation McDonnell Douglas MD-11F, registration Z-BAV, on flight 324 from Shanghai Pudong International Airport to Manas International Airport, near Bishkek, crashed during its take off roll with the loss of 3 lives. As the aircraft rotated for departure, the tail struck the ground, and the aircraft then overshot the end of the runway, crashed and landed on top of a warehouse near the runway. The plane was written off. Avient took delivery of Z-BAV on 20 November 2009, 8 days before the crash.

<span class="mw-page-title-main">Lufthansa Cargo Flight 8460</span> 2010 aviation accident

Lufthansa Cargo Flight 8460 was an international cargo flight which crashed upon landing in Riyadh, Saudi Arabia on the 27th of July, 2010. Both crew members, the only people on board, were injured but survived.

The Ashland County Airport is a public-use airport in Ashland County, Ohio, United States. It is located three nautical miles northeast of the central business district of the City of Ashland. It is included in the FAA's National Plan of Integrated Airport Systems for 2011–2015, which categorized it as a general aviation facility.

<span class="mw-page-title-main">FedEx Express Flight 630</span> 2006 aviation accident

FedEx Express Flight 630 was a regular scheduled cargo flight from Seattle-Tacoma International Airport to Memphis International Airport, Memphis, Tennessee. On July 28, 2006, the McDonnell Douglas MD-10-10F operating the flight, crashed upon landing due to a landing gear failure. The main left undercarriage collapsed seven seconds after touchdown causing the MD-10 to roll off the runway out of control. The aircraft finally came to a stop near taxiway M4 and caught fire. The fire consumed the wing and port engine and the crash and evacuation left everyone onboard injured.

<span class="mw-page-title-main">Delta Air Lines Flight 1086</span> 2015 aviation incident

Delta Air Lines Flight 1086 was a scheduled Delta Air Lines domestic passenger flight between Atlanta and New York's LaGuardia Airport. On March 5, 2015, the McDonnell Douglas MD-88 aircraft veered off the runway shortly after landing at LaGuardia Airport in New York City. The plane ran up the seawall berm and struck the perimeter fence, sliding along it for approximately 940 feet (290 m) before coming to rest with the nose of the aircraft hanging over the berm above Flushing Bay. There were no fatalities, although 29 people suffered minor injuries. The aircraft was seriously damaged and written off.

<span class="mw-page-title-main">Asiana Airlines Flight 162</span> 2015 aviation accident

Asiana Airlines Flight 162 was a regular short-haul international passenger flight from Incheon International Airport near Seoul, South Korea, to Hiroshima Airport in Hiroshima, Japan. On 14 April 2015, the Airbus A320-232 aircraft touched down short of the runway, struck the localizer array, skidded onto the runway on its tail, and spun 120 degrees before finally coming to a rest on the grass, opposite the terminal building. The aircraft suffered substantial damage to the left wing and engine. Of the 82 people aboard, 27 were injured, one seriously.

<span class="mw-page-title-main">FedEx Express Flight 910</span> 2016 aviation incident

On October 28, 2016, FedEx Express Flight 910, a McDonnell Douglas MD-10-10F flying from Memphis International Airport to Fort Lauderdale–Hollywood International Airport was involved in a runway skid after a landing gear collapse, which resulted in a fire completely destroying the left engine and wing. Two crew members, the only people on board, were unharmed.

<span class="mw-page-title-main">FedEx Express Flight 1478</span> Boeing 727 hull loss accident

FedEx Express Flight 1478 was a scheduled domestic cargo flight from Memphis International Airport to Tallahassee International Airport. On July 26, 2002, the Boeing 727-232F aircraft flying this route crashed during landing at Tallahassee. All three flight crew members survived the accident with serious injuries, but the aircraft was destroyed.

<span class="mw-page-title-main">RED Air Flight 203</span> 2022 aviation incident

RED Air Flight 203 (L5203/REA203) was a scheduled international commercial passenger flight from Santo Domingo in the Dominican Republic to Miami International Airport by RED Air. On 21 June 2022, the McDonnell Douglas MD-82 aircraft operating the service suffered a left landing gear collapse and runway excursion, causing the left wing of the aircraft to impact an antenna structure, followed by a subsequent fire on the right side of the airplane. The incident caused three people to be hospitalized with minor injuries.

References

  1. 1 2 Ranter, Harro. "FedEx". aviation-safety.net. Aviation Safety Network.
  2. 1 2 "FedEx jet crashes at Narita; pilots die". The Japan Times . March 24, 2009. Archived from the original on March 24, 2009. Retrieved March 24, 2009.
  3. 1 2 3 "Cargo plane crashes at Narita, killing 2". Asahi Shimbun . March 24, 2009. Archived from the original on May 6, 2009. Retrieved March 24, 2009.
  4. 1 2 3 "FedEx Express Releases Additional Information Regarding FedEx Express Flight 80" (Press release). FedEx. 2009-03-23. Archived from the original on 2009-03-26. Retrieved 2009-03-24.
  5. ↑ "ASN Aircraft accident McDonnell Douglas MD-11F N526FE Tokyo-Narita Airport (NRT)". aviation-safety.net. Retrieved 2023-10-23.
  6. ↑ Weather at Narita at the time of accident: 2009/03/22 21:30Z RJAA 320 26G40KT 9999 FEW020 12/M02 Q0999 WS R34L NOSIG
  7. 1 2 "FedEx Plane Crash Lands At Narita Airport, 2 Confirmed Dead". Nikkei Inc. March 23, 2009. Archived from the original on March 27, 2009. Retrieved April 13, 2016.
  8. ↑ "Kevin Mosley Obituary (2009) - Portland, OR - The Oregonian". The Oregonian. March 29, 2009. Retrieved 2023-10-23– via Legacy.com.
  9. ↑ "Cargo plane crashes at Tokyo airport". NBC News . March 22, 2009. Retrieved March 22, 2009.
  10. 1 2 3 "Deadly plane crash at Tokyo airport". CNN . March 22, 2009. Retrieved March 22, 2009.
  11. ↑ "International Industry Working Group (IIWG), 50th Meeting, Cape Town, Republic of South Africa, August,18-20, 2004, Final Meeting Report, Nov 12, 2004". In re: Narita International Airport, Japan: "Since August 3, 2004, further ground movement restrictions exist for the B777-300 ER and the A340-600 aircraft to use rwy 16L/34R due to clearance limitations on Taxiway B."[ permanent dead link ]
  12. ↑ "McDonnell Douglas MD-11F - MSN 48600 N526FE". FAA. Archived from the original on February 17, 2012. Retrieved March 24, 2009.
  13. ↑ "Federal Express N526FE (McDonnell Douglas MD-11 - MSN 48600) (Ex N813DE N90178 N9017S ) | Airfleets aviation". www.airfleets.net. Retrieved 2019-07-28.
  14. ↑ Conner, Monroe (2015-06-25). "MD-11 Propulsion Controlled Aircraft". NASA. Retrieved 2019-07-28.
  15. ↑ "N813DE". Aviation Safety Network.
  16. ↑ "N813DE in storage at Goodyear - Phoenix / Goodyear (Litchfield Municipal) (GYR), April, 2004". Airliners.net. Retrieved March 23, 2009.
  17. ↑ "N813DE (cn 48600/560)". Airliners.net. Retrieved March 23, 2009. No longer in service with Delta and now owned by Fed Ex, the aircraft is seen parked on the Fed Ex maintenance ramp at Los Angeles prior to its conversion to a freighter. (2006)
  18. ↑ JTSB was established on October 1, 2008 by integrating ARAIC (Aircraft and Railway Accidents Investigation Commission) and JMAIA (Japan Marine Accident Inquiry Agency).
  19. ↑ "FedEx jet crashes at Narita / Pilot, copilot die in airport's 1st fatal accident; wind blamed". Yomiuri Shimbun . March 24, 2009. Archived from the original on March 27, 2009. Retrieved March 24, 2009.
  20. ↑ "Two dead in courier plane crash". The Australian . March 23, 2009. Archived from the original on March 26, 2009. Retrieved March 23, 2009.
  21. ↑ "FedEx plane crashes, explodes on landing in Tokyo". Reuters . March 22, 2009. Retrieved March 22, 2009.
  22. 1 2 3 "JTSB Aircraft Accident Investigation Report. Federal Express Corporation N526FE" (PDF). Japan Transport Safety Board. 2013-04-26. Archived (PDF) from the original on 2013-04-01.
  23. ↑ Crash During Landing, Federal Express, Inc. McDonnell Douglas MD-11, N611FE, Newark International Airport, Newark, New Jersey, July 31, 1997 (PDF). National Transportation Safety Board. July 25, 2000. NTSB/AAR-00/02. Retrieved April 8, 2015.
  24. ↑ "Air Crash Investigation Death at Narita". TV Guide. Retrieved 9 March 2016.
This page is based on this Wikipedia article
Text is available under the CC BY-SA 4.0 license; additional terms may apply.
Images, videos and audio are available under their respective licenses.