The Bell Aerosystems Lunar Landing Research Vehicle (LLRV, nicknamed the Flying Bedstead)[1] was a Project Apollo era program to build a simulator for the Moon landings. The LLRVs were used by the FRC, now known as the NASA Armstrong Flight Research Center, at Edwards Air Force Base, California, to study and analyze piloting techniques needed to fly and land the Apollo Lunar Module in the Moon's low gravity environment.[2]
The research vehicles were vertical take-off vehicles that used a single jet engine mounted on a gimbal so that it always pointed vertically. It was adjusted to cancel 5/6 of the vehicle's weight, and the vehicle used hydrogen peroxide rockets which could fairly accurately simulate the behavior of a lunar lander.
Success of the two LLRVs led to the building of three Lunar Landing Training Vehicles (LLTVs), an improved version of the LLRV, for use by Apollo astronauts at the Manned Spacecraft Center in Houston, Texas, predecessor of NASA's Johnson Space Center. One LLRV and two LLTVs were destroyed in crashes, but the rocket ejection seat system safely recovered the pilot in all cases.
The final phase of every Apollo landing was manually piloted by the mission commander. Because of landing site selection problems, Neil Armstrong, Apollo 11 commander, said his mission would not have been successful without extensive training on the LLTVs. Selection for LLTV training was preceded by helicopter training. In a 2009 interview, astronaut Curt Michel stated, "For airborne craft, the helicopter was the closest in terms of characteristics to the lunar lander. So if you didn't get helicopter training, you knew you weren't going. That sort of gave it away."[3] Even Tom Stafford and Gene Cernan did not get LLTV training for their Apollo 10 mission which was the first flight of the Lunar Module to the Moon, because NASA "didn't have plans to land on Apollo 10" so "there wasn't any point in... training in the LLTV." Cernan only got this training after being assigned as backup commander for Apollo 14, and in 1972 was the last to fly the LLTV while training as commander for Apollo 17, the final landing mission.[4]
History
LLRV-1 at Edwards AFB is tested before acceptance by NASA
Built of aluminum alloy trusses, the LLRVs were powered by a General Electric CF700-2V turbofan engine with a thrust of 4,200lbf (19kN), mounted vertically in a gimbal. The engine lifted the vehicle to the test altitude and was then throttled back to support five-sixths of the vehicle's weight, simulating the reduced gravity of the Moon. Two hydrogen peroxide lift rockets with thrust that could be varied from 100 to 500lbf (440 to 2,200 N) handled the vehicle's rate of descent and horizontal movement. Sixteen smaller hydrogen peroxide thrusters, mounted in pairs, gave the pilot control in pitch, yaw and roll.
Neil Armstrong floats safely to the ground as LLRV-1 crashes at Ellington Air Force Base, 6 May 1968.
The pilot had an ejection seat. On activation, it propelled the pilot upward from the vehicle with an acceleration of roughly 14 times the force of gravity for about a half second. From the ground, it was sufficient to propel the seat and pilot to an altitude of about 250 feet (80m) where the pilot's parachute could be automatically and successfully deployed. Manufactured by Weber Aircraft LLC, it was one of the first zero-zero ejection seats, capable of saving the operator even if the aircraft was stationary on the ground, a necessity given the LLRV's low and slow flight envelope.[5][6][7]
After conceptual planning and meetings with engineers from Bell Aerosystems, Buffalo, New York, a company with experience in vertical takeoff and landing (VTOL) aircraft, NASA issued Bell a $50,000 study contract in December 1961. Bell had independently conceived a similar, free-flying simulator, and out of this study came the NASA Headquarters' endorsement of the LLRV concept, resulting in a $3.6 million production contract awarded to Bell on February 1, 1963, for delivery of the first of two vehicles for flight studies at the FRC within 14 months.
LLRV-1 was shipped from Bell to FRC in April. LLRV-2 was also shipped at the same time, but in parts. Because of a potential cost overrun, the FRC Director, Paul Bickle, decided to have it assembled and tested at FRC. The emphasis then was on LLRV-1. It was first readied for flight on a tilt table constructed at FRC to evaluate its engine operation without actually flying it. The scene then shifted to the old South Base area of Edwards.
The first three flights of #1 were made on October 30, 1964 by FRC's senior research test pilot, Joe Walker. He continued to pilot a number of flights through December 1964, after which flights were shared with Don Mallick, also a FRC research pilot, and Jack Kleuver, the Army's senior helicopter test pilot. Familiarization flights were also made by NASA Manned Spacecraft Center (later Johnson Space Center) pilots Joseph Algranti and H.E. Ream.
Modifications were later made to the cockpits of both LLRVs to better simulate the actual Lunar Module. These included the addition of the LM's three-axis hand controller and throttle. A Styrofoam cockpit enclosure was also added to simulate the pilot's restricted view in the LM.
The final LLRV flight at FRC took place on November 30, 1966. In December 1966, vehicle #1 was shipped to Houston, followed by #2 in January 1967. During the preceding two years, a total of 198 flights of LLRV-1 and six flights of LLRV-2 had been flown without a serious accident.
The first LLRV flight by Neil Armstrong was made in vehicle #1 on March 27, 1967 from its base at a corner of Ellington Air Force Base, the headquarters for Johnson Space Center's aircraft operations. Joe Algranti, chief of JSC's Aircraft Operations Division, and test pilot H.E. Ream also made flights that month. Both observed, as did Armstrong and the other astronauts, that if a serious control problem developed, the pilot had little choice but to eject, since the vehicle only operated to a maximum altitude of 500 feet (200m).
On May 6, 1968, Armstrong was forced to use LLRV-1's ejection seat from about 200 feet (60m) altitude after a control problem, and had about four seconds on his full parachute before landing on the ground unhurt. LLRV-1 was lost.[8] The accident investigation board found that the fuel for the vehicle's attitude control thrusters had run out and that high winds were a major factor. As a result, JSC management decided to terminate further LLRV flights, as the first LLTV was about to be shipped from Bell to Ellington to begin ground and flight testing.
LLRV-2 (NASA 951) was eventually returned to the Armstrong Flight Research Center, where it is on display as an artifact of the center's contribution to the Apollo program.[8]
Lunar Landing Training Vehicle
Alan Shepard during training for the Apollo 14 mission stands in front of LLTV-3.
Negotiations between JSC and Bell Aerosystems for three LLTVs (LLTV-1 to 3), an improved training version of the LLRV, were initiated in October 1966 and a $5.9 million contract for three vehicles was finally signed in March 1967.[9]
In June 1968, the first vehicle (LLTV-1) was delivered by Bell to Ellington to begin its ground and flight testing by JSC's Aircraft Operations Division (AOD). AOD's head, Joe Algranti, was the principal test pilot for its first flight in August 1968. Flight testing continued until December 8, when Algranti lost control of LLTV-1 during a flight to expand the vehicle's speed envelope.[8][10] He managed to eject just three-fifths of a second before the vehicle hit the ground, the close call believed to be as a result of his attempt to regain control.
Test pilot Stuart Present ejects safely from crashing LLTV-2, 29 January 1971.
The accident investigation found that the ground controllers had elected not to monitor in real time the attitude thrusters that controlled the vehicle's yaw motion, and, at the velocity Algranti was flying, the thrusters had been overpowered by the LLTV's aerodynamic forces, causing Algranti to lose control. Due to tight cost constraints on the LLRV and LLTV, wind tunnel testing had been avoided in favor of careful flight testing for evaluation of the vehicles' aerodynamic characteristics. After reviewing the results of the crash investigation, however, it was decided that the third LLTV (LLTV-3) be loaded into NASA's Super Guppy and flown to the Langley Research Center in Virginia for testing in its full-scale wind tunnel. Testing was initiated on January 7, 1968 and ended one month later on February 7.
It was quickly determined that the cause of the divergence was the Styrofoam cockpit enclosure. As the vehicle's sideslip angle reached minus two degrees, a yawing force rapidly built up that exceeded the ability of the yaw thrusters to counteract. The fix decided on was simply to remove the top of the enclosure, thus venting it and eliminating the excessive yawing force. It was also possible from the wind tunnel results to develop a preliminary flight envelope for the LLTV, defining its allowable maximum airspeed at various angles of angle of attack and sideslip. All this had to be verified by flight test, however, since it was not possible in the tunnel to obtain good data with the engine running.
A high level LLTV Flight Readiness Review Board was appointed on March 5, 1969 by JSC Director Dr. Robert Gilruth. It consisted of him as chairman, with board members Chris Kraft, head of Mission Operations; George Low, head of JSC's Apollo Program; Max Faget, JSC's Director of Engineering and astronaut Deke Slayton, Director of Flight Crew Operations. The board reviewed the wind tunnel results, and on March 30 gave approval for the resumption of test flights in LLTV-2.[8] The test program of 18 flights, all flown by H.E. Ream, was successfully completed on June 2. Hence, in the month before the Apollo 11 launch Armstrong was able to complete his LLTV flight training. He commented after his return:
Eagle (the Lunar Module) flew very much like the Lunar Landing Training Vehicle which I had flown more than 30 times at Ellington Air Force Base near the Space Center. I had made from 50 to 60 landings in the trainer, and the final trajectory I flew to the landing was very much like those flown in practice. That, of course, gave me a good deal of confidence — a comfortable familiarity.
In Armstrong's 2005 authorized biography First Man: The Life of Neil A. Armstrong, astronaut Bill Anders is quoted as describing the LLTV as "a much unsung hero of the Apollo Program". Although Armstrong had to eject from the LLRV, no other astronaut ever had to eject from the LLTV, and every Lunar Module pilot through the final Apollo 17 mission trained in the LLTV and flew to a landing on the Moon successfully.
In January 1971 LLTV-2 was destroyed while testing a major modification to the computer system. Its test pilot, Stuart Present, was able to eject safely.[8]
Gene Cernan piloted the surviving LLTV-3 vehicle on November 13, 1972, three weeks before Apollo 17.[8] LLTV-3 (NASA 952) is now on display at the Johnson Space Center.[8]
Lunar Sim Mode
There were two distinct modes of flight for the LLRV and LLTV. The basic mode was with the engine fixed so that it remained 'normal' with respect to the body.
In the gimbaled "Lunar Sim Mode," the free-gimbaled turbofan engine was allowed to swivel and was kept pointing downward to Earth's center of mass regardless of the LLRV's attitude; this allowed the vehicle to tilt at the far greater angles that would be typical of hovering and maneuvering above the lunar surface. Despite its ungainly appearance, the LLRV was equipped with a highly sophisticated array of early sensors (mainly Doppler radar) and computational hardware. The system had no specific name, but the effect it produced was called "Lunar Sim Mode."[11] This was the highest degree of hardware-based simulation. It was not a system to unburden the pilot, as an autopilot does, nor was it meant to introduce any sort of safety or economy.
Lunar Sim Mode can also be thought of as a mixture of stability augmentation, recalculation of vertical acceleration according to the lunar gravity constant, all followed by accompanied instantaneous corrective action. The LLRV's Lunar Sim Mode was even able to correct for wind gusts within milliseconds, as they would have disturbed the impression of a missing atmosphere.
FRC test pilot Don Mallick's comments following the vehicle's first flight in the lunar simulation mode illustrate the experience of piloting the LLRV:[12]
As a general statement concerning the translation ability on earth versus the translational ability in the lunar simulation; the vehicle is reduced from a very positive high response vehicle to a very low or weak response vehicle. I'm sure with training and experience the pilot will be able to increase the overall vehicle-pilot performance once he adapts to the low translational accelerations that are available, as well as the lag that follows along with the anticipation that is required to properly control the vehicle. Even with this training, the pilot is faced with the situation of about 5/6 of his translational maneuvering performance removed from that on earth which is a marked change.
Deke Slayton, then NASA's Chief Astronaut, later said there was no way to simulate a Moon landing except by flying the LLRV.
The electronic control system for the Lunar Landing Training Vehicle was developed for NASA by Bell Aerosystems, Inc. which had engineering facilities located in Niagara Falls, New York. The LLTV was a second generation vehicle, after the Lunar Landing Research Vehicle, used by NASA Apollo Program astronauts to develop piloting skills. The LLTV provided Apollo program commanders the opportunity to experience the flight characteristics associated with the 1/6 gravity conditions on the Moon. The first LLTV vehicle was assembled at Ellington Air Force Base in Houston, Texas in 1967. Three LLTV vehicles were eventually delivered to Ellington AFB. The last remaining of the three LLTV vehicles is on display at the Johnson Spacecraft Center in Houston, Texas.
The electronic control system was designed with redundant channels that used 2 of 2 logic. The outputs of each primary channel were compared on a continuous basis. If a fault was detected in the primary control system, then control was automatically switched to an identical backup channel and the pilot immediately took measures to bring the vehicle to the ground. All the controls were analog circuits utilizing Burr-Brown transistor amplifier modules and other analog components.
The Apollo program, also known as Project Apollo, was the United States human spaceflight program carried out by the National Aeronautics and Space Administration (NASA), which succeeded in preparing and landing the first men on the Moon from 1968 to 1972. It was first conceived in 1960 during President Dwight D. Eisenhower's administration as a three-person spacecraft to follow the one-person Project Mercury, which put the first Americans in space. Apollo was later dedicated to President John F. Kennedy's national goal for the 1960s of "landing a man on the Moon and returning him safely to the Earth" in an address to Congress on May 25, 1961. It was the third US human spaceflight program to fly, preceded by the two-person Project Gemini conceived in 1961 to extend spaceflight capability in support of Apollo.
Apollo 13 was the seventh crewed mission in the Apollo space program and the third meant to land on the Moon. The craft was launched from Kennedy Space Center on April 11, 1970, but the lunar landing was aborted after an oxygen tank in the service module (SM) ruptured two days into the mission, disabling its electrical and life-support system. The crew, supported by backup systems on the lunar module (LM), instead looped around the Moon in a circumlunar trajectory and returned safely to Earth on April 17. The mission was commanded by Jim Lovell, with Jack Swigert as command module (CM) pilot and Fred Haise as lunar module (LM) pilot. Swigert was a late replacement for Ken Mattingly, who was grounded after exposure to rubella.
Apollo 10 was the fourth human spaceflight in the United States' Apollo program and the second to orbit the Moon. NASA, the mission's operator, described it as a "dress rehearsal" for the first Moon landing. It was designated an "F"mission, intended to test all spacecraft components and procedures short of actual descent and landing.
Apollo 12 was the sixth crewed flight in the United States Apollo program and the second to land on the Moon. It was launched on November 14, 1969, by NASA from the Kennedy Space Center, Florida. Commander Charles "Pete" Conrad and Lunar Module Pilot Alan L. Bean performed just over one day and seven hours of lunar surface activity while Command Module Pilot Richard F. Gordon remained in lunar orbit.
Neil Alden Armstrong was an American astronaut and aeronautical engineer who, in 1969, became the first person to walk on the Moon. He was also a naval aviator, test pilot, and university professor.
The Apollo Lunar Module, originally designated the Lunar Excursion Module (LEM), was the lunar lander spacecraft that was flown between lunar orbit and the Moon's surface during the United States' Apollo program. It was the first crewed spacecraft to operate exclusively in the airless vacuum of space, and remains the only crewed vehicle to land anywhere beyond Earth.
STS-1 was the first orbital spaceflight of NASA's Space Shuttle program. The first orbiter, Columbia, launched on April 12, 1981, and returned on April 14, 1981, 54.5 hours later, having orbited the Earth 37 times. Columbia carried a crew of two—commander John W. Young and pilot Robert L. Crippen. It was the first American crewed space flight since the Apollo–Soyuz Test Project (ASTP) in 1975. STS-1 was also the maiden test flight of a new American spacecraft to carry a crew, though it was preceded by atmospheric testing (ALT) of the orbiter and ground testing of the Space Shuttle system.
David Randolph Scott is an American retired test pilot and NASA astronaut who was the seventh person to walk on the Moon. Selected as part of the third group of astronauts in 1963, Scott flew to space three times and commanded Apollo 15, the fourth lunar landing; he is one of four surviving Moon walkers and the only living commander of a spacecraft that landed on the Moon.
The NASA Neil A. Armstrong Flight Research Center (AFRC) is an aeronautical research center operated by NASA. Its primary campus is located inside Edwards Air Force Base in California and is considered NASA's premier site for aeronautical research. AFRC operates some of the most advanced aircraft in the world and is known for many aviation firsts, including supporting the first crewed airplane to exceed the speed of sound in level flight, highest speed by a crewed, powered aircraft, the first pure digital fly-by-wire aircraft, and many others. AFRC operates a second site next to Air Force Plant 42 in Palmdale, California, known as Building 703, once the former Rockwell International/North American Aviation production facility. There, AFRC houses and operates several of NASA's Science Mission Directorate aircraft including SOFIA, a DC-8 Flying Laboratory, a Gulfstream C-20A UAVSAR and ER-2 High Altitude Platform. As of 2023, Bradley Flick is the center's director.
Clifton Curtis Williams Jr., was an American naval aviator, test pilot, mechanical engineer, major in the United States Marine Corps, and NASA astronaut, who was killed in a plane crash; he never went into space. The crash was caused by a mechanical failure in a NASA T-38 jet trainer, which he was piloting to visit his parents in Mobile, Alabama. The failure caused the flight controls to stop responding, and although he activated the ejection seat, it did not save him. He was the fourth astronaut from NASA's Astronaut Group 3 to have died, the first two having been killed in separate T-38 flights, and the third in the Apollo 1 fire earlier that year. The aircraft crashed in Florida near Tallahassee within an hour of departing Patrick AFB.
The Apollo spacecraft was composed of three parts designed to accomplish the American Apollo program's goal of landing astronauts on the Moon by the end of the 1960s and returning them safely to Earth. The expendable (single-use) spacecraft consisted of a combined command and service module (CSM) and an Apollo Lunar Module (LM). Two additional components complemented the spacecraft stack for space vehicle assembly: a spacecraft–LM adapter (SLA) designed to shield the LM from the aerodynamic stress of launch and to connect the CSM to the Saturn launch vehicle and a launch escape system (LES) to carry the crew in the command module safely away from the launch vehicle in the event of a launch emergency.
Joseph Albert Walker was an American World War II pilot, experimental physicist, NASA test pilot, and astronaut who was the first person to fly an airplane to space. He was one of twelve pilots who flew the North American X-15, an experimental spaceplane jointly operated by the Air Force and NASA.
Project Gemini was the second United States human spaceflight program to fly. Conducted after the first American crewed space program, Project Mercury, while the Apollo program was still in early development, Gemini was conceived in 1961 and concluded in 1966. The Gemini spacecraft carried a two-astronaut crew. Ten Gemini crews and 16 individual astronauts flew low Earth orbit (LEO) missions during 1965 and 1966.
The Northrop HL-10 is one of five US heavyweight lifting body designs flown at NASA's Flight Research Center in Edwards, California, from July 1966 to November 1975 to study and validate the concept of safely maneuvering and landing a low lift-over-drag vehicle designed for reentry from space. It was a NASA design and was built to evaluate "inverted airfoil" lifting body and delta planform. It currently is on display at the entrance to the Armstrong Flight Research Center at Edwards Air Force Base.
Several planned missions of the Apollo crewed Moon landing program of the 1960s and 1970s were canceled, for reasons which included changes in technical direction, the Apollo 1 fire, hardware delays, and budget limitations. After the landing by Apollo 12, Apollo 20, which would have been the final crewed mission to the Moon, was canceled to allow Skylab to launch as a "dry workshop". The next two missions, Apollos 18 and 19, were later canceled after the Apollo 13 incident and further budget cuts. Two Skylab missions also ended up being canceled. Two complete Saturn V rockets remained unused and were put on display in the United States.
Lunar escape systems (LESS) were a series of emergency vehicles designed for never-flown long-duration Apollo missions. Because these missions were more hypothetical than the planned cancelled Apollo missions, the designs were never constructed. This concept was an outgrowth of the Lunar Flying Vehicle by Bell Aerospace.
Space Center Houston is a science museum that serves as the official visitor center of NASA Johnson Space Center in Houston, Texas. It was designated a Smithsonian Affiliate museum in 2014. The organization is owned by NASA, and operated under a contract by the nonprofit Manned Spaceflight Education Foundation, a 501(c)(3) organization. The Johnson Space Center is the home of Mission Control and astronaut training.
This page is based on this Wikipedia article Text is available under the CC BY-SA 4.0 license; additional terms may apply. Images, videos and audio are available under their respective licenses.
