Office of Secure Transportation

Last updated
Office of Secure Transportation - Seal.jpg

The U.S. Department of Energy/National Nuclear Security Administration's Office of Secure Transportation (OST) provides safe and secure transportation of nuclear weapons and components and special nuclear materials, and conducts other missions supporting the national security of the United States of America.



Since 1947, the U.S. Department of Energy (DOE) and its predecessor agencies have moved nuclear weapons, nuclear weapons components, and special nuclear materials by a variety of commercial and government transportation modes.

In the late 1960s, worldwide terrorism and acts of violence prompted a review of procedures for safeguarding these materials. As a result, a comprehensive new series of regulations and equipment was developed to enhance the safety and security of these materials in transit. The Transportation Safeguards Division (TSD), renamed Office of Secure Transportation (OST) in the late 1990s, was subsequently established in 1975 at the Department of Energy's (DOE) Albuquerque Operations Office.

The OST modified and redesigned transport equipment to incorporate features that effectively enhance self-protection and deny unauthorized access to the materials. It was during this time that OST curtailed the use of commercial transportation systems and moved to a total federal operation.

Since its establishment in 1975, OST has accumulated over 100 million miles of over-the-road experience transporting DOE-owned cargo with no accidents causing a fatality or release of radioactive material. There have been accidents, however. In November 1996, after 13 years of accident-free travel, a convoy in western Nebraska encountered an unexpected ice storm. A tractor-trailer in the convoy skidded off the road and rolled onto its side, jostling its cargo of two nuclear bombs. [1]


OST-classified shipments are now conducted in a low profile, no-notice manner to ensure the security and safety of the cargo. The personnel who operate the transportation vehicles and the escort vehicles are federal agents. The OST annual budget is about $250 million. [2]

Travel restrictions

The OST attempts to ensure its convoys do not travel during periods of inclement weather. The OST monitors weather from their operations center and weather checks are performed every two hours. If the convoys are going to encounter or do encounter adverse weather, provisions exist for the convoys to seek shelter at previously identified facilities. As an additional travel precaution, the OST has imposed a maximum 65 miles-per-hour speed limit on its convoys, even if the posted limit is greater.

Although OST provides sleeper berths in all vehicles, federal agents (couriers) accompanying shipments are not to exceed 32 hours of continuous travel without then having 8 hours of uninterrupted, stationary bed rest.


As of 2017, OST employed 322 couriers. [3] It seeks to hire military veterans, particularly ex-special-operations forces. Besides dealing with "irregular hours, personal risks, and exposure to inclement weather," agents "may be called upon to use deadly force if necessary to prevent the theft, sabotage or takeover of protected materials by unauthorized persons." [2]


The OST operates a nationwide communications system located in Albuquerque, New Mexico. This system, known as the Transportation and Emergency Control Center (TECC), monitors the status and location of shipments and maintains real-time communications 24-hours a day with every convoy. TECC is the first line in the support of convoys.

Through an active liaison program, the DOE maintains an emergency contact directory of federal and state response organizations located throughout the contiguous United States. During a convoy emergency, an open communications line is established and maintained between the control center and the appropriate state agencies. This way a continuous update of information from the scene can be relayed to the responding units.

OST has established procedures should a law enforcement officer stop an OST vehicle. The liaison program provides law enforcement officers information to assist them in recognizing one of these vehicles should it be involved in an accident and what actions to take in conjunction with the actions of the federal agents.

In the case of emergency event that threatened the cargo of an OST safeguards shipment, DOE would declare a National Security Area (NSA), which temporarily places an area under effective control of the DOE/NNSA. A National Security Area is defined as an area established within the United States and used for the purpose of safeguarding classified, sensitive, and/or restricted data to protect DOE/NNSA equipment and/or material. The CCIC at the scene will define the boundary, mark it with a physical barrier, and post warning signs. The declaration of a National Security Area does not relieve state and local authorities of their responsibilities for the area surrounding the NSA, to include evacuations or other protective actions as needed.

Emergency response

DOE has a system of emergency response including initial notification, monitoring and assessment of the situation, and working with other agencies to resolve the emergency.

In the event of a vehicle accident involving a Safe Secure Trailer (SST) or Safeguards Transporter (SGT), the local responders (e.g., police, sheriff, state trooper, fire department, etc.), after the initial interface with the federal agents, will be asked to meet with the CCIC to discuss the situation and the best way to solve it.

Related Research Articles

Warhead damage-creating payload delivered by a rocket, missile, or torpedo

A warhead is the explosive or toxic material that is delivered by a missile, rocket, or torpedo. It is a type of bomb.

Los Alamos National Laboratory Research laboratory near Santa Fe, New Mexico

Los Alamos National Laboratory is a United States Department of Energy national laboratory initially organized during World War II for the design of nuclear weapons as part of the Manhattan Project. It is located a short distance northwest of Santa Fe, New Mexico, in the southwestern United States.

Lawrence Livermore National Laboratory Federal research institute in Livermore, California, United States

Lawrence Livermore National Laboratory (LLNL) is a federal research facility in Livermore, California, United States, founded by the University of California, Berkeley in 1952. Originally a branch of the Lawrence Berkeley National Laboratory, the Lawrence Livermore laboratory became autonomous in 1971 and was designated a national laboratory in 1981.

United States Department of Energy Cabinet-level department of the United States government concerned with U.S. policies regarding energy and safety in handling nuclear material

The United States Department of Energy (DOE) is a cabinet-level department of the United States Government concerned with the United States' policies regarding energy and safety in handling nuclear material. Its responsibilities include the nation's nuclear weapons program, nuclear reactor production for the United States Navy, energy conservation, energy-related research, radioactive waste disposal, and domestic energy production. It also directs research in genomics; the Human Genome Project originated in a DOE initiative. DOE sponsors more research in the physical sciences than any other U.S. federal agency, the majority of which is conducted through its system of National Laboratories. The agency is administered by the United States Secretary of Energy, and its headquarters are located in Southwest Washington, D.C., on Independence Avenue in the James V. Forrestal Building, named for James Forrestal, as well as in Germantown, Maryland.

Nevada Test Site United States Department of Energy reservation located in southeastern Nye County, Nevada

The Nevada National Security Site, known as the Nevada Test Site (NTS) until August 23, 2010, is a United States Department of Energy (DoE) reservation located in southeastern Nye County, Nevada, about 65 miles (105 km) northwest of the city of Las Vegas. Formerly known as the Nevada Proving Grounds, the site was established on January 11, 1951 for the testing of nuclear devices, covering approximately 1,360 square miles (3,500 km2) of desert and mountainous terrain. Nuclear weapons testing at the Nevada Test Site began with a 1-kiloton-of-TNT (4.2 TJ) bomb dropped on Frenchman Flat on January 27, 1951. Over the subsequent four decades, over one thousand nuclear explosions were detonated at the NTS. Many of the iconic images of the nuclear era come from the NTS. NNSS is operated by Mission Support and Test Services, LLC.


In economics, the words cargo and freight refer in particular to goods or produce being conveyed—generally for commercial gain—by water, air or land. Cargo was originally a shipload. Cargo now covers all types of freight, including that carried by rail, van, truck, or intermodal container. The term cargo is also used in case of goods in the cold-chain, because the perishable inventory is always in transit towards a final end-use, even when it is held in cold storage or other similar climate-controlled facility. The term freight is commonly used to describe the movements of flows of goods being transported by any mode of transportation.

Nunn–Lugar Cooperative Threat Reduction

As the collapse of the Soviet Union appeared imminent, the United States and their NATO allies grew concerned of the risk of nuclear weapons held in the Soviet republics falling into enemy hands. The Cooperative Threat Reduction (CTR) Program was an initiative housed within the Defense Threat Reduction Agency (DTRA). The CTR program is better known as the Nunn–Lugar Act based on the Soviet Nuclear Threat Reduction Act of 1991 which was authored and cosponsored by Sens. Sam Nunn (D-GA) and Richard Lugar (R-IN). This Act was created in 1986 in a congressional meeting. According to the CTR website, "the purpose of the CTR Program is to secure and dismantle weapons of mass destruction and their associated infrastructure in former Soviet Union states." An alternative explanation of the program is "to secure and dismantle weapons of mass destruction in states of the former Soviet Union and beyond".

Idaho National Laboratory

Idaho National Laboratory (INL) is one of the national laboratories of the United States Department of Energy and is managed by the Battelle Energy Alliance. While the laboratory does other research, historically it has been involved with nuclear research.

Savannah River Site

The Savannah River Site (SRS) is a nuclear reservation in the United States in the state of South Carolina, located on land in Aiken, Allendale, and Barnwell counties adjacent to the Savannah River, 25 miles (40 km) southeast of Augusta, Georgia. The site was built during the 1950s to refine nuclear materials for deployment in nuclear weapons. It covers 310 square miles (800 km2) and employs more than 10,000 people.

Y-12 National Security Complex US Energy Dept facility in Oak Ridge, Tennessee

The Y-12 National Security Complex is a United States Department of Energy National Nuclear Security Administration facility located in Oak Ridge, Tennessee, near the Oak Ridge National Laboratory. It was built as part of the Manhattan Project for the purpose of enriching uranium for the first atomic bombs. It is considered the birthplace of the atomic bomb. In the years after World War II, it has been operated as a manufacturing facility for nuclear weapons components and related defense purposes.

The Nuclear Emergency Support Team (NEST), formerly known as the Nuclear Emergency Search Team, is a team of scientists, technicians, and engineers operating under the United States Department of Energy's National Nuclear Security Administration (NNSA). Their task is to be "prepared to respond immediately to any type of radiological accident or incident anywhere in the world".

The Reliable Replacement Warhead (RRW) was a proposed new American nuclear warhead design and bomb family that was intended to be simple, reliable and to provide a long-lasting, low-maintenance future nuclear force for the United States. Initiated by the United States Congress in 2004, it became a centerpiece of the plans of the National Nuclear Security Administration (NNSA) to remake the nuclear weapons complex.

Defence Nuclear Material Transport Operations refer to the movements of military Defence Nuclear Materials (DNM) within, to and from the United Kingdom. Defence Nuclear Material Transport Operations are also known as DNM Transportation; Defence Nuclear Material in transit; Nuclear movements; and DNM movements.

The United States Munitions List (USML) is a list of articles, services, and related technology designated as defense and space-related by the United States federal government. This designation is pursuant to sections 38 and 47(7) of the Arms Export Control Act. These articles fall under the export and temporary import jurisdiction of the Department of State.

Sector Commander is the position title of the commanding officer of a United States Coast Guard Sector, usually of the rank of Captain (O-6). The Sector Commander's second-in-command is the Deputy Sector Commander. Also reporting directly to the Sector Commander are the Command Master Chief (CMC), the Senior Reserve Officer, and the Sector's Auxiliary Coordinator.

Federal law enforcement in the United States Wikipedia list article

The federal government of the United States empowers a wide range of law enforcement agencies to maintain law and public order related to matters affecting the country as a whole.

National Nuclear Security Administration United States federal government agency

The National Nuclear Security Administration (NNSA) is a United States federal agency responsible for safeguarding national security through the military application of nuclear science. NNSA maintains and enhances the safety, security, and effectiveness of the U.S. nuclear weapons stockpile without nuclear explosive testing; works to reduce the global danger from weapons of mass destruction; provides the United States Navy with safe and effective nuclear propulsion; and responds to nuclear and radiological emergencies in the United States and abroad.

Radiation Portal Monitor

Radiation Portal Monitors (RPMs) are passive radiation detection devices used for the screening of individuals, vehicles, cargo or other vectors for detection of illicit sources such as at borders or secure facilities. Fear of terrorist attacks with radiological weapons spurred RPM deployment for cargo scanning since 9/11, particularly in the United States.

Safeguards Transporter

A Safeguards Transporter (SGT) is a truck developed for and used by the National Nuclear Security Administration (NNSA), a semi-autonomous affiliate agency of the United States Department of Energy, for the ground transport of nuclear weapons in the contiguous United States. SGTs' trailers are known as Safe Secure Trailers (SST).

The Federal Protective Forces are paramilitary forces of the United States Department of Energy (DOE) responsible for the protection of Category I special nuclear material. Though officially classified as security police, they have law enforcement authority, under section 161k of the Atomic Energy Act of 1954, while engaged in the performance of official duties. Officers are equipped and trained to respond to serious incidents at Department of Energy facilities by armed adversaries and to reacquire stolen nuclear material. The FPFs have been described, by the DOE, as "elite fighting forces" designed to operate in "combat environments".


  1. James Brooke (December 19, 1996). "Road Mishap Puts a Focus On Shipments Of A-Bombs". New York Times.
  2. 1 2 Adam Weinstein (Feb 15, 2012). "Nuclear Weapons on a Highway Near You; Big rigs with bombs are secretly cruising America's interstates. But how safe are they from terrorists or accidents?". Mother Jones. (Note: published in the May/June 2012 issue of Mother Jones magazine, pg. 5)
  3. Ralph Vartabedian and W.J. Hennigan (Mar 10, 2017). "This troubled, covert agency is responsible for trucking nuclear bombs across America each day". Los Angeles Times.