Condensing boiler

Last updated

Condensing boilers are water heaters typically used for heating systems that are fueled by gas or oil. When operated in the correct circumstances, a heating system can achieve high efficiency (greater than 90% on the higher heating value) by condensing water vapour found in the exhaust gases in a heat exchanger to preheat the circulating water. This recovers the latent heat of vaporisation, which would otherwise have been wasted. The condensate is sent to a drain. In many countries, the use of condensing boilers is compulsory or encouraged with financial incentives.

Contents

For the condensation process to work properly, the return temperature of the circulating water must be around 55 °C (131 °F) or below, so condensing boilers are often run at lower temperatures, around 70 °C (158 °F) or below, which can require larger pipes and radiators than non condensing boilers. Nevertheless, even partial condensing is more efficient than a traditional non-condensing boiler.

Operational principle

In a conventional boiler, fuel is burned and the hot gases produced pass through a heat exchanger where much of their heat is transferred to water, thus raising the water's temperature.

One of the hot gases produced in the combustion process is water vapour (steam), which arises from burning the hydrogen content of the fuel. A condensing boiler extracts additional heat from the waste gases by condensing this water vapour to liquid water, thus recovering its latent heat of vaporization. A typical increase of efficiency can be as much as 10-12%.[ citation needed ] While the effectiveness of the condensing process varies depending on the temperature of the water returning to the boiler, it is always at least as efficient as a non-condensing boiler.

The condensate produced is slightly acidic (3-5 pH), so suitable materials must be used in areas where liquid is present. Aluminium alloys and stainless steel are most commonly used at high temperatures. In low temperature areas, plastics are most cost effective (e.g., uPVC and polypropylene). [1] The production of condensate also requires the installation of a heat exchanger condensate drainage system. In a typical installation, this is the only difference between a condensing and non-condensing boiler.

To economically manufacture a condensing boiler's heat exchanger (and for the appliance to be manageable at installation), the smallest practical size for its output is preferred. This approach has resulted in heat exchangers with high combustion side resistance, often requiring the use of a combustion fan to move the products through narrow passageways. This has also had the benefit of providing the energy for the flue system as the expelled combustion gases are usually below 100 °C (212 °F) and as such, have a density close to air, with little buoyancy. The combustion fan helps to pump exhaust gas to the outside.

Usage

Condensing boilers are now largely replacing earlier, conventional designs in powering domestic central heating systems in Europe and, to a lesser degree, in North America. The Netherlands was the first country to adopt them broadly. [2]

Efficiency

Condensing boiler manufacturers claim that up to 98% thermal efficiency can be achieved, [3] compared to 70%-80% with conventional designs (based on the higher heating value of fuels). Typical models offer efficiencies around 90%, which brings most brands of condensing gas boiler in to the highest available categories for energy efficiency.[ citation needed ] In the UK, this is a SEDBUK (Seasonal Efficiency of Domestic Boilers in the UK) [4] Band A efficiency rating, while in North America they typically receive an Eco Logo and/or Energy Star Certification.

Boiler performance is based on the efficiency of heat transfer and highly dependent on boiler size/output and emitter size/output. System design and installation are critical. Matching the radiation to the Btu/Hr output of the boiler and consideration of the emitter/radiator design temperatures determines the overall efficiency of the space and domestic water heating system.

One reason for an efficiency drop is because the design and/or implementation of the heating system gives return water (heat transfer fluid) temperatures at the boiler of over 55 °C (131 °F), which prevents significant condensation in the heat exchanger. [5] Better education of both installers and owners could be expected to raise efficiency towards the reported laboratory values. Natural Resources Canada [6] also suggests ways to make better use of these boilers, such as combining space and water heating systems. Some boilers (e.g. Potterton) can be switched between two flow temperatures such as 63 °C (145 °F) and 84 °C (183 °F), only the former being "fully condensing." However, boilers are normally installed with higher flow temperature by default because a domestic hot water cylinder is generally heated to 60 °C (140 °F), and this takes too long to achieve with a flow temperature only three degrees higher. Nevertheless, even partial condensing is more efficient than a traditional boiler.

Most non-condensing boilers could be forced to condense through simple control changes. Doing so would reduce fuel consumption considerably, but would quickly destroy any mild steel or cast-iron components of a conventional high-temperature boiler due to the corrosive nature of the condensate. For this reason, most condensing boiler heat-exchangers are made from stainless steel or aluminum/silicon alloy. External stainless steel economizers can be retrofitted to non-condensing boilers to allow them to achieve condensing efficiencies. Temperature control valves are used to blend hot supply water into the return to avoid thermal shock or condensation inside of the boiler.

The lower the return temperature to the boiler the more likely it will be in condensing mode. If the return temperature is kept below approximately 55 °C (131 °F), the boiler should still be in condensing mode making low temperature applications such as radiant floors and even old cast iron radiators a good match for the technology.

Most manufacturers of new domestic condensing boilers produce a basic "fit all" control system that results in the boiler running in condensing mode only on initial heat-up, after which the efficiency drops off. This approach should still exceed that of older models (see the following three documents published by the Building Research Establishment: Information Papers 10-88 and 19-94; General Information Leaflet 74; Digest 339. See also Application Manual AM3 1989: Condensing Boilers by Chartered Institution of Building Services Engineers). By way of contrast Weather compensation systems are designed to adjust the system based on inside, outside, boiler inlet, and boiler outlet temperatures.

Heat pumps are potentially three times more efficient than condensing boilers. [7]

Control

The control of the domestic condensing boiler is crucial to ensuring that it operates in the most economic and fuel efficient way. The burners are usually controlled by an embedded system with built-in logic to control the output of the burner to match the load and give best performance.

Almost all have modulating burners. These allow the power to be reduced to match the demand. Boilers have a turndown ratio which is the ratio of the maximum power output to the minimum power output for which combustion can be maintained. If the control system determines that the demand falls below the minimum power output, then the boiler will cycle off until the water temperature has fallen, and then will reignite and heat the water.

Reliability

Condensing boilers are claimed to have a reputation for being less reliable and may also suffer if worked on by installers and plumbers who may not understand their operation. [8] Claims of unreliability have been contradicted by research carried out by the UK-based Building Research Establishment (see Building Research Establishment).

In particular, the problem of 'pluming' arose with early installations of condensing boilers, in which a white plume of condensed vapour (as minuscule droplets) becomes visible at the outlet flue. Although unimportant to boiler operation, visible pluming was an aesthetic issue that caused much opposition to condensing boilers.

A more significant issue is the slight (pH 3-4) acidity of the condensate liquid. Where this is in direct contact with the boiler's heat exchanger, particularly for thin aluminium sheet, it may give rise to more rapid corrosion than for traditional non-condensing boilers. Older boilers may also have used thick cast heat exchangers, rather than sheet, which had slower time constants for their response but were also resistant, by their sheer mass, to any corrosion. The acidity of the condensate means that only some materials may be used: stainless steel and aluminium are suitable, mild steel, copper or cast iron are not. [9] Poor design or construction standards may have made the heat exchangers of some early condensing boilers less long-lived.

Initial testing and annual monitoring of the heat transfer fluid in condensing boilers with aluminium or stainless steel heat exchangers is highly recommended. Maintenance of a slightly alkaline (pH 8 to 9) liquid with anti-corrosion and buffering agents reduces corrosion of the aluminium heat exchanger. Some professionals believe that the condensate produced on the combustion side of the heat exchanger may corrode an aluminium heat exchanger and shorten boiler life. Statistical evidence is not yet available since condensing boilers with aluminium heat exchangers have not been in use long enough.[ citation needed ]

Building Research Establishment

The Building Research Establishment, which is the UK's major research body for the building industry, produced a leaflet on domestic condensing boilers. According to the Building Research Establishment:

Exhaust

The condensate expelled from a condensing boiler is acidic, with a pH between 3 and 4. Condensing boilers require a drainpipe for the condensate produced during operation. This consists of a short length of polymer pipe with a vapour trap to prevent exhaust gases from being expelled into the building. The acidic nature of the condensate may be corrosive to cast iron plumbing, waste pipes and concrete floors but poses no health risk to occupants. A neutralizer, typically consisting of a plastic container filled with marble or limestone aggregate or "chips" (alkaline) can be installed to raise the pH to acceptable levels. If a gravity drain is not available, then a small condensate pump must also be installed to lift it to a proper drain.

The primary and secondary heat exchangers are constructed of materials that will withstand this acidity, typically aluminum or stainless steel. Since the final exhaust from a condensing boiler has a lower temperature than the exhaust from an atmospheric boiler 38 °C (100 °F) vs. 204 °C (400 °F) a mechanical fan is always required to expel it, with the additional benefit of allowing the use of low-temperature exhaust piping (typically PVC in domestic applications) without insulation or conventional chimney requirements. Indeed, the use of conventional masonry chimney, or metal flue is specifically prohibited due to the corrosive nature of the flue products, with the notable exception of specially rated stainless steel and aluminum in certain models. The preferred/common vent material for most condensing boilers available in North America is PVC, followed by ABS and CPVC. Polymer venting allows for the added benefit of flexibility of installation location including sidewall venting saving unnecessary penetrations of the roof.

Cost

Condensing boilers are up to 50% more expensive to buy and install than conventional types in the UK and the US. However, as of 2006, at UK prices the extra cost of installing a condensing instead of conventional boiler should be recovered in around 2–5 years through lower fuel use (for verification, see the following three documents published by the Building Research Establishment: Information Papers 10-88 and 19-94; General Information Leaflet 74; Digest 339; see also Case studies in Application Manual AM3 1989: Condensing Boilers by Chartered Institution of Building Services Engineers), and 2–5 years[ citation needed ] at US prices. Exact figures will depend on the efficiency of the original boiler installation, boiler utilisation patterns, the costs associated with the new boiler installation, and how frequently the system is used. The cost of these boilers is dropping as the mass takeup enforced by government takes effect and the manufacturers withdraw older, less efficient models, but production cost is higher than older types as condensing boilers are more complex.

The increased complexity of condensing boilers is as follows:

With respect to modern boilers, there are no other differences between condensing and non-condensing boilers.

Reliability, as well as initial cost and efficiency, affects total cost of ownership. One major independent UK firm of plumbers stated in 2005 that it had made thousands of call-outs to mend condensing boilers, and that the greenhouse gas emissions from its vans were probably greater than the savings made by the shift to eco-conscious boilers. [8] However, the same article points out that the Heating and Hotwater Information Council, together with some installers, have found that modern condensing boilers are just as reliable as standard boilers.

Phase out

The phase-out of gas boilers is a set of policies to remove the use of fossil gas (or "natural gas") from the heating of buildings and use in appliances. Typically gas is used to heat water, for showering, or central heating. In many countries, gas heating is one of the major contributors to greenhouse gas emissions and climate damage, leading a growing number of countries to introduce bans. Air source heat pumps are the main alternative. [11]

The International Energy Agency has said that new gas boilers should be banned no later than 2025. [12] Many installations and appliances have a life-span of 25 years, leading for calls that the bans must take place immediately, or at latest by 2025, because otherwise targets of net zero by 2050 cannot or are unlikely to be reached. [13] However fossil fuels lobbyists are resisting phase-out. [14]

See also

Related Research Articles

<span class="mw-page-title-main">Boiler</span> Closed vessel in which fluid is heated

A boiler is a closed vessel in which fluid is heated. The fluid does not necessarily boil. The heated or vaporized fluid exits the boiler for use in various processes or heating applications, including water heating, central heating, boiler-based power generation, cooking, and sanitation.

<span class="mw-page-title-main">Furnace (central heating)</span> Device used for heating buildings

A furnace, referred to as a heater or boiler in British English, is an appliance used to generate heat for all or part of a building. Furnaces are mostly used as a major component of a central heating system. Furnaces are permanently installed to provide heat to an interior space through intermediary fluid movement, which may be air, steam, or hot water. Heating appliances that use steam or hot water as the fluid are normally referred to as a residential steam boilers or residential hot water boilers. The most common fuel source for modern furnaces in North America and much of Europe is natural gas; other common fuel sources include LPG, fuel oil, wood and in rare cases coal. In some areas electrical resistance heating is used, especially where the cost of electricity is low or the primary purpose is for air conditioning. Modern high-efficiency furnaces can be up to 98% efficient and operate without a chimney, with a typical gas furnace being about 80% efficient. Waste gas and heat are mechanically ventilated through either metal flue pipes or polyvinyl chloride (PVC) pipes that can be vented through the side or roof of the structure. Fuel efficiency in a gas furnace is measured in AFUE.

<span class="mw-page-title-main">Chimney</span> Ventilation for hot gases or smoke

A chimney is an architectural ventilation structure made of masonry, clay or metal that isolates hot toxic exhaust gases or smoke produced by a boiler, stove, furnace, incinerator, or fireplace from human living areas. Chimneys are typically vertical, or as near as possible to vertical, to ensure that the gases flow smoothly, drawing air into the combustion in what is known as the stack, or chimney effect. The space inside a chimney is called the flue. Chimneys are adjacent to large industrial refineries, fossil fuel combustion facilities or part of buildings, steam locomotives and ships.

<span class="mw-page-title-main">Fluidized bed combustion</span> Technology used to burn solid fuels

Fluidized bed combustion (FBC) is a combustion technology used to burn solid fuels.

<span class="mw-page-title-main">Water heating</span> Thermodynamic process that uses energy sources to heat water

Water heating is a heat transfer process that uses an energy source to heat water above its initial temperature. Typical domestic uses of hot water include cooking, cleaning, bathing, and space heating. In industry, hot water and water heated to steam have many uses.

<span class="mw-page-title-main">Combined cycle power plant</span> Assembly of heat engines that work in tandem from the same source of heat

A combined cycle power plant is an assembly of heat engines that work in tandem from the same source of heat, converting it into mechanical energy. On land, when used to make electricity the most common type is called a combined cycle gas turbine (CCGT) plant. The same principle is also used for marine propulsion, where it is called a combined gas and steam (COGAS) plant. Combining two or more thermodynamic cycles improves overall efficiency, which reduces fuel costs.

<span class="mw-page-title-main">Cogeneration</span> Simultaneous generation of electricity and useful heat

Cogeneration or combined heat and power (CHP) is the use of a heat engine or power station to generate electricity and useful heat at the same time.

<span class="mw-page-title-main">Central heating</span> Type of heating system

A central heating system provides warmth to a number of spaces within a building from one main source of heat. It is a component of heating, ventilation, and air conditioning systems, which can both cool and warm interior spaces.

<span class="mw-page-title-main">Recuperator</span>

A recuperator is a special purpose counter-flow energy recovery heat exchanger positioned within the supply and exhaust air streams of an air handling system, or in the exhaust gases of an industrial process, in order to recover the waste heat. Generally, they are used to extract heat from the exhaust and use it to preheat air entering the combustion system. In this way they use waste energy to heat the air, offsetting some of the fuel, and thereby improve the energy efficiency of the system as a whole.

<span class="mw-page-title-main">Fire-tube boiler</span> Type of boiler

A fire-tube boiler is a type of boiler invented in 1828 by Mark Seguin, in which hot gases pass from a fire through one or more tubes running through a sealed container of water. The heat of the gases is transferred through the walls of the tubes by thermal conduction, heating the water and ultimately creating steam.

<span class="mw-page-title-main">Thermal power station</span> Power plant that generates electricity from heat energy

A thermal power station is a type of power station in which heat energy is converted to electrical energy. In a steam-generating cycle heat is used to boil water in a large pressure vessel to produce high-pressure steam, which drives a steam turbine connected to an electrical generator. The low-pressure exhaust from the turbine enters a steam condenser where it is cooled to produce hot condensate which is recycled to the heating process to generate more high pressure steam. This is known as a Rankine cycle.

<span class="mw-page-title-main">Pellet stove</span> Stove that uses pellet fuel

A pellet stove is a stove that burns compressed wood or biomass pellets to create a source of heat for residential and sometimes industrial spaces. By steadily feeding fuel from a storage container (hopper) into a burn pot area, it produces a constant flame that requires little to no physical adjustments. Today's central heating systems operated with wood pellets as a renewable energy source can reach an efficiency factor of more than 90%.

<span class="mw-page-title-main">Condensing steam locomotive</span> Type of locomotive designed to recover exhaust steam

A condensing steam locomotive is a type of locomotive designed to recover exhaust steam, either in order to improve range between taking on boiler water, or to reduce emission of steam inside enclosed spaces. The apparatus takes the exhaust steam that would normally be used to produce a draft for the firebox, and routes it through a heat exchanger, into the boiler water tanks. Installations vary depending on the purpose, design and the type of locomotive to which it is fitted. It differs from the usual closed cycle condensing steam engine, in that the function of the condenser is primarily either to recover water, or to avoid excessive emissions to the atmosphere, rather than maintaining a vacuum to improve both efficiency and power.

<span class="mw-page-title-main">Steam-electric power station</span>

The steam-electric power station is a power station in which the electric generator is steam driven. Water is heated, turns into steam and spins a steam turbine which drives an electrical generator. After it passes through the turbine, the steam is condensed in a condenser. The greatest variation in the design of steam-electric power plants is due to the different fuel sources.

Economizers, or economisers (UK), are mechanical devices intended to reduce energy consumption, or to perform useful function such as preheating a fluid. The term economizer is used for other purposes as well. Boiler, power plant, heating, refrigeration, ventilating, and air conditioning (HVAC) uses are discussed in this article. In simple terms, an economizer is a heat exchanger.

<span class="mw-page-title-main">Forced-air gas</span>

Forced-air gas heating systems are used in central air heating/cooling systems for houses. Sometimes the system is referred to as "forced hot air".

An electric boiler is a device that uses electrical energy to boil water. It is different than a gas or oil boiler because an electric boiler uses electricity instead of fossil fuels.

<span class="mw-page-title-main">Wood-burning stove</span> Type of stove

A wood-burning stove is a heating or cooking appliance capable of burning wood fuel, often called solid fuel, and wood-derived biomass fuel, such as sawdust bricks. Generally the appliance consists of a solid metal closed firebox, often lined by fire brick, and one or more air controls. The first wood-burning stove was patented in Strasbourg in 1557. This was two centuries before the Industrial Revolution, so iron was still prohibitively expensive. The first wood-burning stoves were high-end consumer items and only gradually became used widely.

Flue gas condensation is a process, where flue gas is cooled below its water dew point and the heat released by the resulting condensation of water is recovered as low temperature heat.

<span class="mw-page-title-main">Rocket mass heater</span> Type of heating system

A rocket mass heater (RMH), also known as rocket stove mass heater, is a form of slow-release radiant heating system, designed to primarily heat people and secondarily to warm areas in line of sight around it. Variations of RMH can also be extended for the functions of cooking, heating water, and producing warm air for distribution.

References

  1. Day, Anthony; et al. (2003). "Flues for condensing boilers". Heating systems: plant and control . Oxford, England: Blackwell. p.  161. ISBN   0-632-05937-0.
  2. "Application of condensing boilers in the Netherlands". Archived from the original on 15 April 2014. Retrieved 30 September 2012.
  3. Viessmann Gas Fired Boilers
  4. Sedbuk
  5. "Carbon Trust Micro-CHP Accelerator". Archived from the original on 28 March 2014. Retrieved 18 July 2012.
  6. Office of Energy Efficiency, Natural Resources Canada Archived 23 February 2006 at the Wayback Machine
  7. "Heat pumps shown to be three times more efficient than gas boilers".
  8. 1 2 Guardian newspaper: The new boiler that's causing a heated row. 2 April 2005
  9. Jason R. Funk. "Boiler Basics" (PDF). Hughes Machinery. pp. 50–51. Archived from the original (PDF) on 21 April 2016. Retrieved 7 April 2016.
  10. "GIL74 - Domestic Condensing Boilers: the benefits and the myths". Building Research Establishment. Archived from the original on 2 October 2016. Retrieved 28 September 2016.
  11. "Heat pumps show how hard decarbonisation will be". The Economist. ISSN   0013-0613 . Retrieved 14 September 2023.
  12. Net zero by 2050 (May 2021) IEA
  13. EU Commission paralysis delays phase-out of fossil fuel boilers (7 July 2021) Cool Products
  14. https://www.politico.eu/article/energy-fossil-fuels-parliament-vote-on-greening-buildings-gives-lifeline-to-gas-boiler-industry/amp/